Operational and environmental assessment on the use of charcoal in iron ore sinter production

A study was carried out into the use of charcoal as a supplementary fuel in the iron-ore sintering process. The primary fuel was coke breeze and anthracite with 0, 10, 25, 50 and 100% replacement of the energy input with charcoal to produce sinter. This was achieved by considering the carbon content of each fuel and its corresponding participation on fuel blending, in order to have the same carbon input in each test run. An extensive analysis of the environmental impact was carried out regarding the atmospheric pollutants characterization (dust, sulphur dioxide, nitrogen oxides, carbon monoxide, carbon dioxide, methane, total hydrocarbons, and dioxins and furans). Experimental results indicate that fuel blending where 50% of the heat input was provided by charcoal may be comparable with those using 100% coke, under normal sintering conditions, and may result in a 50% reduction on greenhouse gas emission. It was also observed that while dust, methane and hydrocarbons emissions increased, the total dioxins and furans, expressed as polychlorinated dibenzodioxins/furans, decreased approximately 50% when compared with operation with 100% coke.

Processo biotecnologico a cellule immobilizzate per la produzione di acidi grassi volatili da acque di vegetazione

Le acque di vegetazione (AV) costituiscono un serio problema di carattere ambientale, sia a causa della loro elevata produzione sia per l��� elevato contenuto di COD che oscilla fra 50 e 150 g/l. Le AV sono considerate un refluo a tasso inquinante fra i pi�� elevati nell���ambito dell���industria agroalimentare e la loro tossicit�� �� determinata in massima parte dalla componente fenolica. Il presente lavoro si propone di studiare e ottimizzare un processo non solo di smaltimento di tale refluo ma anche di una sua valorizzazione, utlizzandolo come materia prima per la produzione di acidi grassi e quindi di PHA, polimeri biodegradabili utilizzabili in varie applicazioni. A tale scopo sono stati utilizzati due bioreattori anaerobici a biomassa adesa, di identica configurazione, con cui si sono condotti due esperimenti in continuo a diverse temperature e carichi organici al fine di studiare l���influenza di tali parametri sul processo. Il primo esperimento �� stato condotto a 35��C e carico organico pari a 12,39 g/L���d, il secondo a 25��C e carico organico pari a 8,40 g/L���d. Si �� scelto di allestire e mettere in opera un processo a cellule immobilizzate in quanto questa tecnologia si �� rivelata vantaggiosa nel trattamento continuo di reflui ad alto contenuto di COD e carichi variabili. Inoltre si �� scelto di lavorare in continuo poich�� tale condizione, per debiti tempi di ritenzione idraulica, consente di minimizzare la metanogenesi, mediata da microrganismi con basse velocit�� specifiche di crescita. Per costituire il letto fisso dei due reattori si sono utilizzati due diversi tipi di supporto, in modo da poter studiare anche l���influenza di tale parametro, in particolare si �� fatto uso di carbone attivo granulare (GAC) e filtri ceramici Vukopor S10 (VS). Confrontando i risultati si �� visto che la massima quantit�� di VFA prodotta nell���ambito del presente studio si ha nel VS mantenuto a 25��C: in tale condizione si arriva infatti ad un valore di VFA prodotti pari a 524,668 mgCOD/L. Inoltre l���effluente in uscita risulta pi�� concentrato in termini di VFA rispetto a quello in entrata: nell���alimentazione la percentuale di materiale organico presente sottoforma di acidi grassi volatili era del 54 % e tale percentuale, in uscita dai reattori, ha raggiunto il 59 %. Il VS25 rappresenta anche la condizione in cui il COD degradato si �� trasformato in percentuale minore a metano (2,35 %) e questo a prova del fatto che l���acidogenesi ha prevalso sulla metanogenesi. Anche nella condizione pi�� favorevole alla produzione di VFA per��, si �� riusciti ad ottenere una loro concentrazione in uscita (3,43 g/L) inferiore rispetto a quella di tentativo (8,5 g/L di VFA) per il processo di produzione di PHA, sviluppato da un gruppo di ricerca dell���universit�� ���La Sapienza��� di Roma, relativa ad un medium sintetico. Si pu�� constatare che la modesta produzione di VFA non �� dovuta all���eccessiva degradazione del COD, essendo questa nel VS25 appena pari al 6,23%, ma piuttosto �� dovuta a una scarsa concentrazione di VFA in uscita. Questo �� di buon auspicio nell���ottica di ottimizzare il processo migliorandone le prestazioni, poich�� �� possibile aumentare tale concentrazione aumentando la conversione di COD in VFA che nel VS25 �� pari a solo 5,87%. Per aumentare tale valore si pu�� agire su vari parametri, quali la temperatura e il carico organico. Si �� visto che il processo di acidogenesi �� favorito, per il VS, per basse temperature e alti carichi organici. Per quanto riguarda il reattore impaccato con carbone attivo la produzione di VFA �� molto ridotta per tutti i valori di temperatura e carichi organici utilizzati. Si pu�� quindi pensare a un���applicazione diversa di tale tipo di reattore, ad esempio per la produzione di metano e quindi di energia.

Biometanazione della frazione organica di rifiuti solidi urbani da raccolta indifferenziata mediante codigestione con refluo zootecnico o addizione di solfuro di sodio

Il presente elaborato �� stato finalizzato allo sviluppo di un processo di digestione anaerobica della frazione organica dei rifiuti solidi urbani (FORSU oppure, in lingua inglese OFMSW, Organic Fraction of Municipal Solid Waste) provenienti da raccolta indifferenziata e conseguente produzione di biogas da impiegarsi per il recupero energetico. Questo lavoro rientra nell���ambito di un progetto, cofinanziato dalla Regione Emilia Romagna attraverso il Programma Regionale per la Ricerca Industriale, l���Innovazione e il Trasferimento Tecnologico (PRRIITT), sviluppato dal Dipartimento di Chimica Applicata e Scienza dei Materiali (DICASM) dell���Universit�� di Bologna in collaborazione con la Facolt�� di Ingegneria dell���Universit�� di Ferrara e con la societ�� Recupera s.r.l. che applicher�� il processo nell���impianto pilota realizzato presso il proprio sito di biostabilizzazione e compostaggio ad Ostellato (FE). L���obiettivo �� stato la verifica della possibilit�� di impiegare la frazione organica dei rifiuti indifferenziati per la produzione di biogas, e in particolare di metano, attraverso un processo di digestione anaerobica previo trattamento chimico oppure in codigestione con altri substrati organici facilmente fermentabili. E��� stata inoltre studiata la possibilit�� di impiego di reattori con biomassa adesa per migliorare la produzione specifica di metano e diminuire la lag phase. Dalla sperimentazione si pu�� concludere che �� possibile giungere allo sviluppo di metano dalla purea codigerendola assieme a refluo zootecnico. Per ottenere per�� produzioni significative la quantit�� di solidi volatili apportati dal rifiuto non deve superare il 50% dei solidi volatili complessivi. Viceversa, l���addizione di solfuri alla sola purea si �� dimostrata ininfluente nel tentativo di sottrarre gli agenti inibitori della metanogenesi. Inoltre, l���impiego di supporti di riempimento lavorando attraverso processi batch sequenziali permette di eliminare, nei cicli successivi al primo, la lag phase dei batteri metanogeni ed incrementare la produzione specifica di metano.

Transfer and effects of 1,2,3,5,7-pentachloronaphthalene in an experimental food chain.

Polychlorinated naphthalenes are environmentally relevant compounds that are measured in biota at concentrations in the ��g/kg lipid range. Despite their widespread occurrence, literature data on the accumulation and effects of these compounds in aquatic ecosystems are sparsely available. The goal of this study was to gain insights into the biomagnification and effects of 1,2,3,5,7-pentachloronaphthalene (PeCN52) in an experimental food chain consisting of benthic worms and juvenile rainbow trout. Worms were contaminated with PeCN52 by passive dosing from polydimethylsiloxane silicone. The contaminated worms were then used to feed the juvenile rainbow trout at 0.12, 0.25 or 0.50 ��g/g fish wet weight/day, and the resulting internal whole-body concentrations of the individual fish were linked to biological responses. A possible involvement of the cellular detoxification system was explored by measuring PeCN52-induced expression of the phase I biotransformation enzyme gene cyp1a1 and the ABC transporter gene abcb1a. At the end of the 28-day study, biomagnification factors were similar for all dietary intake levels with values between 0.5 and 0.7 kg lipid(fish)/kg lipid(worm). The average uptake efficiency of 60% indicated that a high amount of PeCN52 was transferred from the worms to the fish. Internal concentrations of up to 175 mg/kg fish lipid in the highest treatment level did not result in effects on survival, behavior, or growth of the juvenile trout, but were associated with the induction of phase I metabolism which was evident from the significant up-regulation of cyp1a1 expression in the liver. In contrast, no changes were seen in abcb1a transcript levels.

Concentrations of metals and POPs in liver tissue of wild sea bird chicks from the Norwegian arctic region

Lysosomal membrane stability, lipofuscin (LF), malondialdehyde (MDA), neutral lipid (NL) levels, as well as halogenated organic compounds (HOCs), Cr, Cd, Pb and Fe concentrations were analyzed in liver of black-legged kittiwake (BK), herring gull (HG), and northern fulmar (NF) chicks. There were significant species differences in the levels of NL, LF and lysosomal membrane stability. These parameters were not associated with the respective HOC concentrations. LF accumulation was associated with increasing Cr, Cd and Pb concentrations. HG presented the lowest lysosomal membrane stability and the highest. LF and NL levels, which indicated impaired lysosomes in HG compared to NF and BK. Lipid peroxidation was associated with HOC and Fe2+ levels. Specific HOCs showed positive and significant correlations with MDA levels in HG. The study indicates that contaminant exposure can affect lysosomal and lipid associated parameters in seabird chicks even at low exposure levels. These parameters may be suitable markers of contaminant induced stress in arctic seabirds.

(Table 2) Concentrations of persistant organic pollutants in the yolk of glaucous gull eggs, Bj��rn��ya, Svalbard archipelago

It is largely unknown if and how persistent organic pollutants (POPs) affect the transfer of maternal hormones to eggs. This occurs despite an increasing number of studies relating environmental conditions experienced by female birds at the time of egg formation to maternal hormonal effects. Here we report the concentrations of maternal testosterone, 17beta-estradiol and major classes of POPs (organochlorines, brominated flame retardants and metabolically-derived products) in the yolk of unincubated, third-laid eggs of the glaucous gull (Larus hyperboreus), a top-predator in the Arctic marine environment. Controlled for seasonal and local variation, positive correlations were found between the concentrations of certain POPs and testosterone. Contaminant-related changes in the relative concentrations of testosterone and 17beta-estradiol were also observed. In addition, yolk steroid concentrations were associated with contaminant profiles describing the proportions of different POPs present in the yolk. Eggs from nests in which two sibling eggs hatched or failed to hatch differed in POP profiles and in the relative concentrations of testosterone and 17beta-estradiol. Although the results of this correlative study need to be interpreted with caution, they suggest that contaminant-related changes in yolk steroids may occur, possibly affecting offspring performance over and above toxic effects brought about by POPs in eggs.

(Table 1) Body condition and plasma POP concentrations of glaucous gulls from Bj��rn��ya, Svalbard archipelago

Behavioural field observations are increasingly being used in ecotoxicological research to identify potential adverse effects of exposure to persistent organic pollutants (POPs). We investigated thermal conditions inside the nest and parental behaviour of glaucous gulls, Larus hyperboreus, breeding in the Norwegian Arctic in relation to the concentrations of major classes of POPs (organochlorines, brominated flame retardants and metabolically derived products) accumulated in their blood. Most notably, nest temperature was negatively correlated with the concentrations of the sum of DDT, sum of PCB and several quantitatively minor POP classes within the incubating parent. To investigate the relationship between incubation ability and parental POP exposure further, we experimentally increased the costs of incubation by artificially increasing the clutch size from two to four eggs. Clutch enlargement was followed by a decrease in nest temperature, but this drop in temperature was not associated with POP concentrations within the incubating parent. However, males, which had higher POP concentrations and lower white blood cell counts than females, seemed less able to maintain nest temperature. There was virtually no evidence to suggest that the sum of PCB or DDT were associated with changes in the time a bird spent incubating. However, there was some indication that nest site attendance by nonincubating males was negatively related to the sum of DDT, suggesting that nest protection may have been compromised. The results suggest that adverse effects of parental POP exposure may occur through suboptimal thermal conditions for embryo development and possibly increased egg predation risk.

Sediment physicochemical properties condition pollutant association : a multivariate study of polybrominated diphenyl ethers on the Mendoza River irrigation areas

This work is a multidisciplinary environmental study that provides new insights into the relationships between sediment-organic matter characteristics and polybrominated diphenyl ethers (PBDEs) concentration. The aim of the present multivariate study was to correlate factors influencing PBDEs accumulation in sediment by using principal component analysis (PCA). Organic matter studies by Fourier Transform-Infrared spectroscopy and physicochemical analyses (Total Organic Carbon, pH, electrical conductivity) of sediment samples were considered for PCA. Samples were collected from an artificial irrigation network on the Mendoza River irrigation areas. PCA provided a comprehensive analysis of the studied variables, identifying two components that explained 63% of the data variance. Those factors were mainly associated to organic matter degradation degree, which represent a new insight into the relationships between organic matter in sediments and PBDEs fate. In this sense it was possible to determine that not only the content but also the type of organic matter (chemical structure) could be relevant when evaluating PBDEs accumulation and transport in the environment. Typification of organic matter may be a useful tool to predict more feasible areas where PBDE, may accumulate, as well as sediment transportation capability.

(Table 1) Lipid content and organohalogen contaminant concentration in captive sledge dogs (Canis familiaris) and wild female polar bears (Ursus maritimus) from Greenland

The limited knowledge and/or the inability to control physiological condition parameters that influence the fate of organohalogen contaminants (OHCs) has been the foremost confounding aspect in monitoring programs and health risk assessments of wild top predators in the Arctic such as the polar bear (Ursus maritimus). In the present comparative study, we used a potential surrogate Canoidea species for the East Greenland polar bear, the captive sledge dog (Canis familiaris), to investigate some factors that may influence the bioaccumulation and biotransformation of major chlorinated and brominated OHCs in adipose tissue and blood (plasma) of control (fed commercial pork fat) and exposed (fed West Greenland minke whale (Balaenoptera acutorostrata) blubber) adult female sledge dogs. Furthermore, we compared the patterns and concentrations of OHCs and their known or suggested hydroxylated (OH) metabolites (e.g., OH-PCBs) in sledge dogs with those in adipose tissue and blood (plasma) of East Greenland adult female polar bears, and blubber of their main prey species, the ringed seal (Pusa hispida). The two-year feeding regime conducted with sledge dogs led to marked differences in overall adipose tissue (and plasma) OHC residue accumulation between the control and exposed groups. Characteristic prey-to-predator OHC bioaccumulation dynamics for major PCB and PBDE congeners (patterns and concentrations) and biotransformation capacity with respect to PCB metabolite formation and OH-PCB retention distinguished, to some extent, captive sledge dogs and wild polar bears. Based on the present findings, we conclude that the use of surrogate species in toxicological investigations for species in the Canoidea family should be done with great caution, although they remain essential in the context of contaminants research with sensitive arctic top carnivore species such as the polar bear.

(Table 1) Enantiomer fractions of egg yolk and plasma samples from Svalbard glaucous gulls (Larus hyperboreus)

Glaucous gulls (Larus hyperboreus) and their eggs from Svalbard (Norwegian Arctic) have been used as biomonitors of contaminants in the marine environment. In this study, the enantiomer fractions (EFs) of chiral chlordanes and atropisomeric polychlorinated biphenyl (PCB) congeners were determined in the blood plasma of adult male and female glaucous gulls from three breeding colonies in Svalbard. Plasma EFs were similar in magnitude and direction to EFs previously reported in glaucous gulls from other arctic food webs, suggesting overall similarities in the biochemical processes influencing the EFs of bioaccumulated organochlorine (OC) contaminants within the food webs at those locations. Additionally, EFs in yolk of eggs collected concurrently from within the same nesting colonies varied with location, laying date, and OC concentrations, and may be influenced by changes in the local feeding ecology between those colonies. No differences were found between the EFs for any analyte in female gulls compared to those found in egg yolk, indicating that processes involved in the maternal transfer of chlordanes and PCBs to eggs do not modulate the stereochemical ratio between enantiomers. Therefore, the use of eggs as a valuable and noninvasive means of OC biomonitoring may also extend to enantiomer compositions in glaucous gulls, and perhaps also in other seabird species from arctic regions.