Optimization of control parameters for petroleum waste composting

Composting is being widely employed in the treatment of petroleum waste. The purpose of this study was to find the optimum control parameters for petroleum waste in-vessel composting. Various physical and chemical parameters were monitored to evaluate their influence on the microbial communities present in composting. The CO2 evolution and the number of microorganisms were measured as the activity of composting. The results demonstrated that the optimum temperature, pH and moisture content were 56.5 - 59.5 degreesC, 7.0 - 8.5 and 55 % - 60%, respectively. Under the optimum conditions, the removal efficiency of petroleum hydrocarbon reached 83.29% after 30 days composting.

Reducing H2S production by O-2 feedback control during large-scale sewage sludge composting

Hydrogen sulfide (H2S) production patterns and the influence of oxygen (O-2) concentration were studied based on a well operated composting plant. A real-time, online multi-gas detection system was applied to monitor the concentrations of H2S and O-2 in the pile during composting. The results indicate that H2S was mainly produced during the early stage of composting, especially during the first 40 h. Lack of available O-2 was the main reason for H2S production. Maintaining the O-2 concentration higher than 14% in the pile could reduce H2S production. This study suggests that shortening the interval between aeration or aerating continuously to maintain a high O-2 concentration in the pile was an effective strategy for restraining H2S production in sewage sludge composting. (C) 2010 Elsevier Ltd. All rights reserved.

流化床中RDF焚烧时CO、SO_2和HCl的生成

垃圾衍生燃料 (Refuse-Derived Fuels-RDF)具有热值高、易燃烧的优点。RDF的一个潜在应用是与煤进行混烧，替代一部分锅炉燃烧用煤。由于RDF挥发份相当高，因此燃烧时的污染物排放不易控制。本文在非均匀布风流化床中进行了RDF与煤的混烧试验，测量了H_2O、CO、CO_2、NO、N_2O、HCl、SO_2等污染物质的排放特性。结果表明与单纯燃烧RDF相比，混烧时的CO生成量大大下降；SO2生成浓度较低，而HCl的生成量比单纯烧煤时明显增加。

Release of Sulfur and Chlorine During Cofiring Rdf and Coal In An Internally Circulating Fluidized Bed

An internally circulating fluidized bed (ICFB) was applied to investigate the behavior of chlorine and sulfur during cofiring RDF and coal. The pollutant emissions in the flue gas were measured by Fourier transform infrared (FTIR) spectrometry (Gasmet DX-3000). In the tests, the concentrations of the species CO, CO2, HCl, and SO2 were measured online. Results indicated when cofiring RDF and char, due to the higher content of chlorine in RDF, the formation of HCl significantly increases. The concentration Of SO2 is relatively low because alkaline metal in the fuel ash can absorb SO2. The concentration of CO emission during firing pure RDF is relatively higher and fluctuates sharply. With the CaO addition, the sulfur absorption by calcium quickly increases, and the desulfuration ratio is bigger than the dechlorination ratio. The chemical equilibrium method is applied to predict the behavior of chlorine. Results show that gaseous HCl emission increases with increasing RDF fraction, and gaseous KCl and NaCl formation might occur.

喷流-移动床垃圾衍生燃料热解燃烧特性研究

垃圾的处置已成为全球性环境问题。与填埋法相比，焚烧、热解和气化等热处理法具有减容、减量和能源化利用等优点。如何控制垃圾焚烧过程中HCI、二恶英和未燃尽碳氢化合物等污染物的排放也引起越来越多国家的关注。采用先热解（或气化）再气相燃烧的方法以及对垃圾预处理保持垃圾组成相对稳定的RDF技术是减少二次污染的有效手段。喷动技术能够用相对较小气量流化较粗大颗粒，是进行RDF热解的较佳选择。但RDF具有密度小、流动性差等特点，考虑减少空气量和改善RDF流动性，在喷动床中水平引入辅助气，称为"喷流一移动床"。本论文首先在室温下对喷流一移动床的流体力学特性进行了研究。结果表明，水平辅助气的引入可以降低中心最小喷动气速，调控喷泉高度，提高环流区颗粒的流动速度，增大颗粒的循环流量。在此基础上，根据先部分燃烧部分热解后气相燃烧以及自热型的原则，设计了下部为喷流一移动床热解室上部为气相燃烧室的两段式RDF热解燃烧反应器，并利用实验室内制备的RDF对该反应器的运行特性进行了评价。论文对喷动空气量和辅助空气量对热解室温度分布、气体分布，二次空气对燃烧室温度分布以及CO和NOx的释放特性的影响进行了研究，然后对有机氯（PVC）和无机氯（NaCI）产生Hcl特性、Ca（OH）2对HCI的脱除特性及机理进行了研究。实验结果表明，RDF可以成功地进行自热型的先热解后气相燃烧，通过改变空气／燃料比可以控制热解室温度，水平辅助气的引入可以使热解室轴向温度分布更加均匀，热解室中可以得到O2含量低于2v％热解气体，热解气体在燃烧室中能完全燃烧。二次空气能够控制燃烧室温度以及Co和NOx的排放。PVC中氯能产生较大数量的HCI外,NaCl同样也可生成HCl；温度对PVC生成HCI量的影响很小，而对NaCI却起主要影响作用。漓温不利于钙化物与HCI反应的进仃，同时CaC12在高温时与石英砂(SiO2)、水蒸汽反应产生HCl，因此Ca（OH）2的脱氯效率会降低。

日本垃圾衍生燃料(RDF)的研究开发

综述垃圾衍生燃料（ Refuse Derived Fuel， R D F）的性能、研究开发概况，介绍了日本几个有代表性的垃圾衍生燃料生产利用设备

耐酸产甲烷菌的分离及其复合菌剂的研究

本文从成都龙泉垃圾填埋场和宜宾造纸厂分离到耐酸性能优良的高温产甲烷菌RY3和中温产甲烷菌SH4，并将其与实验室现有的利用不同底物的产甲烷菌配伍组合成了复合菌剂。采用活性污泥作为固体附着物，研制出了固体产甲烷菌复合菌剂。 菌株RY3的pH耐受范围为5.5～10.5，最适生长pH 6.0～8.0。菌株RY3为革兰氏阳性，长杆状，多数单生，不运动；菌落浅黄色，形状近圆形；利用H2+CO2或甲酸盐作为唯一碳源生长，不利用乙酸盐，对氯霉素非常敏感。该菌最适生长温度为55℃～65℃，最适NaCl浓度为0～2%。根据形态和生理生化特性及16S rDNA序列分析将其初步定为热自养甲烷热杆菌（Methanothermobacter thermautotrophicus）。添加RY3菌液与仅添加厌氧污泥作为接种物相比一周内可使达到最大产甲烷速率所需时间缩短三分之二，甲烷总产量提高约1.8倍。菌株SH4的生长pH范围5.5～9.5，其对酸碱具有良好的适应性，培养3天后，在初始pH值为6.0～8.0的培养基中甲烷产量相差不大，且基本达到最大产量。SH4革兰氏染色阳性，短杆状，多数单生，不运动；菌落近圆形，微黄；利用H2+CO2或甲酸盐作为唯一碳源生长，不利用乙酸盐，对氯霉素非常敏感。SH4最适生长pH 为7.0，最适生长温度为35℃，最适NaCl浓度为0～1.5%。实验表明，添加SH4菌液与仅添加厌氧污泥作为接种物相比可使产甲烷启动时间缩短三分之一，甲烷总产量亦有大幅提高。从形态和生理生化特征以及16S rDNA序列分析表明SH4为嗜树木甲烷短杆菌（Methanobrevibacter arboriphilus）。 以活性污泥为附着物，与培养基和菌种经搅拌后厌氧发酵可得产甲烷菌固体复合菌剂。固体复合菌剂的pH耐受范围为5.5～9.5，温度耐受范围为15℃～65℃，表明其对环境的适应性较强。以猪粪为底物进行厌氧发酵，接种复合菌剂进行试验，以接种实验室长期富集的产甲烷厌氧污泥作为对照，在20℃时，发酵甲烷浓度与对照基本一致，但每日产气量优于对照，第15天时接种复合菌剂的发酵瓶每日产气量是对照的1.59倍；50℃时达到最大甲烷含量所需时间比对照缩短三分之二，三周内总产气量约为对照的2.7倍，甲烷总产量约为2.8倍。以不加接种物为对照，接种复合菌剂20℃时发酵甲烷含量达到50%约需2周，对照2周内甲烷含量最高仅为4.3%；50℃时接种复合菌剂发酵仅需约1周甲烷含量便可达50%，对照则至少需要2周。 In this paper, high-temperature Methanogen RY3 and middle-temperature SH4 were isolated from Chengdu Longquan refuse landfill and Yibin paper mill. They could be used to make compound inoculum that producing methane with the existing Methanogens utilized different substrate. With using anaerobic activated sludge be solid fixture, the process had been designed to produce solid compound inoculum. Strain RY3 possessed excellent capacity of acid and alkali-tolerant. The pH-tolerant scale of RY3 was 5.5～10.5 and its optimum pH value for growth was 6.0～8.0. RY3 was G+, long-rod shape, monothetic and nonmotile, the colony was pale yellow with suborbicular-shape. Formate or H2+CO2 but not acetate was utilized by RY3 as sole C-source, and it was very sensitive to chloramphenicol. Besides, strain RY3 grew fastest at 55℃～65 and 0℃～2% NaCl. Characteristics of modality and physiology with sequence analysis of the 16s rDNA gene of strain RY3 preliminarily showed that it was Methanothermobacter thermautotrophicus. The experiments indicated that the time which began to produce methane with the highest velocity could be shortened two third by adding RY3 in one week, and the total methane production also was 1.8 times than before. Strain SH4 possessed wide scale of growing pH（5.5～9.5）and excellent ability of acclimatizing itself to acid-alkali. The methane production had no apparent difference among those cultivated in different initial pH（6.0～8.0）after three days and equaled to the maximum production basically. Cells of SH4 were G+, short-rod sharp, monothetic and nonmotile. The colony was pale yellow with suborbicular-shape. Formate or H2+CO2 but not acetate was utilized by SH4 as sole C-source, and it was very sensitive to chloramphenicol. Besides, it grew fastest at pH 7.0，55 ℃～65 and 0℃～2% NaCl concentration. The experiment indicated the time that began to produce methane could be shortening one third by adding SH4. And the total methane production also rose apparently. Characteristic of modality and physiology with sequence analysis of the 16S rDNA gene of strain SH4 demonstrated it was Methanobrevibacter arboriphilus. The activated sludge was utilized as fixture, mixed with culture medium and inocolum, that the solid compound inoculum could be produced by anaerobic fermentation. The compound inoculum could grow between pH 5.5～9.5, 15℃～65. It demonstrated the compound inoculum ha℃ve great ability of adapting to circumstance. In the experiment that making pig manure be substrate and taking the anaerobic sludge producing methane that cultured in long term in laboratory to be comparison, the concentration of methane in fermentation added compound inoculum almost equal to the comparison at 20℃, but the volume of gas production could be a little higher. The gas production everyday inoculated compound inoculum was 1.59 times to comparison. The time that the concentration of methane to maximum could be shortening by two third by adding compound inoculum, and the total gas production was 2.7 times to comprison while the total methane production was 2.8 times. If take the no inoculum be the comprasion, anaerobic fermentation added compound inoculum made the concentration of methane to 50% in 2 weeks but the comparison only to 4.3% at 20℃. The time that the concentration of methane to 50% by adding compound inoculum only need 1 week, but the comparison need 2 weeks at 50℃.

氮和磷在饲养-堆腐环中的循环率及有机肥料养分利用率

A five-year experiment indicated that the average loss rate of N and P in harvested products through a feeding-composting cycle was about 50% and 15%,respectively.Under high yield condition,the amount of recycled N and P from 80% harvested products and through a feeding-composting cycle in farming systems was about 3751 and 814 kghm~(-2),equivalent to 25%34% of N and 32%56% of P from chemical fertilizers applied each year to the systems.The apparent recoveries of N and P in organic manure increased with the prolongation of fertilization,indicating a synergetic residual effect existed,and was 61% and 39% in average in the five-year experiment.The use of nutrients recycled in the farming systems could not only improve soil fertility,but also increase the recoveries of nutrients and reduce the use of chemical fertilizers.

A QUANTITATIVE ASSESSMENT OF SOURCE CONTRIBUTIONS TO INHALABLE PARTICULATE MATTER POLLUTION IN METROPOLITAN BOSTON

In this paper, source apportionment techniques are employed to identify and quantify the major particle pollution source classes affecting a monitoring site in metropolitan Boston, MA. A Principal Component Analysis (PCA) of paniculate elemental data allows the estimation of mass contributions for five fine mass panicle source classes (soil, motor vehicle, coal related, oil and salt aerosols), and six coarse panicle source classes (soil, motor vehicle, refuse incineration, residual oil, salt and sulfate aerosols). Also derived are the elemental characteristics of those source aerosols and their contributions to the total recorded elemental concentrations (i.e. an elemental mass balance). These are estimated by applying a new approach to apportioning mass among various PCA source components: the calculation of Absolute Principal Component Scores, and the subsequent regression of daily mass and elemental concentrations on these scores.

粪肥堆腐过程中有机酸的变化

通过模拟试验研究了鸡粪和奶牛粪肥堆腐过程中有机酸的种类、含量和变化规律。结果表明 ,鸡粪腐熟过程中会形成和累积大量的有机酸 ,在堆腐的第 5周 ,最高含量可达 88 2cmol/kg ,DW ;不挥发性有机酸在堆腐的第 3周和第 5周分别达到两个高峰 ,挥发性有机酸在第 6周和第 9周分别达到高峰 ,到第 9周后 ,鸡粪中的有机酸大大降低。鸡粪中除了存在大量的芳香酸如苯二酸及其衍生物外 ,在堆腐的过程中还有大量的丁二酸及其衍生物等多元脂肪酸生成。奶牛粪肥的有机酸以不挥发性有机酸为主 ,总酸量最高可达 2 9 38cmol/kg ,DW ;奶牛粪肥中的不挥发有机酸主要是苯二羧酸的衍生物和长链脂肪酸。堆腐过程中有机酸的种类和数量变化较大。堆腐的第 6周 ,产生了多种激素类物质

污泥处理经济评价和污泥堆肥中氧气监测与动态分析

With the continually increase both in the amount of wastewater disposal and in the treatment rate, more and more sewage sludge has been produced. An economic estimate was taken on the different sewage sludge disposal and treatment technologies, and led to the conclusion that compost is an effective way to make sewage sludge harmless, stable and resourceable. Normally, there are several ways to treat sewage sludge, such as landfill, compost, incineration and so on. These technologies will cost 300-1000 Y per ton of sludge. Among those ways, landfill is the cheapest one and operates easily, however, it just postpones the pollution instead of eventually eliminating the pollution; The amount of the sludge will reduce dramatically after incineration, while incineration will take a very high investment in the beginning, at the same time, it's very hard to maintain running; Sewage sludge will be resourceful after composting treantment, thus makes up the treatment cost, makes composting is the most economical way. Compost production is safe when correctly used, compost is a important way to treat sewage sludge. Oxygen is an important control factor in aerobic composting that has great effects on temperature and microorganisms. The gas gathering and transfering system of an online oxygen monitoring system for composting were bettermented to prolong the monitoring system's running period. The oxygen concentration changes in various aerobic composting stage were studied, and conclusions came to that oxygen concentration changes much faster in the oxygen concentration increasing stage than that in the declining stage; the better the aerobic condition is, the sooner the monitoring system starts to work. The minimal oxygen concentration during a ventilation cycle often falls at the beginning, then ascends in the composting period; at the same time, oxygen concentration changes fast in the early composting stage(temperature increasing stage), much slower in the middle stage(continouns thermophilic stage),and seldom changes in the late composting stage(temperature declining stage). With the help of the oxygen realtime-online monitoring system, oxygen concentrations was measured. During the composting period, water contents was analyzed after sampled. It's found that water contents (WC) and Oxygen concentration can both influence the composting process, and the control rule varies in the various composting stages. Essentially, the rule that water and oxygen control the composting process comes from water counterchecks the oxygen transferring to the composting substrate. The most influential factor to the WC and to the oxygen is the components in the composting pile. In the temperature increasing stage, seldom microorganisms exist in the composting pile with low activity, thus oxygen can meet with microorganisms' need, and WC is the dominant factor. In the high temperature (continouns thermophilic) stage, composting process is controlled by WC and oxygen, essentially by WC, at the same time, their influence somehow is not remarkable. In the temperature declining stage, WC and oxygen influence the composting process little. It's also found that the composting process will differ even if under the same components, thus to equably mix the components can avoid WC focusing in some place and let the composting pile to be aerobic. In one sentence, aerobic state is the most important factor in the composting process, suitable bulking material will be useful to the composting control.

从赌博游戏中的损失厌恶行为看情感预测与体验在决策中的作用

In Kermer, Driver-Linn, Wilson and Gilbert’s (2006) study on affective forecast, they found that people have a tendency to overestimate affective reactions in gains and losses, and people expect losses to have greater hedonic impact than gains of equal magnitude. Because of thus affective forecasting error, people prefer to irrationally avoid losses. Loss aversion is then seen as both a wealth-maximizing error and an affect-maximizing error. The present study examined the relationships among affective forecast, affective experience and loss aversion, and tested Kermer et al.’s (2006) conclusion that people’s loss aversion is an affective forecasting error. In experiment 1, we examined the relationship between affective forecast and loss aversion. Kermer et al.’s (2006) hypothesized that when people expect losses to have greater hedonic impact than gains, they will accept the gambling task, and when people expect gains to have greater hedonic impact than losses, they will refuse the gambling task. We found that (1) individuals with lower loss aversion had a greater tendency to accept a gambling task than those with higher loss aversion; (2) individuals with lower loss aversion expected losses and gains to have smaller affective impacts than those with higher loss aversion. Thus, people never exactly calculated their forecasting affective. In experiment 2, we examined the relationship between affective forecast and affective experience. Consistent with Kermer et al.’s (2006) finding, we found that our participants tended to overestimate affective reactions in gains as well as losses. More interestingly, Kermer et al.’s (2006) found that participants’ predictions for a loss were significantly more distant from experienced emotions than were their predictions for a win, we, however, found the opposite —participants’ predictions for a win were significantly more distant from the experienced emotions than were their predictions for a loss. These experiments further validated the relations between affection and decision making, and contributed to our understanding on the affective reactions to future events. Our study imply that it was not the exact calculation of affective forecast on decision outcomes, but rather the magnitude of affection on outcomes, that influenced people’s affective decision making. It indicated that those with lower magnitude of affection would less like to avoid losses, and thus more like to accept a gambling task.