Measurements of thermal radiation in ultralight metal foams with open cells

Highly porous ultralightweight cellular metal foams with open cells have attractive mechanical, thermal, acoustic and other properties and are currently being exploited for high-temperature applications (e.g. acoustic liners for combustion chambers). In such circumstances, thermal radiation in the metal foam becomes a significant mechanism of heat transfer. This paper presents results from experimental measurements on radiative transfer in Fe-Cr-Al-Y (a steel-based high-temperature alloy) foams having high porosity (95 per cent) and different cell sizes, manufactured at low cost from the sintering route. The spectral transmittance and reflectance are measured at different infrared wavelengths ranging from 2.5 to 50 μm, which are subsequently used to determine the extinction coefficient and foam emissivity. The results show that the spectral quantities are strongly dependent on the wavelength, particularly in the short-wavelength regime (less than 25 μm). While the extinction coefficient decreases with increasing cell size, the effect of cell size on foam reflectance is not significant. When the temperature is increased, the total extinction coefficient increases but the total reflectance decreases. The effective radiative conductivity of the metal foam is obtained by using the guarded hot-plate apparatus. With the porosity fixed, the effective radiative conductivity increases with increasing cell size and increasing temperature. © IMechE 2004.

GROOVE FORMATION AND INTERACTION DURING ABRASION OF COPPER.

A pin on cylinder wear rig has been built with precision stepping motor drives to both rotary and axial motions which enable accurate positional control to be achieved. Initial experiments using sapphire indenters running against copper substrates have investigated the build up of a single wear groove by repeated sliding along the same track. An approximate three dimensional ploughing analysis is also presented and the results of theory and experiment compared.

Assessing the road-damaging potential of heavy vehicles

The relative influence of various heavy vehicle design features on road-damaging potential is discussed. Testing procedures that could be used to measure the road-damaging potential of heavy vehicles are examined. A validated vehicle simulation is used to examine some of the characteristics of dynamic tyre forces generated by typical leaf sprung and air sprung articulated heavy vehicles for typical highway conditions. The proposed EC suspension test is simulated and the results compared with dynamic tyre forces generated under highway conditions. It is concluded that the road-damaging potential of a vehicle cannot be assessed by the simplistic parametric measurement of the proposed EC test. It is questionable whether a vehicle that passes the test will be any more 'road friendly' than one that fails.

Spatial repeatability of dynamic tyre forces generated by heavy vehicles

Road damage due to heavy vehicles is thought to be dependent on the extent to which lorries in normal traffic apply peak forces to the same locations along the road. A validated vehicle simulation is used to simulate 37 leaf-sprung articulated vehicles with parametric variations typical of vehicles in one weight class in the highway vehicle fleet. The spatial distribution of tyre forces generated by each vehicle is compared with the distribution generated by a reference vehicle, and the conditions are established for which repeated heavy loading occurs at specific points along the road. It is estimated that approximately two-thirds of vehicles in this class (a large proportion of all heavy vehicles) may contribute to a repeated pattern of road loading. It is concluded that dynamic tyre forces are a significant factor influencing road damage, compared to other factors such as tyre configuration and axle spacing.

Kinetics of the chemical looping oxidation of H2 by a co-precipitated mixture of CuO and Al2O3

Chemical-looping combustion (CLC) has the inherent property of separating CO2 from flue gases. Instead of air, it uses an oxygen-carrier, usually in the form of a metal oxide, to provide oxygen for combustion. When used for the combustion of gaseous fuels, such as natural gas, or synthesis gas from the gasification of coal, the technique gives a stream of CO2 which, on an industrial scale, would be sufficiently pure for geological sequestration. An important issue is the form of the metal oxide, since it must retain its reactivity through many cycles of complete reduction and oxidation. Here, we report on the rates of oxidation of one constituent of synthesis gas, H2, by co-precipitated mixtures of CuO+Al2O3 using a laboratory-scale fluidised bed. To minimise the influence of external mass transfer, and also of errors in the measurement of [H2], particles sized to 355-500μm were used at low [H2], with the temperature ranging from 450 to 900°C. Under such conditions, the reaction was slow enough for meaningful measurements of the intrinsic kinetics to be made. The reaction was found to be first order with respect to H2. Above ∼800°C, the reaction of CuO was fast and conformed to the shrinking core mechanism, proceeding via the intermediate, Cu2O, in: 2CuO+H2→Cu2O+H2O, ΔH1073 K0=- 116.8 kJ/mol; Cu2O+H2→2Cu+H2O, ΔH1073 K0-80.9 kJ/mol. After oxidation of the products Cu and Cu2O back to CuO, the kinetics in subsequent cycles of chemical looping oxidation of H2 could be approximated by those in the first. Interestingly, the carrier was found to react at temperatures as low as 300°C. The influence of the number of cycles of reduction and oxidation is explored. Comparisons are drawn with previous work using reduction by CO. Finally, these results indicate that the kinetics of reaction of the oxygen carrier with gasifier synthesis gases is very much faster than rates of gasification of the original fuel. © 2010 The Institution of Chemical Engineers.

Motor vessel "N. B. Scofield" cruise one of 1953. Cruise Report 53-S-1

(PDF contains 7 pages.)

Studies of physical, chemical, and biological oceanography in the vicinity of the Revilla Gigedo Islands during the “Island Current Survey” of 1957

ENGLISH: The tendency of the tunas, especially the yellowfin (Neothunnus macropterus) to be more abundant in the near vicinity of islands and seamounts, or "banks", than in the surrounding oceanic areas, is well known to commercial fishermen. This has been confirmed by statistical analysis of fishing vessel logbook records, which demonstrates that the catch-per-day's-fishing is, indeed, higher in the near vicinity of these features. It is hypothesized that islands and seamounts cause changes in the physical circulation or the biochemical cycle resulting in greater supplies of food for tunas in their immediate environs. In order to examine this hypothesis, and in order to study possible mechanisms involved, the "Island Current Survey" was undertaken from 8 May to 12 June, 1957, under the joint auspices of the Inter-American Tropical Tuna Commission and the Scripps Institution of Oceanography. Surveys of varying nature and extent were made from M/V Spencer F. Baird near Alijos Rocks, Clarion Island, Shimada Bank and Socorro Island (Figure 1). These studies sought to provide knowledge of the action of islands and seamounts in arresting, stalling or deflecting the mean current past them, in establishing convergence and divergence in the surface flow, in producing vertical motion (mixing and upwelling), and in influencing the primary production and the standing crops of phytoplankton and zooplankton. Each survey is discussed below in detail. Observations made at a front on 10 June will be discussed in another paper. SPANISH: Los pescadores que realizan la pesca comercial conocen muy bien la tendencia de los atunes, en particular del atún aleta amarilla (Neothunnus macropterus), de presentarse en mayor abundancia en las cercanías inmediatas a las islas y cimas submarinas, o "bancos", que en las áreas oceánicas circundantes. Este hecho ha sido confirmado par el análisis estadístico de los registros de los cuadernos de bitácora de las embarcaciones pesqueras, demostrándose que la captura par dias de pesca es, en efecto, más abundante en la inmediata proximidad de tales formaciones. Hipotéticamente se admite que las islas y las cimas submarinas provocan cambios en la circulación física o en el ciclo bioquímico, lo cual se pone de manifiesto a través de un mejor abastecimiento de alimento para los atunes en sus cercanías inmediatas. Con la finalidad de verificar esta hipótesis y de estudiar los mecanismos que ella involucra, se realizó la “Island Current Survey” del 8 de mayo al 12 de junio de 1957, bajo los auspicios de la Comisión Interamericana del Atún Tropical y de la Institución Scripps de Oceanografia. Con el barco Spencer F. Baird se hicieron observaciones de distintas clases y alcances cerca de las Rocas Alijos, la Isla Clarion, el Banco Shimada y la Isla Socorro (Figura 1). Estos estudios tuvieron por objeto adquirir conocimientos sobre la acción que ejercen las islas y cimas submarinas sobre la corriente promedio, ya sea deteniéndola, reduciendo su velocidad o desviando su curso, así como estableciendo convergencia o divergencia en su flujo de superficie, o provocando un movimiento vertical (mezcla y afloramiento) e influyendo en la producción primaria y en las existencias de fitoplancton y zooplancton. Cada operación será tratada a continuación por separado. Las observaciones hechas el dia 10 de junio sobre un frente serán objeto de otra publicación.

Some features of the autecology and distribution of chaetognatha in the Eastern Tropical Pacific

ENGLISH: The Inter-American Tropical Tuna Commission, in cooperation with the Tuna Oceanography Research program of the Scripps Institution of Oceanography, is studying in the Eastern Tropical Pacific Ocean methods of identifying waters of different characteristics that may influence the distribution and behavior of the tropical tunas. One method of attacking the problem has been to attempt to use zooplankton species as biological indicators of water masses. It has been demonstrated that certain zooplankters have ecological affinities that make them useful for identifying and tracing the movements of water masses. In the Eastern Pacific Ocean, Bieri (1957), Lea (1955), Le Brasseur (1959), Sund (1959), and Sund and Renner (1959) have presented evidence that certain species of Chaetognatha possibly can serve as indicators. The present work reports on a study of the distributions of species of Chaetognatha, obtained from various depths by means of horizontal closing-net hauls, in relation to concurrent measurements of temperature, salinity, and dissolved oxygen. Analyses of these data have provided a basis for determining which species are of potential use as biological indicators within the area of the Eastern Pacific considered in this study. SPANISH: La Comisión Interamericana del Atún Tropical, en cooperación con el programa de la "Tuna Oceanography Research" de la Institución Scripps de Oceanografía, viene estudiando en el Océano Pacífico Oriental Tropical métodos para identificar aguas de características diferentes que podrían influir en la distribución y en el comportamiento de los atunes tropicales. Uno de los métodos para abordar el problema ha sido el de intentar la utilización de especies zooplanctónicas como índices biológicos de masas de agua. Se ha demostrado que ciertos organismos del zooplancton tienen afinidades ecológicas, merced a las cuales son útiles para identificar y trazar los movimientos de las masas de agua. Bieri (1957), Lea (1955), Le Brasseur (1959), Sund (1959) y Sund y Renner (1959) presentaron evidencia de que ciertas especies de quetognatos pueden servir, posiblemente, como tales índices en el Océano Pacífico Oriental. El presente trabajo informa sobre un estudio de la distribución de las especies de quetognatos obtenidos de distintas profundidades por medio de la red de plancton que se cierra en lanzamientos horizontales y en relación con mediciones concomitantes de la temperatura, la salinidad y el oxígeno disuelto. El análisis de estos datos ofreció una base para la determinación de las especies que son potencialmente aptas para ser usadas como índices biológicos dentro del área del Pacífico Oriental a la cual se refiere este estudio.

An oceanographic atlas of the Eastern Tropical Pacific Ocean, based on data from EASTROPIC Expedition, October-December 1955.

ENGLISH: EASTROPIC Expedition was a cooperative oceanographic study of the eastern tropical Pacific Ocean conducted during the period 2 October through 16 December 1955. The five participating agencies and the ships they operated were: Scripps Institution of Oceanography (SIO), Spencer F. Baird and Horizon; Pacific Oceanic Fisheries Investigations (POFI) of the U. S. Fish and Wildlife Service, now Honolulu Biological Laboratory (HBL) of the U. S. Bureau of Commercial Fisheries, Hugh M. Smith; California Department of Fish and Game, N. B. Scofield; the Peruvian Navy, Bondu; and the Inter-American Tropical Tuna Commission which operated no vessels but supplied equipment and personnel. In addition to these planned participations in EASTROPIC Expedition, valuable information was provided by CCOFI Cruise 5512 of the California Cooperative Oceanic Fisheries Investigations, conducted during the period 29 November -16 December 1955 with the two vessels Stranger and Black Douglas. While the observational programs of most of the agencies involved, in part, special hydrographic-biological studies of known features and processes in the region (see reports listed under Data Sources) the deployment of ships and therefore of observations was sufficient that EASTROPIC Expedition could be considered a survey of the eastern tropical Pacific. This report is concerned with that aspect of the Expedition and is a presentation in atlas form of most of the hydrographic data collected. For reasons given below, emphasis has been placed on the upper 300 m of the water column. SPANISH: La Expedición EASTROPIC es un estudio oceanográfico cooperativo del Océano Pacífico Oriental Tropical llevado a cabo durante el período del 2 de octubre al 16 de dícíembre de 1955. Las cinco agencias participantes y los barcos operados por ellas son los siguientes: Scrípps Instítutíon of Oceanography (SIO) , Spencer F. Baird y Horizon; Pacific Oceanic Fisheries Investigatíons (PO'FI) del U. S. Fish and Wildlife Service, ahora Honolulu Biological Laboratory (BHL) del U. S. Bureau of Commercial Fisheries, Hugh M. Smith; California Department of Fish and Game, N. B. Scofield; la Marina Peruana, Bondu; y la Comisión Interamericana del Atún Tropical que no dirigió ningún barco pero proporcionó equipo y personal. Además de estas participaciones planeadas en la Expedición EASTROPIC, fué suministrada información de valor por el Crucero CCOFI 5512 del California Cooperative Fisheries Investigatíons, llevado a cabo durante el período del 29 de noviembre al 16 de diciembre de 1955 con los barcos Stranger y Black Douglas. Aunque los programas de observación de la mayoría de las agencias, comprendieron en parte estudios especiales hidrográficos y biológicos de las características y de los procesos conocidos de la región (véase los informes indicados bajo Fuente de Datos), el despliegue de los barcos, y por lo tanto, de las observaciones, fué suficiente para que la Expedición EASTROPIC pudiera ser considerada como una encuesta del Pacífico Oriental Tropical. Este informe se refiere a este aspecto de la Expedición y es una presentación, en forma de un atlas, de la mayoría de los datos hidrográficos recolectados. Por las razones que se dan a continuación, se le dió énfasis a los 300 m., superiores de la columna de agua. (PDF contains 136 pages.)