Start-up of horizontal anaerobic reactors with sludge blanket and fixed bed for wastewater treatment from coffee processing by wet method

In this study it was evaluated the start-up procedures of anaerobic treatment system with three horizontal anaerobic reactors (R1, R2 and R3), installed in series, with volume of 1.2 L each. R1 had sludge blanket, and R2 and R3 had half supporter of bamboo and coconut fiber, respectively. As an affluent, it was synthesized wastewater from mechanical pulping of the coffee fruit by wet method, with a mean value of total chemical oxygen demand (CODtotal) of 16,003 mg L-1. The hydraulic retention time (HRT) in each reactor was 30 h. The volumetric organic loading (VOL) applied in R1 varied from 8.9 to 25.0 g of CODtotal (L d)-1. The mean removal efficiencies of CODtotal varied from 43 to 97% in the treatment system (R1+R2+R3), stabilizing above 80% after 30 days of operation. The mean content of methane in the biogas were of 70 to 76%, the mean volumetric production was 1.7 L CH4 (L reactor d)-1 in the system, and the higher conversions were around at 0.20 L CH4 (g CODremoved)-1 in R1 and R2. The mean values of pH in the effluents ranged from 6.8 to 8.3 and the mean values of total volatile acids remained below 200 mg L-1 in the effluent of R3. The concentrations of total phenols of the affluent ranged from 45 to 278 mg L-1, and the mean removal efficiency was of 52%. The start-up of the anaerobic treatment system occurred after 30 days of operation as a result of inoculation with anaerobic sludge with active microbiota.

Longitudinal distribution of bean seeds in horizontal plate meter operating with one or two seed outlets

This study aimed to evaluate the effect of horizontal plate meter with oblong holes operating with one or two seed outlets at different speeds over the accuracy of longitudinal distribution of common bean seeds (Phaseolus vulgaris L.). The experiment was performed in laboratory using the meter with one and two seed outlet points in relation to ten tangential disk plate speeds (0.03 to 0.30 m s-1). It was used a complete randomized design with four replications, summing up 80 experimental treatments. Tangential speed quantitative factor was estimated through a 2nd order polynomial regression. There was no significant difference in the behavior of the seed meter operating with one or two outlets in the metering of bean seeds in all tested speeds, with percentage of single seeds spacing over 60% in tangential speeds below of 0.24 m s-1.

Horizontal pressures in cylindrical metal silos and comparison with different international standards

The focus of this research was to evaluate the horizontal pressures on a cylindrical metal silo of corrugated walls and flat bottom with 1.82m diameter and 5.4m high, and to compare the values with those obtained theoretically by the ISO 11697, EP 433 and AS 3774 standards. The silo was symmetrically filled and constant speed with wheat cv. soft red for two different height/diameter ratios (H/D) and was unloaded through three orifices with a diameter of 71.6mm, one concentric and two eccentrics. Horizontal pressures were measured on the walls of the silo at three positions using hydraulic type pressure cells. The results showed that shortly after the start of the unloading, there was a mass flow above the quota of H/D = 1.2, whereas below this quota funnel flow occurred. It can be said that the EP 433 standard was more appropriate to predict horizontal pressures in silos in H/D ratio = 1.0, with eccentric unloading. For the H/D ratio = 1.5, AS 3774 standard was the one that produced values closer to the experimental.

Cassava starch extraction effluent treatment in a one phase tubular horizontal pilot reactor with support medium

The cassava starch industries generate a large volume of wastewater effluent that, stabilized in ponds, wastes its biogas energy and pollutes the atmosphere. To contribute with the reversion of this reality, this manipueira treatment research was developed in one phase anaerobic horizontal pilot reactor with support medium in bamboo pieces. The reactor was excavated into the ground and sealed with geomembrane in HDPE, having a volume equal to 33.6 m³ and continuous feeding by gravity. The stability indicators were pH, volatile acidity/total alkalinity ratio and biogas production. The statistical analyses were performed by a completely randomized design, with answers submitted to multivariate analysis. The organical loads in COD were 0.556; 0.670; 0.678 and 0.770 g L-1 and in volatile solids (VS) of 0.659; 0.608; 0.570 and 0.761 g L-1 for the hydraulic retention times (HRT) of 13.0; 11.5; 10.0 and 7.0 days, respectively. The reductions in COD were 88; 80; 88 and 67% and for VS of 76; 77; 65 and 61%. The biogas productions relatively to the consumed COD were 0.368; 0.795; 0.891 and 0.907 Lg-1, for the consumed VS of 0.524; 0.930; 1.757 and 0.952 Lg-1 and volumetric of 0.131; 0.330; 0.430 and 0.374 L L-1 d-1. The reactor remained stable and the bamboo pieces, in visual examination at the end of the experiment, showed to be in good physical conditions.

Uso de traçador salino para avaliação da colmatação e das condições hidrodinâmicas em sistemas alagados construídos de escoamento horizontal subsuperficial

RESUMO A colmatação é um fenômeno intrínseco aos sistemas alagados construídos (SACs) utilizados no tratamento de esgotos, sendo decorrente dos mecanismos de remoção de poluentes. Dentre os métodos disponíveis para a avaliação da colmatação, destaca-se o uso de traçadores para a obtenção das condições hidrodinâmicas dos SACs. No entanto, não há um traçador ideal; os salinos, por exemplo, são passíveis de absorção, mecanismo influenciado pelo estádio no qual a planta se apresenta. Assim, objetivou-se, com a realização do trabalho, avaliar a utilização do NaCl para caracterização do grau de colmatação e das condições hidrodinâmicas de SACs de escoamento horizontal subsuperficial, plantado e não plantado, verificar a confiabilidade do uso desse traçador em testes executados durante o estádio de crescimento (após o corte da parte aérea) e o florescimento da taboa (Typha latifolia), além da suscetibilidade de causar danos às plantas. Os resultados indicaram que o NaCl pode ser utilizado para estudos de comparação do grau de colmatação de SACs, inclusive não apresentando danos à taboa. Verificou-se que, após sete anos de operação, a unidade plantada encontra-se mais colmatada e com regime de escoamento mais turbulento. Também foi possível inferir que o corte das plantas propiciou aumento na dispersão no sistema.

Perfuração gástrica secundária a tricobezoar gigante: descrição de caso e revisão da literatura

Gastric bezoars are impactations offoreign material in lhe stomach. When they are caused by hail; they are named tricho- bezoars. The complications oftrichobezoars are very rare. In this papel; we describe a case of a 16-year-old girl that had a previous history oftricophagia, and had an acute abdominal pain with a pneumoperitoneum in the abdomen radiography. An operation was performed and a gastric perforation was founded associated with a giant trichobezoa7: The trichobezoar was removed by traction through a gastrostomy which was performed in order to remove lhe trichobezoa7: Some fragments of the ulcer were obtained to histological study. The gastrostomy was treated by a gastrorraphy confection. In lhe post- operative period a left subfrenic abscess was revealed and has been drained by laparatomy 15 days after the fisrt operation. After the second surgical procedure the patient had a good evolution, and left the hospital in good health conditions.

Evisceração do intestino delgado através de perfuração de prolapso retal em uma criança

The rectal prolapse is very common in children under 3 years old. Rectal mucosae herniated in to the anal canal. The ethiologic causes are diarrhea, intestinal parasitosis, obstipation and desnutrition. The effort during the defecation, prolonged diarrhea and obstipation are important contribucting factors. The treatment in the majority of cases is medical treating factors like desnutrition, diarrheia and parasitosis. The authors report a case of a 3-month-old child with chronic diarrhea, severe desnutrition and recurrent rectal prolapse with perforation hole. This is a rare complication and considerations are made regarding the management of the case.

Histoplasmose como causa de perfuração intestinal em paciente com síndrome da imunodeficiência adquirida

Thirty-four years old patient, female, husband died of AIDS (Acquired Immunodeficiency Síndrome). She's confined to Hospital Universitário João de Barros Barreto, with a positive tesT for AIDS, fever, 10 kg/month of weight loss, diarrhea with gummy faeces, productive cough, yellowish sputum. The therapy was initiated, symptomatic, associated to Epivir, Saquinavir and AZT. The searching exams for Alcohol Ácid Resistant Bacili and fungi in the sputum were negative. At the hemogram was shown a pancytopenia, the esophagogastroduodenunscopy showed light esophago moniliasis. During commitment presented a perforating acute abdomen chart, the abdominal radiography showed hidroair levels, pneumoperitoneum, enlarced bowels with swollen wall. She was undertaken a surgery with diagnosis hypothesis of cytomegalovirus perforation, which accordin to literature is the most frequent cause of intestinal perforation in patients with AIDS.

Perfuração gástrica por tricobezoar

Bezoars are uncommon foreign bodies found in the stomach and intestines. They are usually secundary to "strange" or "weird" alimentary habits. The contents may include hait; stones, vegetal fibers and others. Diagnosis is generally made due to complications, mainly parcial or complete obstruction of the segment affected. Bleeding and peiforation may also occur: This paper describes a case of a 14-years-old female patient, who presented herself to lhe Emergency Room and was diagnosed as having a gastric peiforation due to a trichobezoar that was 15 cm long and weighted 900g. A review of lhe literature and comments about diagnosis and management are presented.

Perfuração espontânea de colédoco em adolescente

Spontaneous perforation of the common bile duct is rare. It happens predominantly in children and it is related to obstructive disease of the biliary tract. We present a case of an 18 year-old male patient, with ulcerative rectocolitis associated with malignant tumor of the head of pancreas. The patient developed an acute abdomen syndrome and laparotomy, a spontaneous perforation of common bile duct was evidenced. The authors make a revision of the clinical aspects of that pathology.

Hérnia lombar encarcerada complicada com obstrução intestinal e perfuração de ceco

Lumbar hernia is defined as an abdominal passage through the posterior abdominal wall. Approximately 250 to 300 cases have been described in the literature, being quite infrequent. Untreated lumbar hernia may result in severe complications. The authors report a case of a 60 year old male patient presenting a large bowel obstruction and perfuration secundary to incarceration of descending colon within a lumbar hernia. This was diagnosed by clinical history and computed tomography. The patient was successfully treated surgically.

Perfuração espontânea de ducto hepático comum

Perforation of common bile duct (CBD) is usually associated with invasive procedures. Spontaneous perforation is rare, and more often described in neonates. We report a case of a spontaneous perforation of CBD in an adult with a family history of cholelithiasis, but with no calculus found during exploration of the biliary tree. The patient was successfully treated by cholecystectomy and T - tube drainage of the CBD.

Mediastinite por perfuração e ruptura do esôfago torácico

OBJETIVO: Avaliar a mortalidade por mediastinite e sepse originadas por perfuração e ruptura do esôfago torácico, de acordo o tempo de evolução da doença. MÉTODO: Estudo retrospectivo de 14 anos (1992 a 2006), com pacientes portadores de ruptura e perfuração do esôfago. Foi avaliado sexo, idade, mecanismo de lesão, evolução ( 24 horas) e tratamento. RESULTADOS: Foram analisados 44 pacientes, sendo 10 do sexo feminino (22,73%) e 34 do sexo masculino (77,27%). A variação da idade foi de dois meses a 77 anos e a média de 33,2. Os ferimentos estiveram presentes em 19 casos (43,18%): Arma branca em cinco e projétil de arma de fogo 14. A instrumentação endoscópica foi detectada em nove casos (20,45%). Nos pacientes submetidos à esofagorrafia (diagnóstico precoce, menos de 24 horas) a mortalidade esteve presente três casos (20%). Em pacientes submetidos à esofagectomia (diagnóstico tardio, mais de 24 horas) a mortalidade ocorreu em oito casos (36,36%), e essa diferença não foi estatisticamente significante (p 0,05). No tratamento conservador, a mortalidade foi em cinco de sete casos a a diferença foi estatisticamente significativa quando comparado com o tratamento cirúrgico. CONCLUSÕES: O tratamento conservador para mediastinite por ruptura e perfuração do esôfago mostrou mortalidade alta quando comparada com tratamento cirúrgico. Entre os pacientes operados, a diferença não foi estatisticamente significante, confirmando a indicação de esofagectomia para casos de infecção avançada e a esofagorrafia para casos precoces.

Esofagectomia na perfuração esofágica com diagnóstico tardio

Esophageal perforations are related to high mortality rates, especially if there is a delayed diagnostic and treatment. We report an esophageal perforation caused by caustic ingestion, in a suicidal attempt, successfully treated by esophagectomy after a long period of misdiagnosis that lead to infectious complications.

Perfuração espontânea da via biliar principal na infância

The authors report a case of spontaneous perforation of the biliary tract (S.P.B.T) in a three-month-old infant. The diagnosis was suspected before the operation by clinical signs and diagnostic tests. The importance of paracentesis and scintigraphy is stressed. A surgical approach was chosen and drainage procedure of the area around the perforation and a cholecystostomy were done. S.P.B.T. is rare and its etiology is controversial, but cannot be forgotten in association between biliary ascites and cholestatic jaundice during the first months of life.