Chemical composition of Bombay ducks (Harpodon nehereus) and changes occurring in the nutritive value of dried Bombay ducks on storage

Fresh Bombay ducks and Bombay ducks dried (a) without any pre-treatment or (b) after brining with NaCl solutions of 15% and 7.5% concentrations for 18 hours were analyzed for moisture, ash, minerals, vitamins, fat, free fatty acids, peroxide value, thiobarbituric acid value, total protein, total amino nitrogen, soluble proteins and trimethylamine contents. All the dried samples were stored in (a) tightly closed tin containers or (b) polythene bags and analyzed for the above mentioned constituents every 1½ months. It was observed that brining did not exercise any marked influence on keeping properties. Organoleptic observations showed that fish stored in tin containers kept better and longer than those stored in polythene bags.

Surimi based dried fish cake

Minced fish prepared from the fillets of the sciaenid fish (Lutjanus sp.) was washed with cold water (<10 °C) three times. The washed muscle was pressed through a piece of fine cloth to a moisture content around 80%. The pressed cake (Surimi) was ground with 2.5% sodium chloride and 3% tapioca starch. The mixed material was shaped in the form of a cake and left for one hour for the gel to set. The cakes were then steamed. The cooled cakes were cut into pieces of 1 cm length x 1 cm width x 0.5 cm thick. The pieces were either dried in an electrical oven at 50°C or dried in sun to a moisture content of 11-12%. Biochemical, bacteriological and organoleptic evaluation revealed that the cakes were in very good acceptable form for 8 months. The cakes could be rehydrated by soaking in water at ambient temperature for half an hour and boiling in water for 10 minutes.

Quality aspects of some exportable dried fishery products of Bangladesh

A study was conducted to evaluate the quality aspects of eight exportable dried fishery products of Bangladesh. The products were evaluated by examining organoleptic properties, water reconstitution behavior, microbiological and biochemical aspects. The water reconstitution rate was faster in ribbon fish and Bombay duck, and slower in other fishes and air bladder and shark fin products. Organoleptic and physical characteristics in respect of color, odor, texture, insect infestation and broken pieces of the products revealed that all of the products were either in excellent or acceptable condition. Total viable bacterial load ranged from 0.95 x 104 CFU/g to 1.8 x 104 CFU/g in dried products. Coliform bacteria was absent in all the dried fishery products. The results of moisture, crude protein, lipid and ash content of the products ranged from 16.20 to 23.51%, 58.37 to 82.86%, 0.17 to 14.44% and 0.58 to 9.23%, respectively. Non-protein nitrogen (NPN) contents were in the range of 0.104 to 2.372% and the pepsin digestibility values were of 88.41 to 94.23%. The results of the study suggested that the exportable dried products were of good quality and hygienically safe.

Dried fish cakes with improved texture

To overcome the problem of underutilization of marine by-catches, Basu et al. (1985) developed fish cube from minced fish meat. Although the product was acceptable, it had little rubbery texture. An attempt was made to improve the texture of the cake by several methods. It was found that 5% tapioca starch along with 3% texturised soybean protein improved the texture and juiciness of the rehydrated product. Preheating of the minced meat at 70°C for 30 minutes also improved the texture appreciably. It was also found that mixing of the ingredients at low speed (less than 100 rpm) in a dough mixer gave the best texture, higher speed and sharp blades leading to rubbery texture. The dehydrated product (moisture 19-20%) thus prepared had a shelf life of six months at ambient temperature.

Storage characteristics of solar-dried Indian mackerel

Fresh Rastrelliger kanagurta (Indian mackerel) was thoroughly washed, eviscerated, cleaned and salted overnight with dry salt (fish : salt :: 5:1). Salted mackerel was dried in solar drier and on cement floor under direct sun for three days. The temperature inside the drier was 948°C higher than the ambient temperature. The rate of drying was higher in solar drier than on cement floor. The dried fish packed in 300-gauge polythene bags was subjected to biochemical, microbiological and organoleptic evaluation at regular intervals to assess the storage life. The overall quality of fish dried in solar drier was better than that of the fish dried on cement floor under direct sun.

Studies on the preparation of fish silage. 3. Dried silage products

An investigation was undertaken on the production of dried products from silver belly (Leiognathus splendens) silage mixed with plant filter materials. Silages produced using hydrochloric acid and/or formic acid when mixed with rice bran or maize meal and dried, yielded powders having an acceptable appearance and a pleasant odour, which are suitable for use in compounded chicken feeds.

Keeping quality of imported dried fish

All imported salted, dried fish samples tested had a salt content below 30% and above 12% and hence met requirements of the proposed standard. Also samples without quality cut tested had a greater salt content than that with quality cut. This indicates that salt contributes to protecting dried fish and hence may be endorsed by sensory evaluation to a certain extent. Samples with quality cut had more moisture than that without quality cut. But all samples with and without quality cut had a moisture content greater than 35% which is the maximum moisture content for such species specified in the standard. Microbiological testing for total counts and Coliform contents too showed that good quality dried fish had counts greater than that specified in the standard. The different species of fish tested had varying lengths of shelf life. But on an average the shelf life of dried fish could be prolonged for about 12 days by re-drying at 45°C for 6 hours, i.e., re-drying at these temperatures without subsequent packing in polythene bags may not be practical for prolonging the storage life of salted/dried fish.

Increase of storage shelf life of locally produced salted/dried fish by redrying and/or packeting

Experiments were undertaken to prolong the storage life of salted/dried fish by re-drying and/or packing. The storage life under normal conditions is 51 days; re-drying the fish at 50°C for 12 hours extends the storage life only by 7 days. However, re-drying and packing gizzard shad (Gonialosa manminna ) in polyethylene maintains the fish in excellent conditions for well over 87 days. The use of air tight bags for storing good quality salted dried fish is recommended.

A preliminary study on the keeping quality of locally produced marine and freshwater salted dried fish

Experiments were conducted on the storage life of salted dried fish from both freshwater and marine species. It was found that the storage life of salted dried products from the 2 freshwater species tested (Ompok bimaculatus and Labeo dussumieri) is much longer than that of the 2 marine species (Gonialosa manminna and Chorinemus lysan), i.e., 51 days.

Shelf life of dried products from small indigenous fish species under various packing and storage conditions

The overall quality of five SIS products was found in good condition up to 2 months storage on the basis of organoleptic, biochemical and bacteriological characteristics and all the products was excellent in sealed packed condition up to 45 days of storage. However, quality of the products stored in open air atmospheric temperature was found excellent for first 15 days. In an average the initial moisture content was in the range of 13.5 to 15.0% with highest moisture content in puti and lowest in chapila. At the end of the 60 days the moisture content reached to the range of 18.5 to 19.0% which was more or less near the recommended limit of 16% for dried fishery products. The moisture content beyond the recommended limit as the storage period increased further and at the end of 90 days the moisture content increased to the range of 22.9 to 24% when organoleptically the product quality became very poor. The changes in the value of total volatile base nitrogen (TVB-N), peroxide value (PO), moisture and aerobic plate count (APC) of solar tunnel dried products in sealed polythene packages were investigated during 60 days of storage. There was little or no differences in TVB-N, PO and bacterial load of each species packed under various polythene density. The initial TVB-N values were in the range of 10.30 to 12.40 mg/100g of the samples. TVB-N value increased slowly up to the end of the storage period and was to in the range of 46.20 to 57.00 mg/1 00 g of sample. Initially the peroxide values (P.O.) were in the range of 6.54 to 8.40 m.eq./kg oil of the samples. During 60 days of storage, P.O. values increased slowly and at the end of the storage period these values reached to the range of 22.00 to 25.30meq./kg of sample. The initial APC was in the range 5.3xl04-7.3x104 CFU/g. The bacterial load increased slowly and at the end of the 60 days storage period reached to the range 6.6x106 - 8.6x107 CFT/g.

A survey of pest (Dermestes maculatus) infestation of dried preserved Clarias gariepinus: its effect on nutrient quantity and quality

Studies on the nutrient composition of smoked-dried Clarias gariepinus were carried out, to assess the effects of pest infestation on the dried catfish from two different market (Abakpa and Kpirikpiri market) area in Abakaliki Metropolis, Ebonyi State, Nigeria. Fish samples from the two markets where kept for pest to infest it and it were taken to Biochemistry Laboratory of Food Science and Technology in Ebonyi State University to assess the damage of pest on dried catfish using standard methods. There was a significant different among the mean weight of fish from the two markets (Abakpa and kpirikpiri; 19.13kg and 18.98kg respectively) compared with the mean weight of the control 20.09kg. There was a variation in the proximate composition of the fishes from the two markets compared with the control, the decreases of the proximate composition are: crude protein from 60.07% to 40.27%; fat from 8.35% to 5.90%; moisture content from 11.67% to 10.67; fiber from 12.93 to 11.93; ash from 4.02% to 3.54% and carbohydrate 12.67% to 5.89%. The longer the storage periods of the infested smoked fish the more the tissue was degraded. Proper handling and storage of dried catfish are required to prolong the shelf life and nutrient content of dried catfish.

Quality assessment of rotating and solar tunnel dried marine fish product

Studies were conducted to evaluate the quality aspects of marine dried fish i.e. silver jew fish (Johnius argentatus), Bombay duck (Harpodon nehereus) and ribbon fish (Trichiums haumela) products produced in rotating and solar tunnel dryers. On the basis of organoleptic characteristics such as colour, odour, texture, broken pieces, insect infestation and overall quality, four member panels of experts evaluated the quality of the dried products obtained from both rotating and solar tunnel dryers and all the products were found in acceptable quality. Reconstitutions properties of samples were in the range of 51.05 to 98.75% for the dried fish produced in rotating dryer, while 24.64 to 76.76% for dried fish produced in solar tunnel dryer. The highest reconstitution rate was found in dried silver jew fish and lowest in ribbon fish produced in rotating dryer. On the other hand, the highest reconstitution was observed in dried silver jew fish and lowest in dried Bombay duck produced in solar tunnel dryer. Proximate composition such as moisture, crude protein, lipid and ash content of the dried fish muscles produced in rotating dryer ranged from 16.36% to 19.1%, 62.35% to 67.37%, 6.37% to 10.75% and 7.00% to 8.05%, respectively and in solar tunnel dried fish products, they were in the range of 14.05% to 19.71%,57.64% to 69. 21%,6.92% to 15.40%and 7.69% to 8.80 %, respectively. The TVBN values of dried fish products obtained from rotating dryer were in the range of 15.02 to 19.05 mg/100g, while in solar tunnel dried fish products, the values were in the range of 15.46 to 19.21 mg/100g. The results of the studies indicated that dried fish produced from both rotating and solar tunnel drier were acceptable quality in terms of organoleptic and food quality aspects.

Quality of fishmeal processed from sun-dried fish in a commercial fishmeal dryer

The physical and chemical compositions of the raw materials received and the composition and nutritive values of the finished products in a commercial size fish meal plant employing the dry rendering process were studied and reported in this paper.