Comparison of flavor compounds of potato chips fried in palmolein and silicone fluid

The importance of the frying oil as a heat-transfer medium and as a source of flavor precursors for the formation of potato chip flavor was investigated. Potato slices were fried in palmolein or silicone fluid, and the volatile flavor compounds of the resulting chips were isolated onto Tenax and analyzed by gas chromatography-mass spectrometry. Although the heat-transfer coefficients of the oils did not differ significantly, their temperature profiles during frying were different, probably due to greater turbulence on placing potato slices in palmolein, leading to more efficient heat transfer. Levels of Strecker aldehydes and sulfides in chips fried in the two media were not significantly different, but levels of pyrazines were significantly higher in palmolein-fried chips. Amounts of 2,4-decadienal were also significantly higher in palmolein-fried chips, but there was no significant difference in hexanal levels between the samples.

Studying oil absorption in restructured potato chips

The oil-absorption capacity of different restructured potato chips during deep-fat frying was investigated. Low-leach potato flake was chosen as the major ingredient, whereas native and pregelatinized potato starches were studied as complementary ingredients. Results showed that off absorption increased significantly when reducing product thickness in all products. Interestingly, it was found that the product containing native potato starch as an ingredient picked up the lowest amount of on when sheeted into a thick chip, whereas it absorbed the largest amount of oil when sheeted into a thin chip. Those findings were mainly attributed to crust microstructure development as revealed by electron microscopy and confocal microscopy.

The possibility of lowering oil content of potato chips by combining atmospheric frying with postfrying vacuum application

Four protocols involving the application of low pressures, either toward the end of frying or after frying, were investigated with the aim of lowering the oil content of potato chips. Protocol 1 involving frying at atmospheric pressure followed by a 3 min draining time constituted the control. Protocol 2 involved lowering of pressure to 13.33 kPa, 40 s before the end of frying, followed by draining for 3 min at the same pressure. Protocol 3 was the same as protocol 2, except that the pressure was lowered 3 s before the end of frying. Protocol 4 involved lowering the pressure to 13.33 kPa after the product was lifted from the oil and holding it at this value over the draining time of 3 min. Protocol 4 gave a product having the lowest oil content (37.12 g oil/100 g defatted dry matter), while protocol 2 gave the product with highest oil content (71.10 g oil/100 g defatted dry matter), followed by those obtained using protocols 1 and 3(68.48 g oil/100 g defatted dry matter and 52.50 g oil/100 g defatted dry matter, respectively). Protocol 4 was further evaluated to study the effects of draining times and vacuum applied, and compared with the control. It was noted that over the modest range of pressures investigated, there was no significant effect of the vacuum applied on the oil content of the product. This study demonstrates that the oil content of potato chips can be lowered significantly by combining atmospheric frying with draining under vacuum.

Frying of potato chips in a blend of canola oil and palm olein: changes in levels of individual fatty acids and tocols

The changes occurring in the levels of nutritionally relevant oil components were assessed during repeated frying of potato chips in a blend of palm olein and canola oil (1:1 w/w). The blend suffered minimal reductions in omega-3 and omega-6 polyunsaturated fatty acids. There was no significant difference between the fatty acid composition of the oil extracted from the product and that of the frying medium, in all three cases. The blend also contained a significant amount of tocols which add a nutritional value to the oil. The concentration of the tocols was satisfactorily retained over the period of oil usage, in contrast to the significant loses observed in the case of the individual oils. The blend also performed well when assessed by changes in total polar compounds, free fatty acids, p-anisidine value. When fried in used oil, the product oil content increased progressively with oil usage time. This study shows that blended frying oils can combine good stability and nutritional quality

Post-frying oil drainage from potato chips and french fries: a comparative study of atmospheric and vacuum drainage

This paper represents a study of the transient changes occurring in temperature, and moisture and oil contents during the so called “post-frying drainage”—which is the duration for which a product is held in the head space of the fryer after it is removed from the oil. Since most of the oil adhering to the product penetrates into the structure during this period, this paper examines the effects of applying vacuum during drainage (1.33 kPa) to maintain the product temperature consistently above the water saturation temperature corresponding to the prevailing pressure (11 °C), which potentially eliminates water condensation and prevents the occluded surface oil from penetrating into the product structure. Draining under vacuum significantly lowers the oil content of potato chips by 38% compared to atmospheric drainage. This phenomenon can be further confirmed by confocal laser scanning microscopy (CLSM) images, which show that the boundary between the core and the crust regions is clearly visible in the case of vacuum drainage, whereas in the case of atmospheric drainage, the oil is distributed throughout the structure. Unfortunately, the same approach did not reduce the oil content of French fries—the oil content of vacuum-drained product was found similar to the product obtained by draining under atmospheric pressure. This is because the reduction in oil content only occurs when there is net moisture evaporation from the product and the evaporation rate is sufficient to force out the oil from the product; this was clearly not the case with French fries. The CLSM images show that the oil distribution in the products drained under atmospheric pressure and vacuum was similar.

Papas Chips XI : materia seca, peso específico, rendimiento y fijación de aceite, parámetros de calidad

p.145-150

Papas chips XII : tratamiento con CIPC de tubérculos almacenados : su incidencia en la composición química y su relación con la calidad de la chip

p.41-50

Formation of Strecker aldehydes and pyrazines in a fried potato model system

Sugars and amino acids were removed from potato slices by soaking in water and ethanol. They were then infused with various combinations of sugars (glucose and/or fructose) and amino acids (asparagine, glutamine, leucine, isoleucine, phenylalanine, and/or methionine) and fried. Volatile compounds were trapped onto Tenax prior to gas chromatography-mass spectrometry. Relative amounts of compounds (relative to the internal standard) and relative yields (per mole of amino acid infused into the slices) were determined. Amounts of 10 pyrazines, 4 Strecker aldehydes, and 4 other compounds were monitored. Relative amounts and relative yields of compounds varied according to the composition of the system. For the single amino acid-glucose systems, leucine gave the highest relative amount and relative yield of its Strecker aldehyde. Asparagine and phenylalanine gave the highest total relative amount and total relative Yield, respectively, of pyrazines. In the system containing all of the amino acids and glucose, the relative amount of 3-methylbutanal was higher, whereas the amounts of the other monitored Strecker aldehydes were lower. Most of the relative amounts of individual pyrazines were lower compared to the glucose-asparagine system, whereas the total relative yield of pyrazines was lower, compared to all of the single amino acid-glucose mixtures. Addition of fructose to the mixed amino acid-glucose model system generated Strecker aldehydes and pyrazines in ratios that were more similar to those of untreated potato chips than to those from the same system but without fructose. Both the sugars and the amino acids present in potato are crucial to the development of flavor compounds in fried potato slices.

Composição nutricional e perfil de ácidos graxos de batatas chips e sanacks extrusados

Pós-graduação em Engenharia e Ciência de Alimentos - IBILCE

Efeito da adição de óleo essencial de Origanum vulgar e Ocimum gratissimum L. no perfil lipídico da gordura de palma usada em fritura de batata tipo chips

The objective of this study was to determine the antioxidant effect of essential oregano and alfavaca oil on the fatty acid profile of palm oil, used in industrial potato chips processing, aiming to reduce the oxidative state of palm oil. Essential oregano oil was obtained from industrial residues and commercial essential oregano oil was also acquired. The antioxidant activity of Oregano’s essential oil was taken by DPPH method. The DPPH analysis of the essential oil of oregano residue resulted in an IC50 of 797.04 mg.mL-1 and the essential oil of commercial oregano was 424.25 mg.mL-1. Regarding the content of total phenols, the essential oil of commercial oregano showed 0.167 ± 0.058 ug EAG.g-1. Based on these results, concentrations of 50, 100 e 150ug.g-1 of commercial oregano essential oil was added to palm oil and the fatty acid profile was determined by gas cromatography. Analysis were done with palm oil without being used in frying processes and without added essential oil, as well as with the different essential oil concentrations submitted at three frying processes at one single day. In the second part of the project, the effect of oreganos’s comercial essential oil compared to alfavacão essential oil, at the concentration of 100ug.g-1 in palm oil, and submitted to three frying processes during eleven cycles, was studied. The lipid profile was similar to that described in the literature, which an increase in the number of frying times caused a polyunsaturated fatty acids decrease and, therefore, a proportional increase in saturated fatty acids. It was noted an increase in the amounts of total saturated fatty acids from 43.36% (control) to 43.60% (palm oil with essential oil after 11 frying cycles at the concentration of 100ug.g-1). This fact proves that during the frying process, there is an increase in the rate of formation of saturated fatty acids. However, the addition of oregano essential oil did not provide significant change in the fatty acids of palm oil used in frying process of potato chips. The addition of oregano essential oil in a concentration of 100 ug./mL-1 until the third frying cycle showed a reduction effect of trans fatty acid formation. Although, during 11 frying cycles it was not noticed the essential oil effect under trans fatty acid formation. It can be suggested that this factor may be correlated to the frying time, which may not have been sufficient for significant formation of saturated and trans compounds.

Socio-economic differences in takeaway food consumption among adults

To examine socioeconomic differences in the frequency and types of takeaway foods consumed. Cross-sectional postal survey. Participants were asked about their usual consumption of overall takeaway food (< four times a month, or ≥ four times a month) and 22 specific takeaway food items (< once a month, or ≥ once a month): these latter foods were grouped into “healthy” and “less healthy” choices. Socioeconomic position was measured using education and equivalised household income and differences in takeaway food consumption were assessed by calculating prevalence ratios using log binomial regression. Adults aged 25–64 years from Brisbane, Australia were randomly selected from the electoral roll (N = 903, 63.7% response rate). Compared with their more educated counterparts, the least educated were more regular consumers of overall takeaway food, fruit/vegetable juice, and less regular consumers of sushi. For the “less healthy” items, the least educated more regularly consumed potato chips, savoury pies, fried chicken, and non-diet soft drinks; however, the least educated were less likely to consume curry. Household income was not associated with overall takeaway consumption. The lowest income group were more regular consumers of fruit/vegetable juice compared with the highest income group. Among the “less healthy” items, the lowest income group were more regular consumers of fried fish, ice-cream, and milk shakes, while curry was consumed less regularly. The frequency and types of takeaway foods consumed by socioeconomically disadvantaged groups may contribute to inequalities in overweight/obesity and chronic disease.

Différence dans la qualité de l’alimentation en relation au risque d’excès de poids chez des populations autochtones canadiennes

L‘obésité constitue un problème de santé publique au Canada, particulièrement chez les populations autochtones où les prévalences les plus élevées ont été rapportées. D’après les écrits recensés, plusieurs méthodes ont été essayées pour étudier la relation entre l’alimentation et l’obésité, mais les résultats sont inconstants. Le but de cette thèse est d’identifier, en termes quantitatif et qualitatif, les différences dans l’alimentation des obèses et non-obèses. Pour y parvenir, nous avons développé une nouvelle méthode à l’aide d’une banque de données portant sur les enfants Mohawk de Kahnawake afin d’identifier les différences dans les choix alimentaires. Cette même méthode a été ensuite appliquée à deux autres banques de données (celle des adultes cris de la Baie James et celle des autochtones de l’enquête ESCC 2.2). Globalement, les résultats n’ont pas montré de différences significatives dans l’alimentation des participants selon les catégories d’IMC en considérant les indicateurs reliés à la quantité et à la qualité de l’alimentation comme l’apport énergétique total, l’apport énergétique en provenance des lipides, les fibres alimentaires, la densité énergétique et la diversité alimentaire. Par contre, les résultats de la nouvelle méthode fondée sur la sélection des items alimentaires fréquemment consommés par au moins 10 % des participants ont révélé que les enfants de Kahnawake à risque d’excès de poids consommaient plus fréquemment de croustilles (p=0.001) et moins fréquemment de craquelins que les enfants avec excès de poids ou ceux ayant un poids normal (p=0.015). Ensuite, en prenant la catégorie de poids normal comme référence, le rapport de côte (Odds ratio : OR) d’être à risque d’excès de poids était de 2.16 (95 % IC : 1.14 - 4.09) fois plus élevé chez les enfants de Kahnawake qui consommaient plus fréquemment de croustilles comparativement aux non-consommateurs de croustilles, et ce, après ajustement pour l’âge. Par contre, le rapport de côte d’être à risque d’excès de poids diminuait de 79 % (OR = 0.21; 95 % IC : 0.06 – 0.72) chez les enfants consommateurs de craquelins comparativement à leurs homologues non-consommateurs. Après avoir corrigé les quantités pour l’âge, on note que les enfants avec excès de poids consommaient plus de frites que les enfants à risque d’excès de poids ou ceux ayant un poids normal (p = 0.027). Chez les femmes cries, les résultats de la nouvelle méthode ont montré que le colorant à café était associé à un risque élevé d’obésité (OR = 4.64, 95 % IC : 1.04 - 0.54); alors que le lait faible en matières grasses était associé à un moindre risque d’embonpoint (OR = 0.38, 95 % IC : 0.17 - 0.82), après ajustement pour l’âge. Quant aux hommes cris, le lait entier était associé à un moindre risque d’avoir de l’embonpoint (OR ajusté pour l’âge = 0.38, 95 % IC : 0.20 - 0.71) et, en termes de quantité corrigée pour l’âge, les hommes obèses buvaient plus de boissons sucrées aux fruits comparativement aux hommes de poids normal ou ceux ayant de l’embonpoint (p=0.015). Selon les résultats de cette méthode appliquée aux données de l’enquête ESCC 2.2, les garçons à risque d’excès de poids ou avec excès de poids consommaient moins fréquemment de pain blanc que ceux de poids normal (p=0.048). En termes de quantité toutefois, ils consommaient plus de pain blanc (p=0.040), utilisaient plus de farine de blé (p=0.006) et de levure (p=0.002). Après avoir ajusté les quantités consommées pour l’âge et l’indice d’activité physique, les femmes avec embonpoint ou obèses utilisaient plus de farine de blé (p< 0.001) que leurs homologues de poids normal. Chez les hommes, il n'y avait pas de différences ni dans les fréquences de consommation ni dans les quantités consommées. Concernant les filles, leurs apports alimentaires n'étaient pas valides (facteur d'activité de Goldberg < 1.2 dans la catégorie embonpoint / obèse). Les résultats de cette méthode innovatrice pourraient d’une part, permettre d’axer la sensibilisation sur des aliments particuliers en plus des recommandations générales du Guide Alimentaire Canadien. D’autre part, ils nous renvoient aux données biologiques de laboratoire afin d’identifier les composantes des items susceptibles de contribuer au développement de l’obésité.

Combination of moderate vacuum frying with high vacuum drainage: relationship between process conditions and oil uptake

This paper explores the possibility of combining moderate vacuum frying followed by post-frying high vacuum application during the oil drainage stage, with the aim to reduce oil content in potato chips. Potato slices were initially vacuum fried under two operating conditions (140 °C, 20 kPa and 162 °C, 50.67 kPa) until the moisture content reached 10 and 15 % (wet basis), prior to holding the samples in the head space under high vacuum level (1.33 kPa). This two-stage process was found to lower significantly the amount of oil taken up by potato chips by an amount as high as 48 %, compared to drainage at the same pressure as the frying pressure. Reducing the pressure value to 1.33 kPa reduced the water saturation temperature (11 °C), causing the product to continuously lose moisture during the course of drainage. Continuous release of water vapour prevented the occluded surface oil from penetrating into the product structure and released it from the surface of the product. When frying and drainage occurred at the same pressure, the temperature of the product fell below the water saturation temperature soon after it was lifted out of the oil, which resulted in the oil getting sucked into the product. Thus, lowering the pressure after frying to a value well below the frying pressure is a promising method to lower oil uptake by the product.

Qualidade físico-química e de fritura de tubérculos de cultivares de batata na safra de inverno

Conselho Nacional de Desenvolvimento Científico e Tecnológico (CNPq)