Growth and compaction behaviour of copper concentrate granules in a rotating drum

In order to understand the growth and compaction behaviour of chalcopyrite (copper concentrate), batch granulation tests were carried out using a rotating drum. The granule growth exhibited induction-type behaviour, as defined by Iveson and Litster [AIChE J. 44 (1998) 15 10]. There were two consecutive stages during granulation: the induction stage, during which the granules are gradually being compacted and little or no growth occurs, and the rapid growth stage, which starts when the granules have become surface wet and are rapidly growing. In agreement with earlier findings. an increased amount of binder liquid shortened the induction time. The compaction behaviour was also investigated. A displaced volume method was adopted to determine the porosity of the granules. It was shown that this technique had a limitation as it was unable to detect the reduction of the volumes of the granule pores after the granules had become surface wet. Due to this, some of the measurements were not suited for fitting a three-parameter empirical model. Attempts were made to determine whether the rapid growth stage started with the pore saturation exceeding a certain critical value, but due to the scatter in the porosity measurements and the fact that some of the measurements could not be used, it was not possible to determine a critical pore saturation, However, the porosity measurements clearly demonstrated that the porosity of the granules decreased during the induction stage of an experiment and that when rapid growth occurred, the granules had a pore saturation was around 0.85. This value was slightly lower than unity, which is most likely due to trapped air bubbles. (C) 2002 Published by Elsevier Science B.V.

Mineral chemistry, whole-rock compositions, and petrogenesis of leg 176 gabbros: Data and discussion

We report mineral chemistry, whole-rock major element compositions, and trace element analyses on Hole 735B samples drilled and selected during Leg 176. We discuss these data, together with Leg 176 shipboard data and Leg 118 sample data from the literature, in terms of primary igneous petrogenesis. Despite mineral compositional variation in a given sample, major constituent minerals in Hole 735B gabbroic rocks display good chemical equilibrium as shown by significant correlations among Mg# (= Mg/[Mg+Fe2+]) of olivine, clinopyroxene, and orthopyroxene and An (=Ca/[Ca+Na]) of plagioclase. This indicates that the mineral assemblages olivine + plagioclase in troctolite, plagioclase + clinopyroxene in gabbro, plagioclases + clinopyroxene + olivine in olivine gabbro, and plagioclase + clinopyroxene + olivine + orthopyroxene in gabbronorite, and so on, have all coprecipitated from their respective parental melts. Fe-Ti oxides (ilmenite and titanomagnetite), which are ubiquitous in most of these rocks, are not in chemical equilibrium with olivine, clinopyroxene, and plagioclase, but precipitated later at lower temperatures. Disseminated oxides in some samples may have precipitated from trapped Fe-Ti–rich melts. Oxides that concentrate along shear bands/zones may mark zones of melt coalescence/transport expelled from the cumulate sequence as a result of compaction or filter pressing. Bulk Hole 735B is of cumulate composition. The most primitive olivine, with Fo = 0.842, in Hole 735B suggests that the most primitive melt parental to Hole 735B lithologies must have Mg# ≤ 0.637, which is significantly less than Mg# = 0.714 of bulk Hole 735B.

Review and future directions in the modelling and control of continuous drum granulation

Many granulation plants operate well below design capacity, suffering from high recycle rates and even periodic instabilities. This behaviour cannot be fully predicted using the present models. The main objective of the paper is to provide an overview of the current status of model development for granulation processes and suggest future directions for research and development. The end-use of the models is focused on the optimal design and control of granulation plants using the improved predictions of process dynamics. The development of novel models involving mechanistically based structural switching methods is proposed in the paper. A number of guidelines are proposed for the selection of control relevant model structures. (C) 2002 Published by Elsevier Science B.V.

DRhoGEF2 regulates cellular tension and cell pulsations in the Amnioserosa during Drosophila dorsal closure

Coordination of apical constriction in epithelial sheets is a fundamental process during embryogenesis. Here, we show that DRhoGEF2 is a key regulator of apical pulsation and constriction of amnioserosal cells during Drosophila dorsal closure. Amnioserosal cells mutant for DRhoGEF2 exhibit a consistent decrease in amnioserosa pulsations whereas overexpression of DRhoGEF2 in this tissue leads to an increase in the contraction time of pulsations. We probed the physical properties of the amnioserosa to show that the average tension in DRhoGEF2 mutant cells is lower than wild-type and that overexpression of DRhoGEF2 results in a tissue that is more solid-like than wild-type. We also observe that in the DRhoGEF2 overexpressing cells there is a dramatic increase of apical actomyosin coalescence that can contribute to the generation of more contractile forces, leading to amnioserosal cells with smaller apical surface than wild-type. Conversely, in DRhoGEF2 mutants, the apical actomyosin coalescence is impaired. These results identify DRhoGEF2 as an upstream regulator of the actomyosin contractile machinery that drives amnioserosa cells pulsations and apical constriction.

Internal structure of the nanogratings generated inside bulk fused sílica by ultrafast laser direct writing

The aim of the present work was to characterize the internal structure of nanogratings generated inside bulk fused silica by ultrafast laser processing and to study the influence of diluted hydrofluoric acid etching on their structure. The nanogratings were inscribed at a depth of 100 mu m within fused silica wafers by a direct writing method, using 1030 nm radiation wavelength and the following processing parameters: E = 5 mu J, tau = 560 fs, f = 10 kHz, and v = 100 mu m/s. The results achieved show that the laser-affected regions are elongated ellipsoids with a typical major diameter of about 30 mu m and a minor diameter of about 6 mu m. The nanogratings within these regions are composed of alternating nanoplanes of damaged and undamaged material, with an average periodicity of 351 +/- 21 nm. The damaged nanoplanes contain nanopores randomly dispersed in a material containing a large density of defects. These nanopores present a roughly bimodal size distribution with average dimensions for each class of pores 65 +/- 20 x 16 +/- 8 x 69 +/- 16 nm(3) and 367 +/- 239 x 16 +/- 8 x 360 +/- 194 nm(3), respectively. The number and size of the nanopores increases drastically when an hydrofluoric acid treatment is performed, leading to the coalescence of these voids into large planar discontinuities parallel to the nanoplanes. The preferential etching of the damaged material by the hydrofluoric acid solution, which is responsible for the pores growth and coalescence, confirms its high defect density. (C) 2014 AIP Publishing LLC.

Surface morphology and phase transformations of femtosecond laser-processed saphire

The morphological and structural modifications induced in sapphire by surface treatment with femtosecond laser radiation were studied. Single-crystal sapphire wafers cut parallel to the (0 1 2) planes were treated with 560 fs, 1030 nm wavelength laser radiation using wide ranges of pulse energy and repetition rate. Self-ordered periodic structures with an average spatial periodicity of similar to 300 nm were observed for fluences slightly higher than the ablation threshold. For higher fluences the interaction was more disruptive and extensive fracture, exfoliation, and ejection of ablation debris occurred. Four types of particles were found in the ablation debris: (a) spherical nanoparticles about 50 nm in diameter; (b) composite particles between 150 and 400 nm in size; (c) rounded resolidified particles about 100-500 nm in size; and (d) angular particles presenting a lamellar structure and deformation twins. The study of those particles by selected area electron diffraction showed that the spherical nanoparticles and the composite particles are amorphous, while the resolidified droplets and the angular particles, present a crystalline a-alumina structure, the same of the original material. Taking into consideration the existing ablation theories, it is proposed that the spherical nanoparticles are directly emitted from the surface in the ablation plume, while resolidified droplets are emitted as a result of the ablation process, in the liquid phase, in the low intensity regime, and by exfoliation, in the high intensity regime. Nanoparticle clusters are formed by nanoparticle coalescence in the cooling ablation plume. (C) 2013 Elsevier B.V. All rights reserved.

Thin films composed of gold nanoparticles dispersed in a dielectric matrix: the influence of the host matrix on the optical and mechanical responses

Gold nanoparticles were dispersed in two different dielectric matrices, TiO2 and Al2O3, using magnetron sputtering and a post-deposition annealing treatment. The main goal of the present work was to study how the two different host dielectric matrices, and the resulting microstructure evolution (including both the nanoparticles and the host matrix itself) promoted by thermal annealing, influenced the physical properties of the films. In particular, the structure and morphology of the nanocomposites were correlated with the optical response of the thin films, namely their localized surface plasmon resonance (LSPR) characteristics. Furthermore, and in order to scan the future application of the two thin film system in different types of sensors (namely biological ones), their functional behaviour (hardness and Young's modulus change) was also evaluated. Despite the similar Au concentrations in both matrices (~ 11 at.%), very different microstructural features were observed, which were found to depend strongly on the annealing temperature. The main structural differences included: (i) the early crystallization of the TiO2 host matrix, while the Al2O3 one remained amorphous up to 800 °C; (ii) different grain size evolution behaviours with the annealing temperature, namely an almost linear increase for the Au:TiO2 system (from 3 to 11 nm), and the approximately constant values observed in the Au:Al2O3 system (4–5 nm). The results from the nanoparticle size distributions were also found to be quite sensitive to the surrounding matrix, suggesting different mechanisms for the nanoparticle growth (particle migration and coalescence dominating in TiO2 and Ostwald ripening in Al2O3). These different clustering behaviours induced different transmittance-LSPR responses and a good mechanical stability, which opens the possibility for future use of these nanocomposite thin film systems in some envisaged applications (e.g. LSPR-biosensors).

Antibacterial Ag/a-C nanocomposite coatings: The influence of nano-galvanic a-C and Ag couples on Ag ionization rates

Biofilm formation has been pointed as a major concern in different industrial applications, namely on biomedical implants and surgical instruments, which has prompted the development of new strategies for production of efficient antimicrobial surfaces. In this work, nano âgalvanic couples were created to enhance the antibacterial properties of silver, by embedding it into amorphous carbon (a-C) matrix. The developed Ag/a-C nanocomposite coatings, deposited by magnetron sputtering, revealed an outstanding antibacterial activity against S.epidermidis, promoting a total reduction in biofilm formation with no bacteria counts in all dilution. The open circuit potential (OCP) tests in 0.9% NaCl confirmed that a-C shows a positive \OCP\ value, in contrast to Ag coating, thus enhancing the ionization of biocidal Ag+ due to the nano-galvanic couple activation. This result was confirmed by the inductively coupled plasma-optical emission spectroscopy (ICP-OES), which revealed a higher Ag ionization rate in the nanocomposite coating in comparison with the Ag coating. The surface of Ag/a-C and Ag coatings immersed in 0.9% NaCl were monitored by scanning electron microscopy (SEM) over a period of 24 hours, being found that the Ag ionization determined by ICP-OES was accompanied by an Ag nanoparticles coalescence and agglomeration in Ag/a-C coating.

Alterações morfológicas e citológicas do cafeeiro (Coffea arabica L, var. Bourbon (B. Rodr.) Choussy) cultivado em solução nutritiva decorrentes das deficiências e excessos dos macronutrientes

The present work was carried out in order to study: (1) the symptoms of deficiency and excess of macronutrients (N, P, K, Ca, S, Mg) in the coffee plant (Coffea arabica L. var. Mundo novo); (2) the modifications induced by those treatments in the hystological make up of the leaves; (3) the effects of deficiency and excess on the growth and in the chemical composition of the plants. Young coffee plants were grown in nutrient solution, three treatments being used, namely: complete solution (HOAGLAND & ARNON, 1950), deficient solution, in which a giVen element was omitted, and solution with 3 times the concentration of the element under study. The main conclusions can be summaryzed as follows. 1. SYMPTOMS. Clear cut symptoms of malnutrition were observed in the treatments: -N, -P, +P, -Ca, -Mg, -S and +S; the signals - and + stared respectively for deficient and excess level. 2. HISTOLOGICAL EFFECTS. The most definite alterations took place in the treatments +P, -Mg and +S. Usually the characteristics of the chloroplasts were affected: loss of the green color and coalescence into irregular bodies.

Sintomas externos (morfológicos) e internos (anatômicos), observados em folhas de goiabeira (Psidium guajava L.), de plantas cultivadas em solução nutritiva com carência dos macronutrientes

The present work was carried out in order to study: (1) The symptoms of deficiency of macronutrients (N, P, K, Ca, Mg, S) in guava (Psidium guajava L.). (2) The modifications induced by those treatments in the histological make up of the leaves. Young guava plants were grown in nutrient solution two treatments being used, namely: complete solution (HOAGLAND and ARNON, 1950), deficient solution, in which a given element was ommitted. The main conclusions can be summaryzed as follows. a) Symptoms Clear cut symptoms of malnutrition were observed in the treatments: -N, -P, -Ca, -K, -Mg, and -S. The signal - stared respectively for deficient level. b) Histological effects Usually the characteristics of the chloroplasts were affected: loss of the green and coalescence into irregular bodies.

Verwendung von acetyliertem Distärkephosphat und Distärkeadipat als Stabilisator in einer Lachscreme auf Emulsionsbasis

The present Bachelor thesis gives an overview of the influence of some starch esters (acetylated distarch phosphate (E 1414) and adipate (E1422)) as stabilizing agents in a salmon-emulsion-cream. The aim of this work was the development of an optimal recipe. Different concentrations of starches were used in combination with xanthan gum. The methods were used to describe the rheological, microphotographical, microbiological, chemical and sensorial characteristics of the spread. The analysis of determination and development of droplet size showed a significant reduction in coalescence process. Rheological experiments indicated that high concentrations of E 1414 are necessary getting a slightly higher viscosity than in case of the E 1422 creams. The microbiological results showed minimal differences. All tested samples showed high stability against oxidation. For the use of a new recipe acetylated distarch adipate is the better choice in this case.

Bilateral uveal pigmented alterations with remarkable evolution: long term follow-up in a case of possible bilateral diffuse uveal melanocytic proliferation

Purpose: to describe a case of probable bilateral diffuse uveal melanocytic proliferation (BDUMP) with scleral involvement, free from systemic malignancies and cataract. Methods: fifty months of follow up with recurrent complete ophthalmological examinations, including fundus photography, fluorescein/indocyanine green angiography (FA) and optical coherence tomography (OCT). Investigations also included an electroretinography (ERG) and histological examination of scleral biopsy. Extraocular malignancies were repeatedly searched. Results: the patient was a 61 year-old Italian man with chronic hepatitis type C. At first visit his best corrected visual acuity (BCVA) was 20/32 in OS and 20/25 in OD. Funduscopy showed multiple patch-shaped pigmented alterations involving macular region and mid retinal periphery. FA showed corresponding areas of late-phase hyperfluorescent pinpoints (figure 1a, OS) and intemediate-phase hypocyanescence (figure 1b, OS), with subtle serous neurosensory retinal detachment confirmed by OCT. Photopic and scotopic ERG tested normal. Systemic prednisone was administered for one month without any improvement. After ten months round pigmentary lesions appeared also in superior scleral surface of both eyes. Biopsy allowed to disclose slightly pigmented spindle cells. BCVA worsened for further 10 months, with enlargement of FA alteration areas but lenses still clear. After 30 months spontaneous coalescence and atrophy of retinal lesions started, paralleled by progressive visual recovery. At the end of our follow up BCVA was 20/25 in OU while scleral pigmentary lesions remained unchanged. Conclusions: we report the case of a patient with main features of BDUMP and some unusual findings. Although not all classical diagnostic criteria were fulfilled, the presence of scleral pigmented lesions and spontaneous visual recovery may enlarge clinical spectrum of the disease.

Perturbation expansions of multilocus fixation probabilities for frequency-dependent selection with applications to the Hill-Robertson effect and to the joint evolution of helping and punishment.

Natural populations are of finite size and organisms carry multilocus genotypes. There are, nevertheless, few results on multilocus models when both random genetic drift and natural selection affect the evolutionary dynamics. In this paper we describe a formalism to calculate systematic perturbation expansions of moments of allelic states around neutrality in populations of constant size. This allows us to evaluate multilocus fixation probabilities (long-term limits of the moments) under arbitrary strength of selection and gene action. We show that such fixation probabilities can be expressed in terms of selection coefficients weighted by mean first passages times of ancestral gene lineages within a single ancestor. These passage times extend the coalescence times that weight selection coefficients in one-locus perturbation formulas for fixation probabilities. We then apply these results to investigate the Hill-Robertson effect and the coevolution of helping and punishment. Finally, we discuss limitations and strengths of the perturbation approach. In particular, it provides accurate approximations for fixation probabilities for weak selection regimes only (Ns < or = 1), but it provides generally good prediction for the direction of selection under frequency-dependent selection.

Cell-free reconstitution of vacuole membrane fragmentation reveals regulation of vacuole size and number by TORC1.

Size and copy number of organelles are influenced by an equilibrium of membrane fusion and fission. We studied this equilibrium on vacuoles-the lysosomes of yeast. Vacuole fusion can readily be reconstituted and quantified in vitro, but it had not been possible to study fission of the organelle in a similar way. Here we present a cell-free system that reconstitutes fragmentation of purified yeast vacuoles (lysosomes) into smaller vesicles. Fragmentation in vitro reproduces physiological aspects. It requires the dynamin-like GTPase Vps1p, V-ATPase pump activity, cytosolic proteins, and ATP and GTP hydrolysis. We used the in vitro system to show that the vacuole-associated TOR complex 1 (TORC1) stimulates vacuole fragmentation but not the opposing reaction of vacuole fusion. Under nutrient restriction, TORC1 is inactivated, and the continuing fusion activity then dominates the fusion/fission equilibrium, decreasing the copy number and increasing the volume of the vacuolar compartment. This result can explain why nutrient restriction not only induces autophagy and a massive buildup of vacuolar/lysosomal hydrolases, but also leads to a concomitant increase in volume of the vacuolar compartment by coalescence of the organelles into a single large compartment.

Bilateral Uveal Pigmented Alterations With Remarkable Evolution: Long Term Follow-Up in a Case of Possible Bilateral Diffuse Uveal Melanocytic Proliferation

Purpose: to describe a case of probable bilateral diffuse uveal melanocytic proliferation (BDUMP) with scleral involvement, free from systemic malignancies and cataract. Methods: fifty months of follow up with recurrent complete ophthalmological examinations, including fundus photography, fluorescein/indocyanine green angiography (FA) and optical coherence tomography (OCT). Investigations also included an electroretinography (ERG) and histological examination of scleral biopsy. Extraocular malignancies were repeatedly searched. Results: the patient was a 61 year-old Italian man with chronic hepatitis type C. At first visit his best corrected visual acuity (BCVA) was 20/32 in OS and 20/25 in OD. Funduscopy showed multiple patch-shaped pigmented alterations involving macular region and mid retinal periphery. FA showed corresponding areas of late-phase hyperfluorescent pinpoints (figure 1a, OS) and intemediate-phase hypocyanescence (figure 1b, OS), with subtle serous neurosensory retinal detachment confirmed by OCT. Photopic and scotopic ERG tested normal. Systemic prednisone was administered for one month without any improvement. After ten months round pigmentary lesions appeared also in superior scleral surface of both eyes. Biopsy allowed to disclose slightly pigmented spindle cells. BCVA worsened for further 10 months, with enlargement of FA alteration areas but lenses still clear. After 30 months spontaneous coalescence and atrophy of retinal lesions started, paralleled by progressive visual recovery. At the end of our follow up BCVA was 20/25 in OU while scleral pigmentary lesions remained unchanged. Conclusions: we report the case of a patient with main features of BDUMP and some unusual findings. Although not all classical diagnostic criteria were fulfilled, the presence of scleral pigmented lesions and spontaneous visual recovery may enlarge clinical spectrum of the disease.