Effect of chilled sea water storage of oil sardine (Sardinella longiceps) on quality changes during frozen storage

The shelf-life of frozen oil sardine (Sardinella longiceps) can be improved by preserving the fish immediately after catch in chilled sea water before freezing. Delayed icing caused considerable deterioration in quality and reduced frozen shelf-life. Oil sardine preserved in chilled sea water were found to be suitable for freezing up to 5 days whereas iced samples could be frozen only up to 2 days.

Studies on freezing and storage of Psenopsis cyanea

The freezing and storage characteristics of Psenopsis cyanea caught on board FORV Sagar Sampada from a depth of 350 m off Cochin are reported. The fat content of the fish was high (15.58% on the weight of whole fish) and the meat was white in colour. Peroxide value, free fatty acids and thiobarbituric acid values increased during frozen storage and organoleptically the fish was acceptable up to 32 weeks at -22 ± 1°C.

Effect of pre-processing iced storage on deteriorative changes in lipids of silver pomfrets stored at -18°C

Silver pomfret (Pampus argenteus) was frozen in the fresh condition as well as after holding in ice for one, two and four days. Evaluation of changes in the quality of these samples during storage at -18°C has shown that shelf-life decreased sharply if the pre-freezing iced storage was more than one day. The shelf-life of one day iced, two day iced and four day iced frozen samples were 32, 20 and 16 weeks respectively. No correlation was observed between the peroxide value and the organoleptic detection of rancid flavour. Levels of free fatty acids were more in the samples frozen after storage in ice for one day than in all the other samples.

Studies on iced storage of cultured rohu (Labeo rohita)

The biochemical, bacteriological and organoleptic changes in cultured rohu (Labeo rohita) during iced storage have been studied. Non-protein nitrogen decreased and water soluble nitrogen remained almost same during storage in ice. Initially, when the fish was in pre-rigor and rigor conditions, the extractability of protein was low (45 to 50%) which increased after the resolution of the rigor and the decrease in extractability towards the end of storage was insignificant. The total volatile base nitrogen remained steady up to 7 days in ice and showed slight decrease on further storage. During iced storage the bacterial count increased from 10^3/g to 10^5/g by the 11th day of storage. Nearly 80-90% of the total bacterial population in fresh fish was constituted by mesophiles which decreased gradually (decreased to 1% by 13th day of iced storage). Organoleptically the fish was acceptable up to 15 days in ice.

Solid loss and weight gain in prawns during storage in ice

Loss of solids from and gain in weight of meat of whole prawn and prawn meat stored in ice has been studied to explain the mechanism of solid loss. Two stages are identified in this phenomenon. In the first stage water is absorbed without loss of solids resulting in a maximum increase in weight. In the second stage both solids and water are lost resulting in gradual decrease in weight from the maximum reached but not reaching the original weight. It is inferred that whole prawns stored in ice up to two days give the maximum peeled yield without loss of nutrients and at the same time making the peeling process easier.

Bulk packages for storage and transportation of salted and dried fish

The effect of bulk packaging on the storage of salted and dried fish was studied at ambient conditions. Four different packaging systems were tried, among which gusseted type high density polyethylene woven sacks having either circular loom or traditional loom laminated with 100 gauge low density polyethylene were found to be best suited for dry fish packaging as they could withstand the hazards of handling, transportation and storage.

The effect of various salinity levels and stocking density manipulation methods on the survival of milkfish fry (Chanos chanos Forsskal) during storage

Results of the study indicate that the survival rate and increase in body weight did not differ significantly at different salinity levels or at different stocking density manipulation methods. A significant interaction between salinity and stocking density manipulation could not be demonstrated statistically. There apparently is no need to reduce the salinity of the water used in storing milkfish Chanos chanos fry in order to attain higher survival as commonly believed. Sufficient food and maintenance of good water quality are more important than salinity for higher survival of fry during storage.

Effect of preprocessing storage conditions on the carbonyls of oil sardine

Changes in the total as well as major individual carbonyls of oil sardine muscle during storage at room temperature for 24 h and in crushed ice up to 6 days are reported. Carbonyls extracted with hexane were converted to their 2:4 dinitrophenyl hydrazone (DNPH) derivatives and were separated into major classes by column chromatography on celite/magnesia. Individual carbonyls were then identified by capillary gas chromatography of these derivatives. Though absolute values for carbonyls exhibited wide variations depending upon the degree of freshness, the pattern of changes in the carbonyls during storage of fish under different conditions gave an insight into the influence of carbonyls on flavour. The significance of the findings is discussed.

Shelf-life of rotary and solar tunnel dried SIS products under different packaging and storage conditions

A study was conducted on the shelf-life of rotary and solar tunnel dried SIS products under different packaging and storage conditions. Organoleptically dried products were found in good condition after a storage period of 60 days in ambient and chilled conditions. The moisture content, TVB-N value and bacterial load slightly increased during 60 days of storage in ambient and chilled conditions. The changes in moisture content and bacterial load were faster in ambient temperature than in chilled storage condition whereas changes in TVB-N value was higher in chilled condition than in ambient temperature. The initial moisture content was in the range of 13.71% to 22.84%. After 60 days of storage in ambient and chilled condition the moisture content of dried products was in the range of 15.09% to 25.11% and 14.49% to 25.01%, respectively. The initial TVB-N value was in the range of 10.64 to 17.52 mg/100g and after 60 days of storage in ambient and chilled condition, TVB-N value was in the range of 29.00 to 34.82 mg/100g and 31.41 to 39.11 mg/100g, respectively. The initial bacterial load was in the range of 1.91x10 super(8) to 2.84x10 super(8) and after 60 days of storage in ambient and chilled condition, the bacterial load was in the range of 6.2x10 super(8) to 1.8x10 super(9) and 5.75x10 super(7) to 5.05x10 super(8) CFU/g, respectively. The results of the present study indicated that it is necessary to store high quality dried products in sealed packed in chilled condition to ensure good quality up to a certain period of time.

Organoleptic and microbiological quality changes of catla (Catla catla) in immediate and delayed ice storage and at ambient temperature

An investigation was carried out on the quality changes of Catla (Catla calla) stored immediately (0 h) in ice, after 6 hours in ice and at ambient temperature. The samples were examined for organoleptic and microbiological parameters in summer. Organoleptically, the acceptability of fish varied between 16-20 days in both the iced storage conditions and 12-13.5 hours at ambient temperature (28°C). When fish were organoleptically just acceptable on the 16th day of storage, bacterial load were 6.23 and 6.17 log10 cfu/g, respectively for 0 hour and after 6 hours iced fish. But on the 20th day of storage, when fish were just unacceptable SPC were 6.51 and 6.62 log10 cfu/g. In case of ambient temperature storage condition standard plate count was 8.36 log10 cfu/g on 13.5 hours, when fish were organoleptically just unacceptable. At the time of rejection for fish stored in ice (0 hour and after 6 hours) on 20th day, gram negative and gram positive values were 55.45%, 44.55% and 44.52%, 55.48% respectively. While fish were rejected after 13.5 hours at ambient temperature gram negative and gram positive bacteria were found as 43.02% and 56.98%. The differences in SPC, gram positive and gram negative bacteria between the storage times were statistically significant (p<0.05).

Study on shelf life of fish cake prepared from surimi of silver carp (Hypophthalmichthys molitrix) during frozen storage

Surimi was prepared from silver carp with an aim to put this underutilized fish for profitable use. The mince prepared was washed twice with chilled water (5°C) using mince to water ratio (w/v) of 1:2 for 5-6 minutes each. After final dewatering to moisture content to about 80%; half the quantity of washed minced meat was mixed with cryoprotectants (4% sorbitol, 4% sucrose and 0.3% sodium tripolyphosphate) to produce surimi. The prepared surimi and the dewatered minced meat were packed in LDPE bags, frozen using a plate freezer and stored at -20°C. Surimi and dewatered minced meat from frozen storage were used as base material for production of fish cakes. These were fried at 160°C for 3 to 4 minutes before serving for organoleptic test. Changes in salt soluble nitrogen, total volatile base nitrogen, non-protein nitrogen, peroxide value and free fatty acid of surimi and dewatered mince were estimated at every ten days interval during the storage period of 3 months. The study has indicated that frozen storage of surimi could be a potential method for effective utilization of silver carp. This surimi when incorporated in fish cakes yielded products which retained the shelf life even up to 90 days of storage.

Microbiological quality study of Macrobrachium rosenbergii (de Man 1879) during storage at -20°C temperature

The shelf life of fresh water prawn Macrobrachium rosenbergii by applying low temperature was investigated. M. rosenbergii preserved at -20°C was subjected for quality assessment before storage and at 15, 30, 45, and 90 days of storage period. The quality assessments as done microbiological viz. total bacterial count (TBC), total mould count (TMC), total yeast count (TYC), total coliform count (TCC) and salmonella count. All the samples were acceptable during 90 days because the upper limit of all spoilage indicator was not exceeding within the experimental time period.

The effect of Rosmarinus officinalis and Zataria multiflora extracts on the stability of poly unsaturated fatty acids in frozen silver carp minced

The purpose of this study, Evaluation the effect of Rosmarinus officinalis and Thymus vulgaris extracts on the stability of poly unsaturated fatty acids in frozen Silver carp minced. Treatments include: Treatment 1 - Control: frozen meat packaged in conventional Treatment 2: Frozen Silver carp minced+Thyme 300 mg/kg in normal packaging Treatment 3: Frozen Silver carp minced+Rosemary 200 mg/kg in normal packaging Treatment 4: Frozen Silver carp minced+Rosemary compound (100 mg/kg) and Thyme (100 mg/kg) in normal packaging After rapid freezing of samples in the spiral freezer by individual quick freezing method, to maintain the cold temperature (-18) °C were transferred. Sampling and measurements to determine the fatty acid profile of the zero phase beginning in the first month and then every ten days, and 15 days in the second month of the third month after the monthly test. Identifying, defining and measuring the fatty acid profile by gas chromatography was performed. In this study, levels of both saturated and unsaturated fatty acids in three experimental and one control were identified as follows: A: saturated fatty acids: Meristic C14: 0/Palmitic C16: 0/Hepta decaenoic C17: 0/Stearic C18: 0/Arashidic C20: 0/B:Mono unsaturated fatty acids: palmitoleic C16: 1-W7/Oleic C18: 1-W9/Gadoleic C20: 1-W9 C:Poly unsaturated fatty acids: Linoleic C18: 2-W6/α-Linolenic C18: 3-W3 D:High unsaturated fatty acids: Arachidonic C20: 4-W6 Eicosapentaenoic acid C20: 5-EPA/W3 Docosahexaenoic C22: 6-DHA/W3 Results of this study was to determine, Thyme and rosemary extracts containing silver carp minced stored in freezing conditions, Stability of different types of fatty acids, monounsaturated fatty acids, poly-unsaturated fatty acids, omega-3 and omega-6 fatty acids are. So that none of the fatty acids measured were not significant 100% increase or decrease, While changes in the fatty acid oxidation during storage time is minimized. The results obtained from the fatty acid profiles and indicators of their and statistical tests show that treatment with rosemary extract More stable during storage (-18) ° C In comparison with the control and other treatments are shown; And at relatively low compared to other treatments and control samples oleic acid and linoleic acid, palmitic more. According to studies,in Silver carp minced that containing rosemary extract, end of the storage period of six months. Were usable, so even rosemary extract the shelf-life examples to increase more than six months.

In vivo and in vitro storage of kutum, Rutilus frisii kutum eggs

Effects of post-ovulatory and post-stripping retention time and temperature on egg viability rates were studied in kutum (Rutilus frisii kutum). Eggs were retained inside (in vivo storage) or outside the ovarian cavity with ovarian fluid (in vitro storage) at various temperatures. Two experiments were performed: 1) Partial volumes of eggs were stripped and fertilized at 24- hour intervals for 96 hours post-ovulation (HPO) (at 11 °C) and at 12-hour intervals for 72 HPO (at 14 °C), and 2) stored eggs were fertilized after 0, 2, 4, 6, and 8 hours post-stripping (HPS) at temperatures of 4, 10, 12, and 26 °C. In the first experiment, the highest eyeing and hatching rates (76% and 60% at 11 °C; 81% and 71% at 14 °C) and the lowest eyed-egg mortalities (20% at 11 °C; 12% at 14 °C) occurred in the eggs fertilized immediately (0–24 HPO at 11 °C and 0–12 HPO at 14 °C) after ovulation. Egg viability, as shown by successful eyeing and hatching rates, was completely lost by 72–96 HPO at 11 °C, and 60–72 HPO at 14 °C. In the second experiment, the maximum eyeing (87%) and hatching (75%) rates of eggs took place at 0 HPS followed by 8 HPS (> 80% and > 70%, respectively) at 4 °C. As storage temperature increased, egg viability decreased: 80%, 70%, and 50% viable at 8 HPS at 4, 10, and 12 °C, respectively. The eggs stored at 26 °C lost their viability almost completely after 4 HPS. Eyed-egg mortality increased from 13% at 0 HPS to 48.2% at 4 HPS at 26°C. These results demonstrate that egg stripping should take place within 168 °C-hours after ovulation and that complete loss of viability of the eggs occurs by 672°C-hours after ovulation. The in vivo storage method is more effective compared to in vitro storage. Also successful in vitro storage of eggs can be used atleast within 8 hours at temperatures ranging from 4 to 12ºC.