Technological aspects of preservation and processing of edible shell fishes IV. Comparative efficiency of different glazes in the preservation of frozen crab meat

The present work was undertaken to enlighten upon the comparative efficiency of different glazes in improving the quality of frozen crab meat (Scylla Serrata).

Bacterial aspects of quality of phosphate treated frozen prawns

Changes in physical, organoleptic and biochemical characteristics of phosphate treated prawns and frog legs during storage have been studied in detail by Mathen and Pillai, (1970). Adoption of the recommended method by the industry in the freezing of prawns made it necessary to assess the influence of such treatment on the bacterial quality. This aspect assumes more importance in view of the proposed compulsory bacterial standards for raw frozen prawns. This note gives an account of the results on the influence of phosphate treatment on bacterial quality of raw frozen shrimp meat.

Quality loss in prawns due to double freezing

Icing is the practice for preserving prawns on board fishing boats in India. Majority of these boats need to preserve the catch only for a few hours because of the short duration of the fishing trip. However, with the anticipated introduction of a considerable number of bigger fishing vessels which can remain in the fishing ground for longer periods, more than fortnight, preservation methods, other than icing are required to retain prime quality. Freezing and cold storage of whole prawns on board followed by thawing and processing on land is a possible proposition. The extent of quality loss in prawns during these operations is one of the important points to be considered. Hence, laboratory scale studies were undertaken on double freezing of prawns and the results are dealt within this communication.

Quality control in the Indian fish processing industry

Quality control is defined as the continuing assessment of a current operation. It is usually the responsibility of an individual or a department directly responsible to the management. In the case of fish and fishery products, quality control includes all the steps taken to protect the quality of the material since catch until it reaches the consumer.

Cathodic protection of the hulls of fishing trawlers in India

Nearly 10,000 mechanised fishing trawlers mostly built of wood and about 100 trawlers built of steel besides a few fiberglass reinforced plastic and a couple of ferro-cement boats constitute the modern fishing fleet of India at present. Metallic corrosion in sea water is a very well-known phenomenon in all ships and various other marine structures; the exact financial loss and the material breakdowns have never been fully realized among the trawler owners in India. The Central Institute of Fisheries Technology at Cochin has been studying these problems for some years and has been able to assess the significance of underwater corrosion particularly of the hull below water line in the trawlers and suitable remedial measures have been suggested in this paper.

Technological aspects of preservation and processing of edible shell fishes V. Cold storage changes in mussels (Mytilus edulis) and clams (Villortia [i.e. Villorita] sp.)

The changes in chemical, bacteriological and organoleptic qualities of mussels and clams during freezing and subsequent frozen storage have been studied in relation to the holding time in ice prior to freezing and the shelf-life of the product is determined.

Studies on thermal deffusivity [i.e. diffusivity] and conductivity of fresh and dry fish

Thermal diffusivity (α) and conductivity (K) of fresh and dry cured fish at different moisture levels were investigated by a calorimeter (regular regime) method and transient line source technique. Thermal conductivity has a linear correlation with packing density and percentage water content. K values calculated from formula method and line source technique are comparable.

Bacteria in the inshore environment at Karwar and Vengurla

Qualitative and quantitative studies of the bacterial population in two stations, Karwar and Venguria, have been made for a period of eight months, which revealed the pattern of distribution to be almost similar to that from east coast and west coast.

On the comparative efficiency of trawls made of cotton, polyethylene and combination of both the materials

The merits and demerits of cotton, polyethylene and combination of the two materials ascertained on the basis of cost, wear and tear, maintenance, total catch and qualitative analysis of the catch are discussed by making comparative fishing experiments with the three trawl gears made of these materials. The study can be concluded with a suggestion for switching over to polyethylene twisted monofilaments for better, in case of bottom trawls without in any way adversely affecting the catch of shrimps and at the same time for enhanced fish catch. Even though the combination net is found to be equal in efficiency as the polyethylene net this idea cannot be conveniently adopted from the point of view of economy.

Utilization of prawn waste: isolation of chitin and its conversion to chitosan

process is described for the preparation of chitosan from prawn waste. The process involves extraction of protein using 0.5% sodium hydroxide solution, bleaching the protein free mass with bleach liquor containing 0.3-0.5% available chlorine followed by demineralisation with 1.25 N hydrochloric acid in the cold and deacetylation using 1:1 (w/w) sodium hydroxide solution at 100°C for 2 hours.

Preliminary study on the rearing of Chilka prawn ('Kantala') Penaeus indicus H. Milne-Edwards in the brackish water ponds at Keshpur (Orissa)

Results of experimental rearing of Penaeus indicus without supplemental feeding in unfertilized brackish water ponds in fore-shore of Chilka lake are presented in this paper. Higher rate of survival was recorded where advanced juveniles were stocked and lower rate of survival was recorded where early juveniles were stocked. The average growth rate recorded from the rearing experiments was higher than the average growth rate of Penaeus indicus recorded from the adjoining Chilka Lake which indicates the promising future of prawn farming in and around the lake. Analysis of gut contents revealed that Penaeus indicus could efficiently utilise algal and higher plant matter present in the ponds. No noticeable differences in daily growth rates were noticed between early and advanced juveniles in rearing experiments.

Modification to the bilge and sea water pumps fitted in 17.5 metre Jingha type trawlers

This paper brings out the difficulties encountered with the Bilge and sea water circulating pumps which are fitted and drawn in series along with a fresh water pump in the 17.5 m fishing trawlers.

Spoilage of spotted seer (Scomberomorous guttatus) during ice storage

Quality deterioration of seer held directly in contact with ice, in different forms, fillets and chunks, and of chunks held in ice but without direct contact, was studied for a period of 15 days. While the chunks held out of contact with ice were acceptable up to 13 days based on organoleptic evaluations, the chunks and fillets held in direct contact with ice were acceptable only up to 10 days. The order of preference of the samples at any interval of ice storage was chunks held out of contact with ice>chunks held directly in ice>fillets held directly in ice. The changes in the chemical quality of these samples were also in the same order, the deterioration being maximum in fillets and least in chunks kept out of contact with ice.

Note on an abnormal catch of Catla catla in Hirakud reservoir

During the 1973 experimental fishing operations in the Hirakud Reservoir, it was found that though 11 species of fish occur in the reservoir only four species (Silondia silondia, Labeo fimbriatus, Cirrhina mrigala and Catla catla) predominate the catch in the order of abundance. This paper gives details of fishing operations and gears utilised.

On the measurement of concentration of blanching brine by electrical conductivity method

Blanching is an important operation in the shrimp canning process, in order to bring down the moisture content of the product to the required level, to allow the proteins to coagulate and to give proper texture, shape and characteristic pink colour to the meat. It has been observed that among other factors responsible for fluctuations in the drained weight in the canned prawns, concentration of brine used for blanching and the duration of blanching are important (Varma, Chaudhury and Pillai 1961). The papers gives details of experiments