一株放线菌发酵产物抗肿瘤活性的研究

本学位论文主要研究一株放线菌发酵产物的抗肿瘤活性。先对该株放线菌进行活化培养，然后进行大批量发酵，发酵液经过冷冻离心，对离心得到的沉淀和上清液用不同极性的有机溶剂进行萃取，得到六个浸膏样品。对六个样品进行初步抗肿瘤活性检测。 然后对活性浸膏进行分离纯化和活性跟踪。本论文主要进行了如下的工作： 1、对菌种进行活化培养，利用该菌株在280C，200r.min-1条件下进行发酵实验，发酵时间为72h,发酵总量为15L。发酵液经过离心得到上清液和沉淀两部分。 2、分别用石油醚、乙酸乙酯、正丁醇萃取沉淀和上清液，得到编号为1—6的六个浸膏样品，对六个浸膏样品进行初步的细胞毒性和抗HepG2肿瘤活性实验，得出结论为5号样品活性最高。在没有分离纯化的情况下GI50达到0.76µg/mL。 3、对5号样品进行TLC实验，找出能够较好分离5号样品中各组分的溶剂组合，最后得出在氯仿：甲醇=8：1时分离效果较好。然后利用氯仿：甲醇=8：1的溶剂组合作为洗脱剂对5号样品进行过硅胶柱分离纯化并进行活性跟踪分离。 4、对分离纯化后得到的样品进行活性跟踪和结构分析。分离后得到样品A，在其浓度为10µg/ml时，抗肿瘤实验细胞的生长率为73.5%。在浓度为1.0mg/ml时，抗单纯疱疹病毒率（HSVⅡ）为74.5%。结构分析得知其分子式最可能为C41H43N8O4. This dissertation studied about the anti-tumor activity of an actinomycete fermentation product. First, we cultured the actinomycete. Second, we fermented it in large quantities, and then centrifuged the fermentation fluid; the next step is that we extract sedimentation and supernatant in different polar organic solvents, in turn to obtained six samples, which were detected about anti-tumor activity. Last, we purified active sample and tracked activity of it. We carried out the following research work: 1. Activation, culture and screening of the actinomyces was carried on. We used the screening strain to carry on the fermentation when the conditions are 280C，200r.min-1,the fermentation time is 72h. Fermentation fluid volume is 15L.And we obtained sedimentation and supernatant after fermentation fluid was centrifuged. 2. We used Petroleum ether, ethyl acetate, n-butanol separately to extract sedimentation and supernatant, and obtained six samples that were numbered 1-6. From the preliminary cell toxicity and the anti-tumor（HepG2） bioactivity experiment, we found that No.5 sample has the highest activity in the samples; the GI50 was 0.76µg/ml which has not been purified. 3. We Carried on TLC experiment on the No.5 sample, found the solvent composition that can separate each component of the No.5 sample. At last, we found that when the proportions are tri-chloromethane: methyl alcohol = 8:1, the Separation result was the best, and then we used the Solvent composition which proportion are tri-chloromethane: methyl alcohol = 8:1 as eluant to Purify No.5 sample by silica gel column. 4. We tracked the activity of pure sample obtained from Purification and analyzed structure of these substances. We got a compound A after separation, and the cell growth rate was 73.5% when its concentration was 10µg/ml. The anti-virus（HSVⅡ） rate was 74.5% when its concentration was 1.0mg/ml. We analyzed the Structure of A, and informed its molecular formula that was the most likely for C41H43N8O4.

链霉菌S227抗耐药菌活性成分的研究

本论文以从四川峨嵋山森林土壤中分离筛选获得的一株产抗耐药性活性化合物的链霉菌S227为材料，对发酵液中活性物质的分离纯化及抗耐药性活性进行了研究。 建立了抗耐药性活性的定性、定量检测方法。建立的管蝶法活性定量检测的标准回归方程为：D=4.8229Ln(C)+3.6326 R=0.9972 ；纸片法活性定量检测的标准回归方程为：D=5.5Ln(C)-12.794 R=0.999。 根据建立的样品活性的检测方法，测定了发酵液的初始活性。实验证明活性物质的温度、pH稳定性好。 通过活性的定性、定量追踪方法，分别利用等体积的石油醚、乙酸乙酯、正丁醇在不同的pH梯度下萃取，确定了pH3条件下正丁醇能最大程度的萃取活性物质，说明活性物质极性很大。对正丁醇萃取相经过两次硅胶柱层析及薄层层析分离得到具有抗耐药菌活性的纯化样品S227-4。 经过核磁共振氢谱、碳谱数据分析初步确定S227-4为四聚糖，通过糖的水解实验初步确定S227-4由葡萄糖和半乳糖组成。 纸片法活性检测表明S227-4具有抗耐药菌活性。采用MIC测定法对该样品抗耐药活性进行研究。在证明该样品本身不具有抗菌活性的基础上，以临床分离的耐药性金黄色葡萄球菌为指示菌，考察了该样品与抗生素联合使用时对耐药菌抗生素MIC（最小抑菌浓度）值的影响，结果表明在不影响菌体生长的浓度条件下，该样品能明显降低多株耐药菌对多种抗生素的MIC值，不同程度地恢复所测试耐药菌对相应抗生素的敏感性。如S227-4与青霉素钠联用可以使S. aureus 12352的MIC降低8倍，而与红霉素联用可以使S. aureus 12334的MIC降低128倍。 The purification process and the activity of the anti bacterial drug resistance compounds produced by Streptomyces S227 isolated from the forest soil sample of the Mountain E’MEI in Sichuan Province were studied in this thesis. Quantitative and qualitative activity assay methods of the active compounds were established. The regression equation of the tube method was D=4.8229Ln(C)+3.6326, R=0.9972. The regression equation of the paper method was D=5.5Ln(C)-12.794, R=0.999. According to the established activity assay method, the incipient activity of the broth was evaluated. And it was proved that the stability of the active compounds was good. By quantitative and qualitative activity tracing method, petroleum ether, ethyl acetate and butanol were used to extract the active compounds at different pH. The result showed that butanol was the most effective agent for active component recovery at pH3. From the butanol extraction a purified sample, S227-4, was isolated by silica gel column chromatography and thin-layer chromatography . S227-4 was proved to be a tetra- saccharide by 1H-NMR and 13C-NMR. And its monosaccharides include glucose and galactose by hydrolysate analysis. The anti-drug resistant activity of S227-4 was tested in vitro by MICs assay using different drug resistant Staphylococcus aureus strains isolated clinically. The sample itself showed no anti-microbial activity in growth inhibitory experiment, but when it was used together with different antibiotics, it could remarkably decrease the MICs of different clinically isolated drug-resistant bacterial strains to these antibiotics. For example, when S227-4 was used with penicillin, the MIC of S. aureus 12352 decreased 8 times compared with that when penicillin was used alone. Meanwhile when it was used with erythromycin the MIC of S. aureus 12334 deceased 128 times compared with erythromycin alone.

三孢布拉氏霉发酵产β-胡萝卜素的研究

本论文研究了利用三孢布拉氏霉(Blakeslea trispora)发酵产β-胡萝卜素的培养条件。主要包括：发酵培养基的确定，发酵条件的优化。还考察了发酵菌丝体中β-胡萝卜素的提取方法及薄层层析等。 首先研究了培养基成分对三孢布拉氏霉发酵产β-胡萝卜素的影响。确立了玉米淀粉作为碳源，黄豆粉（热榨）作为氮源，棉籽油作为植物油的发酵培养基配方，其成分为：玉米淀粉 3％，黄豆粉（热榨） 2％，棉籽油 3％，KH2PO4 0.2%，MgSO4·7H2O 0.2%，维生素B1 0.002％，pH值6.0。 其次，通过比较不同的发酵影响因子，分别得到最适的条件：如三孢布拉氏霉正负菌接种比例为1.3：0.7，培养基pH值为7.0（灭菌后），发酵促进因子为Triton X-100。并采用正交试验法，确定其最佳发酵条件为正负菌接种比例1.3/0.7，发酵培养基pH为7.0，在培养基中添加表面活性基Triton X-100 0.08％。使该菌株产β-胡萝卜素的量达到0.73g/L，较初始发酵条件提高了3.3倍。 研究中还找到一个简便有效的对β-胡萝卜素的提取方法，选用盐酸-热处理法进行细胞破壁，并选用沸程为60～90℃的石油醚进行萃取。 用三孢布拉霉菌丝体内类胡萝卜索的石油醚提取液点样于硅胶G板，以丙酮：石油醚（5：95）为展开剂能将β-胡萝卜素与其它类胡萝卜索分离。该方法简便快速，并有一定实用价值。 The fermentative conditions of β-carotene by Blakeslea trispora have been investigated. These conditions include fermentation medium, the optimization of some fermentation factor. The extracting methods and the TLC of carotenoids were also researched. Firstly, the effects of composition of fermentation medium on the yield of β-carotene were studied. the results showed that the best fermentation medium was corn starch 3％，soybean power 2％，cottonseed oil 3％，KH2PO4 0.2%，MgSO4·7H2O 0.2%，vitamin B1 0.002％，pH value 6.0. Secondly, through compared some factors, such as different proportion of plus and minus strains, pH value, nonionic surfactants, respective best values have been obtained. The best proportion of plus and minus strains is 1.3:0.7, pH value of fermentation medium (sterilized) is 7.0, fermentation accelerant which acts as surfactants is Triton x-100. Farther on, the fermentative conditions were optimized through orthogonal experiment, the optimization showed that proportion of plus and minus strains is 1.3:0.7，pH value is 7.0, content of Triton x-100 is 0.08％. And the yield of β-carotene reached 0.73g/L, which was up to 3.3 times through the fermentation. In the extracting study, it has showed hydrochloric acid-heat treatment is a simple, convenient and effective extracting methods is which was used to destroy the cell wall, and the extracting organic solvent is petroleum ether whose boiling range is 60~90 ℃. In the TLC experiments, extracting contents in the petroleum ether were spotted in the silicagel plate, and the mixed liquor of acetone and petroleum ether (5：95) is developping agent, which can distinguish β-carotene from other carotenoids. It is a simple and quick technique.

钻井废水可生化性研究及处理技术探索

钻井废水是油气井开采钻探过程中产生的废水，钻井废水成分复杂，有机物浓度高、色度高、悬浮物浓度高，水质变化大，排放点分散，不经处理排放会污染环境，破坏生态。随着石油工业的不断发展和国家环保法律法规的日益严格，钻井废水的治理也越来越受到重视。如何采用经济有效的方法处理废弃钻井液，对油气井开采业的可持续发展具有重要意义。本论文以遂宁磨153 井的钻井废水为主要研究对象，在对废水进行絮凝沉降预处理和生物法处理探索的基础上，针对钻井废水可生化性差的特点，采用水解酸化和Fenton 试剂改善钻井废水的可生化性，对反应过程进行了比较详细的考察，对可生化性改善的机理进行了探索。主要研究结论如下：1 用PFS 和PAC 配制的混合混凝剂对钻井废水COD 的去除效果比较显著，在最佳条件下COD 的去除率可达75%，且絮体沉降速度较快，出水pH 保持中性；2 水解酸化法处理钻井废水可显著改善废水的可生化性。经48 小时水解酸化处理，钻井废水的理论BOD5可提高约22 倍，表观BOD5/COD值由0.004 提高到0.034。用接触氧化反应器处理经水解酸化处理后的废水，处理效果比较稳定，COD平均去除率达35.5%；3 研究了Fenton反应中各影响因子对废水COD去除率、BOD5/COD的影响并分析其作用机制，确定了最佳条件：初始pH为4.0，H2O2/Fe2+(摩尔浓度比)为20，H2O2/COD（质量浓度比）为1，反应时间为2 个小时。此条件下，废水的COD去除率约为40%，BOD5/COD值从0.002～0.003 提高至0.15～0.2，可生化性得到很大提高。本论文的主要创新点在于：1 以成分复杂、水质变化大的气井钻井废水为研究对象，从理论BOD 和表观BOD 两方面对水解酸化过程中废水可生化性的变化进行了分析；2 对Fenton 试剂改善钻井废水可生化性的过程、主要影响因素进行了比较详细的考察。本论文的研究成果，可为生物法处理钻井废水的深入研究提供理论依据。Drilling wastewater is produced in the process of oil-gas well drilling,because of its complicated composition, high concentrate of organic compound andsuspended solid, high chroma, levity of water quality and decentralization ofdischarge point, it pollutes environment seriously if discharged without treatment.With the development of petroleum industry and the issuing of more strict laws forenvironmental protection, it has been paid more and more attention on drillingwastewater treatment. It is of great importance for the sustainable development ofoil-gas well drilling to treat drilling wastewater by economical and effective methods.In this paper, drilling wastewater of Mo No.153 well in Suining was studied asthe main object. On the basis of research on pre-treatment with flocculant andbiological treatment, and according to the character of poor biodegradability, thedrilling wastewater was treated by hydrolytic acidification and Fenton’s reagent toimprove its biodegradability. The process and mechanism of biodegradabilitychanging were investigated. The primary conclusions are:1 It is effective to treat drilling wastewater with mixing PFS and PAC asflocculant. The removal rates of COD came up to 75% under optimal conditions, thesedimentation rate of flocculation is rapid, and the pH value of treated water remainedneutral;2 The biodegradability of drilling wastewater was highly improved afterhydrolytic acidification process. The theoretic BOD5 of drilling wastewater increasedby 22 times and its detected BOD5/COD ratio increased from 0.004 to 0.034 afterhydrolytic acidification for 48 hours. The wastewater after hydrolytic acidificationwas treated by biological contact oxidation reactor. Stable treatment performance was achieved, and the average removal rates of COD came up to 35.5%;3 The effects of various affection factors on the removal efficiency of COD andBOD5/COD radio in treating drilling wastewater by Fenton’s reagent wereinvestigated and the mechanism was analyzed. The optimal conditions were: initialpH of solution was 4.0, the molar ratio of H2O2 and Fe2+ was 20, the concentrationratio of H2O2 and COD was 1 and the reaction time was 120 min. Under the aboveconditions, the removal efficiency was about 40% and the ratio of BOD5 and CODincreased from 0.002 ¡« 0.003 to 0.15 ¡« 0.2. The biodegradability of drillingwastewater was greatly improved.The innovations of this thesis are:1 The drilling wastewater was taken as the research object which hascomplicated composition and variational water quality, and the changes ofbiodegradability were analyzed from theoretic BOD and detected BOD aspects duringhydrolytic acidification process;2 The biodegradability changing process and primary affection factors of drillingwastewater treating by Fenton’s reagent were investigated.The results of this study could provide theoretic foundation for further researchon biological treatment of drilling wastewater.

Demulsification of emulsions exploited by enhanced oil recovery system

Experimental data are presented to show the influence of the enhanced oil recovery system's components, alkali, surfactant, and polymer, on the demulsification and light transmittance of the water separated from the emulsions. Among which, the effects of surfactants, polyoxyethylene (10) alkylphenol ether (OP-10) and sodium petroleum sulfonate (CY-1) on emulsion stability, are the strongest of any component, the effects of polymer, hydrolytic polyacrylamide (HPAM) 3530S, on emulsion stability are the weakest. This research also suggests a possible emulsion minimization approach, which could be implemented in refineries utilizing microwave radiation. Compared with conventional heating, microwave radiation can effectively enhance the demulsification rate by an order of magnitude and increase the light transmittance of the water separated from the emulsions. The demulsification efficiency may reach 100% in a very short. time under microwave radiation.

高效石油烃降解菌的分离鉴定及降解特性

为获得更为丰富的石油降解微生物资源,从沈抚污灌区石油污染土壤和实验室高浓度柴油胁迫土壤中筛选出了4株高效石油烃降解菌SF-422、SF-428、SF-433和SYS-1.这4株菌总石油烃(Total petroleum hydrocarbon/TPH)生物降解率为67.4%~73.6%.经过16项生理生化特性实验和16S rDNA序列分析鉴定,SF-433,SF-428,SF-422和SYS-1分别为蜡状芽孢杆菌(Bacillus cereus),木糖氧化无色杆菌(Achromobacter xylosoxidans),施氏假单胞菌(Pseudomonas stutzeri)和洋葱伯克霍尔德氏菌(Burkholderia cepacia).纯烃降解定性实验表明所筛选出的4株高效降解菌均能够利用正十六烷、苯、菲和环己烷为唯一碳源生长,其中菌株SF-428和SYS-1显示了对芳烃及环烷烃较强的利用能力.

石油污染土壤的生物修复技术

The soil contaminated by petroleum hydrocarbons and main methods of cleaning the pollutants were dealt with in the paper.The key principles,technological types, effect factors ,consolidation of the technology,present situation and development of the bioremediation of the soil contaminated by petroleum hydrocarbons were presented.