Rapid Surface Plasmon Resonance Immunoassay for the Determination of Deoxynivalenol in Wheat, Wheat Products, and Maize-Based Baby Food

A rapid screening assay (9 min/sample) has been developed and validated for the detection of deoxynivalenol in durum wheat, wheat products, and maize-based baby foods using an SPA biosensor. Through a single laboratory validation, the limits of detection (LOD) for wheat, wheat-based breakfast cereal, and maize-based baby food were 57, 9, and 6 mu g/kg, respectively. Intra-assay and interassay precisions were calculated for each matrix at the maximum and half-maximum European Union regulatory limits and expressed as the coefficient of variation (CV). All CVs fell below 10% with the exception of the between-run CV for breakfast cereal. Recoveries at the concentrations tested ranged from 92 to 115% for all matrices. Action limits of 161, 348, and 1378 mu g/kg were calculated for baby food, wheat-based breakfast cereal, and wheat, respectively, and the linear range of the assay was determined as 250-2000 mu g/kg.

Digestibility of different wheat products in white shrimp Litopenaeus vannamei juveniles

Dry matter, energy, crude protein and amino acid apparent digestibility coefficients (ADCs) were determined in white shrimp juveniles for six wheat products: hard red winter whole grain meal (HWG), Rayon whole grain meal (RWG), Durum whole grain meal (DWG), hard red winter clear flour (HCF), mixed wheat 2nd clear flour (MCF) and semolina (S). The test diets included 30% of the test ingredients and 70% of a ground commercial diet supplemented with 1% chromic oxide and 1% sodium alginate. Amino acid contents in the ingredients, diets and feces were analyzed, and digestibility was determined by difference in order to minimize the impact of endogenous amino acid losses; crude protein and amino acids ADCswere adjusted for dietary preprandial losses in seawater. In general, nutrients digestibility was far higher in the wheat products than in the fish meal-based reference diet. Drymatter and crude proteinADCswere not statistically different amongwheat products (from84 to 96% and from88 to 107% respectively). Energy ADCs were significantly higher for clear flours (96% for HCF and MCF) than forwhole grainmeals and S (from83 to 86%). Total amino acids (TAA) and essentialamino acids (EAA) ADCs, once adjusted for preprandial leaching fromthe experimental diets, ranged from81 to 89% and from 58 to 81% respectively, and were statistically comparable among wheat products. Low Thr ADCs appear as a common feature of the amino acids digestibility profiles for whole grain meals, clear flours, or semolina.

Down-regulation of the CSLF6 gene results in decreased (1,3;1,4)-beta-D-glucan in endosperm of wheat

(1,3;1,4)-beta-d-Glucan (beta-glucan) accounts for 20% of the total cell walls in the starchy endosperm of wheat (Triticum aestivum) and is an important source of dietary fiber for human nutrition with potential health benefits. Bioinformatic and array analyses of gene expression profiles in developing caryopses identified the CELLULOSE SYNTHASE-LIKE F6 (CSLF6) gene as encoding a putative beta-glucan synthase. RNA interference constructs were therefore designed to down-regulate CSLF6 gene expression and expressed in transgenic wheat under the control of a starchy endosperm-specific HMW subunit gene promoter. Analysis of wholemeal flours using an enzyme-based kit and by high-performance anion-exchange chromatography after digestion with lichenase showed decreases in total beta-glucan of between 30% and 52% and between 36% and 53%, respectively, in five transgenic lines compared to three control lines. The content of water-extractable beta-glucan was also reduced by about 50% in the transgenic lines, and the M(r) distribution of the fraction was decreased from an average of 79 to 85 x 10(4) g/mol in the controls and 36 to 57 x 10(4) g/mol in the transgenics. Immunolocalization of beta-glucan in semithin sections of mature and developing grains confirmed that the impact of the transgene was confined to the starchy endosperm with little or no effect on the aleurone or outer layers of the grain. The results confirm that the CSLF6 gene of wheat encodes a beta-glucan synthase and indicate that transgenic manipulation can be used to enhance the health benefits of wheat products.

Effects of genotype and environment on free amino acid levels in wheat grain: implications for acrylamide formation during processing

Acrylamide forms from free asparagine and reducing sugars during cooking, with asparagine concentration being the key parameter determining the formation in foods produced from wheat flour. In this study free amino acid concentrations were measured in the grain of varieties Spark and Rialto and four doubled haploid lines from a Spark x Rialto mapping population. The parental and doubled haploid lines had differing levels of total free amino acids and free asparagine in the grain, with one line consistently being lower than either parent for both of these factors. Sulfur deprivation led to huge increases in the concentrations of free asparagine and glutamine, and canonical variate analysis showed clear separation of the grain samples as a result of treatment (environment, E) and genotype (G) and provided evidence of G x E interactions. Low grain sulfur and high free asparagine concentration were closely associated with increased risk of acrylamide formation. G, E, and G x E effects were also evident in grain from six varieties of wheat grown at field locations around the United Kingdom in 2006 and 2007. The data indicate that progress in reducing the risk of acrylamide formation in processed wheat products could be made immediately through the selection and cultivation of low grain asparagme varieties and that further genetically driven improvements should be achievable. However, genotypes that are selected should also be tested under a range of environmental conditions.

Proceedings - National Conference on Wheat Utilization Research..

Mode of access: Internet.

Preliminary investigation into implication of a single cell organism in fish feed bouyancy and flotation

Two Isocaloric Isoproteic 30% crude protein diets were formulated for Clariid catfish and Tilapia with wheat grain starch (WGS) and cassava tuber starch (CTS) incorporated at 10 percent as binding agents. Saccharomyces cerevisiae was included at 2% as floating additive. The water stability, nutrient retention and flotation of pelleted feeds were observed for 60 minutes. There were generally decreasing trends in stability and retention at increasing time of immersion in water. The lipid retention was higher (P>0.05) than proteins in both diets. WGS diet was better (P>0.05) than CTS diet in flotation, which has attributed to the presence of gluten protein in wheat products. It is envisaged that a break through in floating feed development in Nigeria aquaculture would save the Nigeria economy from extruded (floating) feed importation

Effect of breadmaking process on In Vitro gut microbiota parameters in irritable bowel syndrome

A variety of foods have been implicated in symptoms of patients with Irritable Bowel Syndrome (IBS) but wheat products are most frequently cited by patients as a trigger. Our aim was to investigate the effects of breads, which were fermented for different lengths of time, on the colonic microbiota using in vitro batch culture experiments. A set of in vitro anaerobic culture systems were run over a period of 24 h using faeces from 3 different IBS donors (Rome Criteria–mainly constipated) and 3 healthy donors. Changes in gut microbiota during a time course were identified by fluorescence in situ hybridisation (FISH), whilst the small -molecular weight metabolomic profile was determined by NMR analysis. Gas production was separately investigated in non pH-controlled, 36 h batch culture experiments. Numbers of bifidobacteria were higher in healthy subjects compared to IBS donors. In addition, the healthy donors showed a significant increase in bifidobacteria (P<0.005) after 8 h of fermentation of a bread produced using a sourdough process (type C) compared to breads produced with commercial yeasted dough (type B) and no time fermentation (Chorleywood Breadmaking process) (type A). A significant decrease of δ-Proteobacteria and most Gemmatimonadetes species was observed after 24 h fermentation of type C bread in both IBS and healthy donors. In general, IBS donors showed higher rates of gas production compared to healthy donors. Rates of gas production for type A and conventional long fermentation (type B) breads were almost identical in IBS and healthy donors. Sourdough bread produced significantly lower cumulative gas after 15 h fermentation as compared to type A and B breads in IBS donors but not in the healthy controls. In conclusion, breads fermented by the traditional long fermentation and sourdough are less likely to lead to IBS symptoms compared to bread made using the Chorleywood Breadmaking Process.

Evaluación de la calidad funcional y sensorial en cultivares de Triticum aestivum ssp. vulgare y ssp. spelta en cultivo ecológico

En esta Tesis Doctoral se ha estudiado la influencia del cultivar sobre el comportamiento reológico y panadero de cinco cultivares de trigo sembrados en el mismo año y en el mismo ambiente, en condiciones de cultivo ecológico. Tres de ellos eran de trigo panadero (Triticum aestivum ssp. vulgare), ‘Bonpain’, ‘Craklin’ y ‘Sensas’ y los otros dos de trigo espelta (Triticum aestivum ssp. spelta), ‘Espelta Álava’ y ‘Espelta Navarra’. Actualmente, el alohexaploide trigo panadero (2n=6x=42 genomio AABBDD) supone en torno al 90% del trigo cultivado en el mundo. En cambio, el cultivo del trigo alohexaploide espelta (2n=6x=42 genomio AABBDD) se limita a pequeñas regiones de Europa y de América del Norte. En España, el cultivo de trigo espelta se ha mantenido durante años ligado a la región de Asturias, aunque en la actualidad su cultivo está empezando a diversificarse hacia otras regiones. Esto se debe, fundamentalmente, a su potencial nutricional y a su adaptabilidad a condiciones de agricultura sostenible. El reciente resurgimiento de la espelta en productos de panificación, se debe, en gran parte, a la percepción del consumidor de que se trata de un producto ”más saludable” y “más natural” y con menor requerimiento de insumos que los trigos modernos. A medida que el consumo de alimentos a base de harina de espelta aumenta, se plantea la necesidad de evaluar su calidad harino-panadera, nutricional y sensorial en comparación con los productos elaborados con variedades de trigo común. Se caracterizaron las gluteninas de alto peso molecular (HMW) y las puroindolinas de los cinco cultivares. Se evaluó la calidad del grano, la reología de sus masas y se analizó la calidad instrumental y sensorial de sus panes. Para tal fin se ha puesto a punto un protocolo de panificación adecuado a las características particulares de los trigos espelta y se ha propuesto para el análisis sensorial de los panes un protocolo de selección, entrenamiento y validación de jueces. Teniendo en cuenta la composición en gluteninas HMW de los cultivares, se comprobó su influencia en el volumen de sedimentación y en la fuerza panadera. La composición en puroindolinas se vió reflejada en el parámetro dureza del endospermo. Los resultados indicaron que hay diferencias entre trigo panadero y trigo espelta en parámetros como, la tenacidad y el equilibrio de sus masas, la capacidad de absorción de agua de la harina y el comportamiento de la masa durante el amasado. Los trigos espeltas mostraron menor valor en el tiempo en alcanzar la presión máxima y la tolerancia al amasado, mientras que presentaron valores superiores en el decaimiento a los 250 y 450 segundos respectivamente. Respecto a la calidad de los panes elaborados, los trigos espeltas tenían mayor elasticidad en la miga y mayores valores en el área y en el diámetro de sus alveolos. Estas diferencias en la estructura y textura de la miga fueron también detectadas a nivel sensorial por el panel de jueces. Mediante el perfil sensorial descriptivo, se determinó que uno de los dos panes elaborado con trigo espelta (‘Espelta Navarra’) fue el pan más complejo considerando conjuntamente los atributos de aroma y flavor. En este trabajo no se apreciaron diferencias entre ambos tipos de trigo ni en el contenido en proteína, ni en minerales, ni en la viscosidad de su almidón. ABSTRACT In this Doctoral Thesis, the influence of various cultivars on rheological and baking behavior was studied. Five wheat cultivars were used, all planted in the same year and same organic farming environment. Three were bread wheat (Triticum aestivum ssp. vulgare), 'Bonpain', 'Craklin' and 'Sensas' and the other two were spelt wheat (Triticum aestivum ssp. spelta) , 'Espelta Álava' and 'Espelta Navarra' . Currently, the allohexaploid bread wheat (2n=6x=42 genome AABBDD) represents about 90% of global wheat production. On the other hand, allohexaploid spelt wheat (2n=6x=42 genome AABBDD) is merely produced in small areas of Europe and North America. For many years, the cultivation of spelt wheat in Spain was limited to the region of Asturias, although nowadays its production has begun to spread into other regions. This is owing to its nutritional potential and adaptability to conditions of sustainable agriculture. The recent resurgence of spelt in baking products is mainly due to consumers perception of it, as "healthier" and "more natural", and to the fewer agricultural input requirements compared to modern wheat products. As the consumption of foods made from spelt flour increases, there is a need to assess its baking, nutritional and sensory quality, compared to products made with common varieties of wheat. High molecular weight glutenins and puroindolines from the five cultivars were characterized. The quality of the grain and the rheology of the dough were evaluated and the instrumental and sensory quality of its breads were analyzed. To this end it a baking protocol was appropriately developed to the particular characteristics of spelt wheat and a selection protocol was proposed for the sensory analysis of breads, after proper training and validation of judges. Considering the HMW glutenin composition of the cultivars, the influence on the sedimentation volume and the baking strength was proven. The composition of puroindolines was reflected in the endosperm hardness parameter. The results show that there are differences between bread wheat and spelt wheat on parameters such as the tenacity and tenacity/elasticity ratio of their masses, the water absorption capacity of the flour and the behavior of the dough during kneading. The values for total time to reach maximum pressure and tolerance to mixing were lower for spelt wheat, and higher values were found for the drop at 250 s and 450 s. Regarding the quality of manufactured bread, spelt wheat had the greatest elasticity of the crumb and higher values in the area and diameter of the cells. These differences in the structure and texture of the crumb were also noticed at a sensory level by the panel of judges. It was determined by a descriptive sensory profile that one of the two loaves of bread made with spelt ('Espelta Navarra') was the most complex in the sense of its attributes of scents and flavors altogether. In this study, no differences were appreciated between the two types of wheat or the protein composition, or minerals or viscosity of the starch.

Labeling of meat food products to reflect the inclusion of imitation or alternate cheese; and the effects of consumption of tropical oils on the soybean program [microform] : joint hearing before the Subcommittee on Livestock, Dairy, and Poultry and the Subcommittee on Wheat, Soybeans, and Feed Grains of the Committee on Agriculture, House of Representatives, One Hundredth Congress, first session on H.R. 3232, September 10, 1987.

"Serial no. 100-44."