Characterization of thermal and mechanical properties of polypropylene-based composites for fuel cell bipolar plates and development of educational tools in hydrogen and fuel cell technologies

In this project we developed conductive thermoplastic resins by adding varying amounts of three different carbon fillers: carbon black (CB), synthetic graphite (SG) and multi-walled carbon nanotubes (CNT) to a polypropylene matrix for application as fuel cell bipolar plates. This component of fuel cells provides mechanical support to the stack, circulates the gases that participate in the electrochemical reaction within the fuel cell and allows for removal of the excess heat from the system. The materials fabricated in this work were tested to determine their mechanical and thermal properties. These materials were produced by adding varying amounts of single carbon fillers to a polypropylene matrix (2.5 to 15 wt.% Ketjenblack EC-600 JD carbon black, 10 to 80 wt.% Asbury Carbon's Thermocarb TC-300 synthetic graphite, and 2.5 to 15 wt.% of Hyperion Catalysis International's FIBRILTM multi-walled carbon nanotubes) In addition, composite materials containing combinations of these three fillers were produced. The thermal conductivity results showed an increase in both through-plane and in-plane thermal conductivities, with the largest increase observed for synthetic graphite. The Department of Energy (DOE) had previously set a thermal conductivity goal of 20 W/m·K, which was surpassed by formulations containing 75 wt.% and 80 wt.% SG, yielding in-plane thermal conductivity values of 24.4 W/m·K and 33.6 W/m·K, respectively. In addition, composites containing 2.5 wt.% CB, 65 wt.% SG, and 6 wt.% CNT in PP had an in–plane thermal conductivity of 37 W/m·K. Flexural and tensile tests were conducted. All composite formulations exceeded the flexural strength target of 25 MPa set by DOE. The tensile and flexural modulus of the composites increased with higher concentration of carbon fillers. Carbon black and synthetic graphite caused a decrease in the tensile and flexural strengths of the composites. However, carbon nanotubes increased the composite tensile and flexural strengths. Mathematical models were applied to estimate through-plane and in-plane thermal conductivities of single and multiple filler formulations, and tensile modulus of single-filler formulations. For thermal conductivity, Nielsen's model yielded accurate thermal conductivity values when compared to experimental results obtained through the Flash method. For prediction of tensile modulus Nielsen's model yielded the smallest error between the predicted and experimental values. The second part of this project consisted of the development of a curriculum in Fuel Cell and Hydrogen Technologies to address different educational barriers identified by the Department of Energy. By the creation of new courses and enterprise programs in the areas of fuel cells and the use of hydrogen as an energy carrier, we introduced engineering students to the new technologies, policies and challenges present with this alternative energy. Feedback provided by students participating in these courses and enterprise programs indicate positive acceptance of the different educational tools. Results obtained from a survey applied to students after participating in these courses showed an increase in the knowledge and awareness of energy fundamentals, which indicates the modules developed in this project are effective in introducing students to alternative energy sources.

Processing and mechanical properties of cast aluminum containing scandium, zirconium, and ytterbium

A series of aluminum alloys containing additions of scandium, zirconium, and ytterbium were cast to evaluate the effect of partial ytterbium substitution for scandium on tensile behavior. Due to the high price of scandium, a crucible-melt interaction study was performed to ensure no scandium was lost in graphite, alumina, magnesia, or zirconia crucibles after holding a liquid Al-Sc master alloy for 8 hours at 900 °C in an argon atmosphere. The alloys were subjected to an isochronal aging treatment and tested for conductivity and Vickers microhardness after each increment. For scandium-containing alloys, peak hardnesses of 520-790 MPa, and peak tensile stresses of 138-234 MPa were observed after aging from 150-350 °C for 3 hours in increments of 50 °C, and for alloys without scandium, peak hardnesses of 217-335 MPa and peak tensile stresses of 45-63 MPa were observed after a 3 hour, 150 °C aging treatment. The hardness and tensile strength of the ytterbium containing alloy was found to be lower than in the alloy with no ytterbium substitution.

Decision making in patients with acute abdominal pain at a university and at a rural hospital: Does the value of abdominal sonography differ?

Introduction and objectives Abdominal sonography is regarded as a quick and effective diagnostic tool for acute abdominal pain in emergency medicine. However, final diagnosis is usually based on a combination of various clinical examinations and radiography. The role of sonography in the decision making process at a hospital with advanced imaging capabilities versus a hospital with limited imaging capabilities but more experienced clinicians is unclear. The aim of this pilot study was to assess the relative importance of sonography and its influence on the clinical management of acute abdominal pain, at two Swiss hospitals, a university hospital (UH) and a rural hospital (RH). Methods 161 patients were prospectively examined clinically. Blood tests and sonography were performed in all patients. Patients younger than 18 years and patients with trauma were excluded. In both hospitals, the diagnosis before and after ultrasonography was registered in a protocol. Certainty of the diagnosis was expressed on a scale from 0% to 100%. The decision processes used to manage patients before and after they underwent sonography were compared. The diagnosis at discharge was compared to the diagnosis 2 – 6 weeks thereafter. Results Sensitivity, specificity and accuracy of sonography were high: 94%, 88% and 91%, respectively. At the UH, management after sonography changed in only 14% of cases, compared to 27% at the RH. Additional tests were more frequently added at the UH (30%) than at the RH (18%), but had no influence on the decision making process-whether to operate or not. At the UH, the diagnosis was missed in one (1%) patient, but in three (5%) patients at the RH. No significant difference was found between the two hospitals in frequency of management changes due to sonography or in the correctness of the diagnosis. Conclusion Knowing that sonography has high sensitivity, specificity and accuracy in the diagnosis of acute abdominal pain, one would assume it would be an important diagnostic tool, particularly at the RH, where tests/imaging studies are rare. However, our pilot study indicates that sonography provides important diagnostic information in only a minority of patients with acute abdominal pain. Sonography was more important at the rural hospital than at the university hospital. Further costly examinations are generally ordered for verification, but these additional tests change the final treatment plan in very few patients.

Shaping a Bright Future for Montana Tech: Developing State, National and Global Leaders in Resource Sectors

Presentation by Leigh W. Freeman. Rachel Carson's book Silent Spring published in 1962 marked the birth of concepts leading to the development of mineral resources with a balance of economic, environmental and social imperatives. Montana plays a special role in this story. It is 'the last best place.' As such it can serve as a bell-weather state for Carson's revelations. Consider: Butte as a poster child for legacy problems resulting from resource development under solely economic imperatives; and Montana as a first-adapter in 1971 of state environmental laws based on imperatives heralded with Silent Spring. What better place is there to educate and develop leaders and incubate the future of resource development in global sustainability?

Past is Prologue: Montana’s Historic Women’s Movement Re-emerges in the Progressive 1970s -- Dorothy Bradley, Marilyn Wessel & Jane Jelinski “In the Crucible of Change”

One-hundred years ago, in 1914, male voters in Montana (MT) extended suffrage (voting rights) to women six years before the 19th Amendment to the US Constitution was ratified and provided that right to women in all states. The long struggle for women’s suffrage was energized in the progressive era and Jeanette Rankin of Missoula emerged as a leader of the campaign; in 1912 both major MT political party platforms supported women suffrage. In the 1914 election, 41,000 male voters supported woman suffrage while nearly 38,000 opposed it. MT was not only ahead of the curve on women suffrage, but just two years later in 1916 elected Jeanette Rankin as the first woman ever elected to the United States Congress. Rankin became a national leader for women's equality. In her commitment to equality, she opposed US entry into World War I, partially because she said she could not support men being made to go to war if women were not allowed to serve alongside them. During MT’s initial progressive era, women in MT not only pursued equality for themselves (the MT Legislature passed an equal pay act in 1919), but pursued other social improvements, such as temperance/prohibition. Well-known national women leaders such as Carrie Nation and others found a welcome in MT during the period. Women's role in the trade union movement was evidenced in MT by the creation of the Women's Protective Union in Butte, the first union in America dedicated solely to women workers. But Rankin’s defeat following her vote against World War I was used as a way for opponents to advocate a conservative, traditionalist perspective on women's rights in MT. Just as we then entered a period in MT where the “copper collar” was tightened around MT economically and politically by the Anaconda Company and its allies, we also found a different kind of conservative, traditionalist collar tightened around the necks of MT women. The recognition of women's role during World War II, represented by “Rosie the Riveter,” made it more difficult for that conservative, traditionalist approach to be forever maintained. In addition, women's role in MT agriculture – family farms and ranches -- spoke strongly to the concept of equality, as farm wives were clearly active partners in the agricultural enterprises. But rural MT was, by and large, the bastion of conservative values relative to the position of women in society. As the period of “In the Crucible of Change” began, the 1965 MT Legislature included only three women. In 1967 and 1969 only one woman legislator served. In 1971 the number went up to two, including one of our guests, Dorothy Bradley. It was only after the Constitutional Convention, which featured 19 women delegates, that the barrier was broken. The 1973 Legislature saw 9 women elected. The 1975 and 1977 sessions had 14 women legislators; 15 were elected for the 1979 session. At that time progressive women and men in the Legislature helped implement the equality provisions of the new MT Constitution, ratified the federal Equal Rights Amendment in 1974, and held back national and local conservatives forces which sought in later Legislatures to repeal that ratification. As with the national movement at the time, MT women sought and often succeeded in adopting legal mechanisms that protected women’s equality, while full equality in the external world remained (and remains) a treasured objective. The story of the re-emergence of Montana’s women’s movement in the 1970s is discussed in this chapter by three very successful and prominent women who were directly involved in the effort: Dorothy Bradley, Marilyn Wessel, and Jane Jelinski. Their recollections of the political, sociological and cultural path Montana women pursued in the 1970s and the challenges and opposition they faced provide an insider’s perspective of the battle for equality for women under the Big Sky “In the Crucible of Change.” Dorothy Bradley grew up in Bozeman, Montana; received her Bachelor of Arts Phi Beta Kappa from Colorado College, Colorado Springs, in 1969 with a Distinction in Anthropology; and her Juris Doctor from American University in Washington, D.C., in 1983. In 1970, at the age of 22, following the first Earth Day and running on an environmental platform, Ms. Bradley won a seat in the 1971 Montana House of Representatives where she served as the youngest member and only woman. Bradley established a record of achievement on environmental & progressive legislation for four terms, before giving up the seat to run a strong second to Pat Williams for the Democratic nomination for an open seat in Montana’s Western Congressional District. After becoming an attorney and an expert on water law, she returned to the Legislature for 4 more terms in the mid-to-late 1980s. Serving a total of eight terms, Dorothy was known for her leadership on natural resources, tax reform, economic development, and other difficult issues during which time she gained recognition for her consensus-building approach. Campaigning by riding her horse across the state, Dorothy was the Democratic nominee for Governor in 1992, losing the race by less than a percentage point. In 1993 she briefly taught at a small rural school next to the Northern Cheyenne Indian Reservation. She was then hired as the Director of the Montana University System Water Center, an education and research arm of Montana State University. From 2000 - 2008 she served as the first Gallatin County Court Administrator with the task of collaboratively redesigning the criminal justice system. She currently serves on One Montana’s Board, is a National Advisor for the American Prairie Foundation, and is on NorthWestern Energy’s Board of Directors. Dorothy was recognized with an Honorary Doctorate from her alma mater, Colorado College, was named Business Woman of the Year by the Bozeman Chamber of Commerce and MSU Alumni Association, and was Montana Business and Professional Women’s Montana Woman of Achievement. Marilyn Wessel was born in Iowa, lived and worked in Los Angeles, California, and Washington, D.C. before moving to Bozeman in 1972. She has an undergraduate degree in journalism from Iowa State University, graduate degree in public administration from Montana State University, certification from the Harvard University Institute for Education Management, and served a senior internship with the U.S. Congress, Montana delegation. In Montana Marilyn has served in a number of professional positions, including part-time editor for the Montana Cooperative Extension Service, News Director for KBMN Radio, Special Assistant to the President and Director of Communications at Montana State University, Director of University Relations at Montana State University and Dean and Director of the Museum of the Rockies at MSU. Marilyn retired from MSU as Dean Emeritus in 2003. Her past Board Service includes Montana State Merit System Council, Montana Ambassadors, Vigilante Theater Company, Montana State Commission on Practice, Museum of the Rockies, Helena Branch of the Ninth District Federal Reserve Bank, Burton K. Wheeler Center for Public Policy, Bozeman Chamber of Commerce, and Friends of KUSM Public Television. Marilyn’s past publications and productions include several articles on communications and public administration issues as well as research, script preparation and presentation of several radio documentaries and several public television programs. She is co-author of one book, 4-H An American Idea: A History of 4-H. Marilyn’s other past volunteer activities and organizations include Business and Professional Women, Women's Political Caucus, League of Women Voters, and numerous political campaigns. She is currently engaged professionally in museum-related consulting and part-time teaching at Montana State University as well as serving on the Editorial Board of the Bozeman Daily Chronicle and a member of Pilgrim Congregational Church and Family Promise. Marilyn and her husband Tom, a retired MSU professor, live in Bozeman. She enjoys time with her children and grandchildren, hiking, golf, Italian studies, cooking, gardening and travel. Jane Jelinski is a Wisconsin native, with a BA from Fontbonne College in St. Louis, MO who taught fifth and seventh grades prior to moving to Bozeman in 1973. A stay-at-home mom with a five year old daughter and an infant son, she was promptly recruited by the Gallatin Women’s Political Caucus to conduct a study of Sex-Role Stereotyping in K Through 6 Reading Text Books in the Bozeman School District. Sociologist Dr. Louise Hale designed the study and did the statistical analysis and Jane read all the texts, entered the data and wrote the report. It was widely disseminated across Montana and received attention of the press. Her next venture into community activism was to lead the successful effort to downzone her neighborhood which was under threat of encroaching business development. Today the neighborhood enjoys the protections of a Historic Preservation District. During this time she earned her MPA from Montana State University. Subsequently Jane founded the Gallatin Advocacy Program for Developmentally Disabled Adults in 1978 and served as its Executive Director until her appointment to the Gallatin County Commission in 1984, a controversial appointment which she chronicled in the Fall issue of the Gallatin History Museum Quarterly. Copies of the issue can be ordered through: http://gallatinhistorymuseum.org/the-museum-bookstore/shop/. Jane was re-elected three times as County Commissioner, serving fourteen years. She was active in the Montana Association of Counties (MACO) and was elected its President in 1994. She was also active in the National Association of Counties, serving on numerous policy committees. In 1998 Jane resigned from the County Commission 6 months before the end of her final term to accept the position of Assistant Director of MACO, from where she lobbied for counties, provided training and research for county officials, and published a monthly newsletter. In 2001 she became Director of the MSU Local Government Center where she continued to provide training and research for county and municipal officials across MT. There she initiated the Montana Mayors Academy in partnership with MMIA. She taught State and Local Government, Montana Politics and Public Administration in the MSU Political Science Department before retiring in 2008. Jane has been married to Jack for 46 years, has two grown children and three grandchildren.

Progress Report on Iowa State University Burroughs Endowment Activities

Faculty in the Department of Animal Science initiated soliciting of funds in 1987 to establish a permanent endowment to recognize the distinguished career and major contributions of Dr. Wise Burroughs, a distinguished professor in animal science at Iowa State University. The endowment was established in the Iowa State University Foundation in 1991. The purpose of the fund is to support research and graduate education in the areas of fundamental factors regulating growth in food-producing animals, with emphasis on ruminants; to enhance growth of animals with the goal of improving the competitive position of ruminants as food-producing animals; and to develop innovative approaches to ruminant nutrition and/or growth enhancement as a means to improve desirability of meat produced by food animals. Dr. Burroughs’ research resulted in important and significant developments in technology for modern production systems for beef cattle. He was widely known for his ability to communicate complex ideas and research results for use by those involved in the animal industry. The current Burroughs Team has established three research projects: 1) Ghrelin--How does ghrelin affect blood and body composition in rats?; 2) Use of 25- hydroxyvitamin D3 to improve tenderness of beef; 3) Redesigning beef cattle to have a more healthful fatty acid composition.

Iowa State University ADVANCE Program, Annual Report, Year 1: June 2007

The goal of the ISU ADVANCE program is to investigate the effectiveness of a multilevel collaborative effort to produce institutional transformation that results in the full participation of women faculty in science, technology, engineering and math fields in the university. Our approach focuses on transforming departmental cultures (views, attitudes, norms and shared beliefs), practices (what people say and do), and structures (physical and social arrangements), as well as university policies, through active participation of individuals at all levels of the university.

Iowa State University Strategic Plan 2010–2015

The challenges of the 21st century demand that we focus on what we do best. To ensure that Iowa State University is a leading research university in 2050, we must recruit, support, and retain students, faculty, and staff who are committed to excellence, integrity, the free exchange of ideas, and collaboration. It is imperative that the creation, sharing, and application of knowledge be a global effort characterized by a profound respect for the diversity of people and ideas. These are the values that enrich our work and guide Iowa State’s Strategic Plan.

General Catalog 1987–1989, Iowa State University Bulletin

The Iowa State University Bulletin is a general catalog of information regarding fees, curricula and related policies and procedures.

Iowa State University Bulletin, General Catalog 1991–93

The Iowa State University Bulletin is a general catalog of information regarding fees, curricula and related policies and procedures.

General Catalog 1985–87, Iowa State University Bulletin

The Iowa State University Bulletin is a general catalog of information regarding fees, curricula and related policies and procedures.

Iowa State University Bulletin, General Catalog 1995–97

The Iowa State University Bulletin is a general catalog of information regarding fees, curricula and related policies and procedures.