Comparison of Ozone and Chlorine in Low Concentrations as Sanitizing Agents of Chicken Carcasses in the Water Immersion Chiller

The aim of this study was to investigate the effects of the use of chlorine or ozone as sanitizing agents in the water of chicken immersion chilling, using the residual levels usually applied in Brazil (1.5 ppm), comparing the effects of these treatments on the microbiological, physicochemical, and sensory characteristics of carcasses. Chicken carcasses were chilled in water (4 degrees C) with similar residual levels of ozone and chlorine until reaching temperatures below 7 degrees C (around 45 min). The stability of carcasses was assessed during 15 days of storage at 2 +/- 1 degrees C. Microbiological, surface color (L*, a*, b* parameters), pH value, lipid oxidation (thiobarbituric acid reactive substances index), and sensory evaluation (on a 9-point hedonic scale for odor and appearance) analyses were carried out. The presence of Salmonella was not detected, coagulase-positive staphylococci counts were below 10(2) CFU/ml of rinse fluid, and Escherichia coil and total coliform counts were below 10(5) CFU/ml of rinse fluid until the end of the storage period for both treatments. Psychrotrophic microorganism counts did not differ (P > 0.05) between chlorine and ozone treatments, and both values were near 10(9) CFU/ml of rinse fluid after 15 days at 4 +/- 1 degrees C. pH values did not differ between treatments (P > 0.05) or during the storage period (P > 0.05). In addition, neither chlorine nor ozone treatment showed differences (P > 0.05) in the lipid oxidation of carcasses; however, the thiobarbituric acid reactive substances index of both treatments increased (P <= 0.05) during the storage period, reaching values of approximately 0.68 mg of malonaldehyde per kg. Samples from both treatments did not differ (P > 0.05) in their acceptance scores for odor and overall appearance, but in the evaluation of color, ozone showed an acceptance score significantly higher (P <= 0.05) than that for the chlorine treatment. In general, under the conditions tested, ozone showed results similar to the results for chlorine in the disinfection of chicken carcasses in the immersion chilling, which may indicate its use as a substitute for chlorine in poultry slaughterhouses.

Gases and volatile compounds associated with micro-organisms in blown pack spoilage of Brazilian vacuum-packed beef

This study correlated the composition of the spoilage bacterial flora with the main gaseous and volatile organic compounds (VOCs) found in the package headspace of spoiled, chilled, vacuum-packed meat. Fifteen chilled, vacuum-packed beef samples, suffering from blown pack spoilage, were studied using 16S rRNA clone sequencing. More than 50% of the bacteria were identified as lactic acid bacteria (LAB), followed by clostridia and enterobacteria. Fifty-one volatile compounds were detected in the spoiled samples. Although the major spoilage compounds were identified as alcohols and aldehydes, CO2 was identified as the major gas in the spoiled samples by headspace technique. Different species of bacteria contribute to different volatile compounds during meat spoilage. LAB played an important role in blown pack deterioration of the Brazilian beef studied.

Effetto della temperatura di conservazione del latte, dalla raccolta all'affioramento, sulla microflora del latte, del sieroinnesto e del formaggio Trentingrana

This PhD research is part of a project addressed to improve the quality of Grana Trentino production. The objectives were to evaluated if milk storage and collection procedures may affect cheese-making technology and quality. Actually the milk is collected and delivered to the cheese factory just after milking in 50 L cans without refrigeration or in tanks cooled at 18 °C. This procedure is expensive (two deliveries each day) and the milk quality is difficult to preserve as temperatures are not controlled. The milk refrigeration at the farm could allow a single delivery to the dairy. Therefore it could be a good strategy to preserve raw milk quality and reduce cheese spoilage. This operation may, however, have the drawbacks of favouring the growth of psychrotrophic bacteria and changing the aptitude of milk to coagulation. With the aim of studying the effect on milk and cheese of traditional and new refrigerated technologies of milk storage, two different collection and creaming technologies were compared. The trials were replicated in three cheese factories manufacturing Grana Trentino. Every cheese-making day, about 1000 milk liters were collected from always the same two farms in the different collection procedures (single or double). Milk was processed to produce 2 wheels of Grana trentino every day. During the refrigerated trials, milk was collected and stored at the farm in a mixed tank at 12 or 8 °C and then was carried to the dairy in truck once a day. 112 cheese making day were followed: 56 for traditional technology and 56 for the refrigerated one. Each one of these two thechnologies lead to different ways of creaming: long time in the traditional one and shorter in the new one. For every cheese making day we recorded time, temperatures and pH during the milk processing to cheese. Whole milk before ceraming, cream and skim milk after creaming, vat milk and whey were sampled during every cheese-making day for analysis. After 18 months ripening we opened 46 cheese wheels for further chemical and microbiological analyses. The trials were performed with the aim of: 1 estimate the effect of storage temperatures on microbial communities, physico-chemical or/and rheological differences of milk and skim milk after creaming. 2 detect by culture dependent (plate counts) and indipendent (DGGE) methodolgies the microbial species present in whole, skimmed milk, cream and cheese sampled under the rind and in the core; 3 estimate the physico-chemical characteristics, the proteolytic activity, the content of free aminoacids and volatile compounds in 18 months ripened Grana Trentino cheeses from different storing and creaming of milk technologies. The results presented are remarkable since this is the first in-deep study presenting microbiological and chemical analysis of Grana Trentino that even if belonging to Grana Padano Consortium, it is clearly different in the milk and in the manufacturing technology.

Qualitatitive and quantitative analysis of fish spoilage processes for development of new food monitoring systems

This study investigates the growth and metabolite production of microorganisms causing spoilage of Atlantic cod (Gadus morhua) fillets packaged under air and modified atmosphere (60 % CO2, 40 % O2). Samples were provided by two different retailers (A and B). Storage of packaged fillets occurred at 4 °C and 8 °C. Microbiological quality and metabolite production of cod fillets stored in MAP 4 °C, MAP 8 °C and air were monitored during 13 days, 7 days and 3 days of storage, respectively. Volatile compounds concentration in the headspace were quantified by Selective ion flow tube mass spectrometry and a correlation with microbiological spoilage was studied. The onset of volatile compounds detection was observed to be mostly around 7 log cfu/g of total psychrotrophic count. Trimethylamine and dimethyl sulfide were found to be the dominant volatiles in all of the tested storage conditions, nevertheless there was no close correlation between concentrations of each main VOC and percentages of rejection based on sensory evaluation. According to results it was concluded that they cannot be considered as only indicators of the quality of cod fillets stored in modified atmosphere and air.  

Biomass and substrate utilization of cold adapted bacteria in Fram Strait and the Western Greenlad Sea

During the 'Polarstern' expedition ARK-IV/2 in June 1987, water samples from 8 stations were taken to study biomass and substrate utilization of cold adapted bacteria. Bacterial biomasses determined from acridine orange direct counts (AODC) were between 0.4 and 31.4 µ/g C/l, and ATP concentrations amounted from <0.1 to 40 ng/l. Colony counts on seawater agar reached only 0.1% of AODC, but with the MPN-method 1 to 10% of AODC were recorded. With 14C-glutamic acid or 14C-glucose as tracer substrate in oligotrophic broth containing 0.5 mg trypticase and 0.05 mg yeast extract per liter of seawater, obligately oligotrophic bacteria could be detected in one water sample. Although incubation was at 2 °C, only psychrotrophic bacteria showing growth temperatures between 1 and 30 °C were obtained. Organic substrate utilizations by 106 isolates were tested at 4 and 20 °C. Most carbohydrates, organic acids, alcohols, and alanine were assimilated at both temperatures, but arginine, aspartate and ornithine were utilized only at 20 °C by almost all strains.

Oligotrophic bacteria from the Antarctic Ocean

From enrichment cultures in dialysis chambers held in natural seawater tanks, 104 strains were isolated and kept in culture. All strains proved to be Gram-negative and psychrotrophic, having optimum growth temperatures of between 20 and 24 °C. Maximal growth temperatures were 30 to 37 °C, or even higher. With 55 isolates, substrate utilizations in Biolog MicroPlates were determined, and the obtained metabolic fingerprints used for clustering. Five groups could be distinguished at the 80% similarity level. Fifteen strains belonged to cluster 1, seven strains to cluster 2, and each of the clusters 3 and 4 contained nine strains. Cluster 5 can be divided into subcluster 5a and 5b, with 6 strains showing a few substrates metabolized, and 9 strains without any reactions, or weak reactions for one or two substrates, respectively. Each cluster could be characterized by specific metabolic fingerprints. Strains from cluster 1 metabolized N-acetyl-D-glucosamine, alpha-hydroxybutyric acid and gamma-hydroxybutyric acid, strains from cluster 2 citric acid, formic acid, thymidine and putrescine, strains from cluster 3 glycyl-L-aspartic acid, glycyl-L-glutamic acid, L-threonine and inosine, whereas strains from cluster 4 metabolized alpha-cyclodextrin and N-acetyl-D-galactosamine, typically. Methylamine was not utilized by the isolates, but strains from cluster 1, 2 and 3 could grow on basal seawater agar. Morphological characteristics and photomicrographs of the oligotrophic strains are presented. Due to their typical morphologies and ampicillin resistence, the nine strains from cluster 3 can be regarded as new species of the genus Planctomyces. These bacteria have not been cultivated before.

Avaliação da qualidade microbiológica, contagem de Pseudomonas spp, e sua importância durante a obtenção e armazenamento de leite cru refrigerado no período de seca e chuva

Na propriedade rural, onde o leite cru refrigerado fica armazenado até a captação pelo caminhão tanque em coleta a granel, o mesmo é mantido a temperatura de refrigeração entre 1 a 4ºC por longos períodos (até 96 horas), os microrganismos psicrotróficos encontram condições favoráveis para sua multiplicação, produzindo enzimas proteolíticas e lipolíticas termotolerantes, podendo provocar alterações indesejáveis no leite e nos seus derivados. Quando estes microrganismos estão presentes em elevadas populações, pode ser indicativo de baixa qualidade do leite e insatisfatória condições sanitárias para o processamento. Devido a necessidade da melhora da qualidade dos produtos lácteos, objetivou-se a execução desta pesquisa realizando levantamentos sobre o cumprimento dos padrões microbiológicos exigidos pela atual legislação brasileira IN 62 (BRASIL, 2011), pesquisas sobre os microrganismos psicrotróficos, Pseudomonas spp. e produção de enzimas proteolítica e lipolítica por Pseudomonas spp. As coletas foram realizadas em 10 propriedades do Estado de São Paulo na Regional Agrícola do Escritório de Desenvolvimento Rural - EDR Limeira - SP, sendo, 5 propriedades com ordenha manual e 5 propriedades com ordenha mecânica, nos períodos de chuva e seca e em vários pontos durante a obtenção do leite cru refrigerado e também do leite com intervalo de 24 horas até a captação deste leite pelo caminhão. As médias das populações dos microrganismos mesófilos na ordenha manual, foi diferente estatisticamente significativo no leite recém ordenhado (1,52×106 UFC.mL-1) para o leite com 24 horas de armazenamento (2,67×107 UFC.mL-1) no período chuvoso, e na ordenha mecânica, o encontrado foi uma diferença estatisticamente significativa no leite recém ordenhado (3,87×106 UFC.mL-1) para o leite com 24 horas de armazenamento (9,82×108 UFC.mL-1) também no período chuvoso. Nas populações dos microrganismos psicrotróficos, suas médias diferiram estatisticamente na ordenha manual no período da chuva no leite recém ordenhado (1,48×104 UFC.mL-1) para o leite com 48 horas de armazenamento (1,49×105 UFC.mL-1) e na ordenha mecânica, o leite recém ordenhado (8,74×103 UFC.mL-1), com 24 horas de armazenamento (4,33×104 UFC.mL-1) não diferiram entre si e foram diferentes estatisticamente do leite com 48 horas de armazenamento (3,46×105 UFC.mL-1) apresentaram valor elevado, principalmente quando o leite cru refrigerado permanece por longos períodos de armazenamento na propriedade rural, que pode ser um sério fator de comprometimento pela produção de lipases ou proteases principalmente pelas Pseudomonas spp. onde em todos os pontos amostrados foram isolados este microrganismo produzindo enzimas (lipase e/ou protease). A maior porcentagem de atividade lipolítica foi verificada no período seco, já a maior porcentagem de atividade proteolítica foi verificada no período chuvoso. Contudo, deve-se intensificar as medidas de autocontrole para minimizar os efeitos dos microrganismos mesófilos e psicrotróficos sobre a qualidade do leite cru refrigerado e, consequentemente, de seus derivados.

Origin and ecological selection of core and food-specific bacterial communities associated with meat and seafood spoilage

The microbial spoilage of meat and seafood products with short shelf lives is responsible for a significant amount of food waste. Food spoilage is a very heterogeneous process, involving the growth of various, poorly characterized bacterial communities. In this study, we conducted 16S ribosomal RNA gene pyrosequencing on 160 samples of fresh and spoiled foods to comparatively explore the bacterial communities associated with four meat products and four seafood products that are among the most consumed food items in Europe. We show that fresh products are contaminated in part by a microbiota similar to that found on the skin and in the gut of animals. However, this animal-derived microbiota was less prevalent and less abundant than a core microbiota, psychrotrophic in nature, mainly originated from the environment (water reservoirs). We clearly show that this core community found on meat and seafood products is the main reservoir of spoilage bacteria. We also show that storage conditions exert strong selective pressure on the initial microbiota: alpha diversity in fresh samples was 189 +/- 58 operational taxonomic units (OTUs) but dropped to 27 +/- 12 OTUs in spoiled samples. The OTU assemblage associated with spoilage was shaped by low storage temperatures, packaging and the nutritional value of the food matrix itself. These factors presumably act in tandem without any hierarchical pattern. Most notably, we were also able to identify putative new clades of dominant, previously undescribed bacteria occurring on spoiled seafood, a finding that emphasizes the importance of using culture-independent methods when studying food microbiota.

Microbiological quality and safety of minimally processed fruits in the marketplace of southern Portugal

The availability of fresh-cut fruit (FCF) in the marketplace has been increasing in Portugal, although reports of its microbial quality are not known. Due to the growing concerns of these commodities over their microbial safety, the objectives of this work were to study the microbiological quality and prevalence of Salmonella and Listeria monocytogenes on fresh-cut fruits sold in southern Portugal. A study to examine the changes in pH and microbial counts, before and after the expiration dates, was also made. A total of 160 samples was purchased in the local grocery stores between September 2011 and August 2014, before their sell-by date. These samples were assayed for aerobic mesophilic (AM) and psychrotrophic (AP) microorganisms, yeasts and molds (YM), lactic-acid bacteria (LAB), coliforms (TC), Escherichia coli and coagulase positive staphylococci as well as L. monocytogenes and Salmonella. The microbiological counts ranged from 3.0-9.2 lg cfu/g (AM); 2.2–10.7 lg cfu/g (AP); 2.3–10.4 lg cfu/g (YM); 1.9–9.0 lg cfu/g (LAB) and less than 1–9.1 lg cfu/g (TC). The melons and watermelon presented the highest levels of the microbial quality parameters studied. However, no E. coli, staphylococci, Salmonella and L. monocytogenes were detected in any of the samples. After the sell-by date, an increase of the AM, AP, LAB and YM values was observed in all fruits. Conversely, the differences found in TC counts before and after the best-before date had no statistical significance. A decrease in pH was observed in all fruits except pineapple whose pH slightly increased after 14 days of storage. The results highlight the importance of preventing contamination and cross contamination, selecting adequate decontamination technologies and maintaining a strict temperature control during processing, distribution and selling of FCF.