New strategies for treatment and reuse of spent sulfidic caustic stream from petroleum industry

This work examines traditional and new routes for removal of H2S and other sulfur compounds from spent sufidic caustic (SSC). SH- (hydrogenosulfide) and S2- (sulfide) ions were quantitatively oxidized at 25 ºC using H2O2, NaOCl or a spent sulfochromic mixture. SH-/S2- ions were also removed via reaction with freshly prepared iron or manganese hydroxides, or after passing the SSC through strong basic anion exchange resins (OH- form). The treated caustic solution, as well as iron/manganese hydroxides, removed H2S from diesel samples at 25 ºC. SSC treatment via strong basic anion-exchange resins produced the treated caustic solution with the highest free alkalinity.

TREATMENT OF WASTE FROM ATOMIC EMISSION SPECTROMETRIC TECHNIQUES AND REUSE IN UNDERGRADUATE LAB CLASSES FOR QUALITATIVE ANALYSIS

Flame atomic absorption spectrometry (FAAS) and inductively coupled plasma optical emission spectrometry (ICP OES) are widely used in academic institutions and laboratories for quality control to analyze inorganic elements in samples. However, these techniques have been observed to underperform in sample nebulization processes. Most of the samples processed through nebulization system are discarded, producing large volumes of waste. This study reports the treatment and reuse of the waste produced from ICP OES technique in a laboratory of analytical research at the Universidade Federal do Ceará, Brazil. The treatment of the waste was performed by the precipitation of elements using (NH4)2CO3. Subsequently, the supernatant solution can be discarded in accordance with CONAMA 430/2011. The precipitate produced from the treatment of residues can be reused as a potential sample in undergraduate qualitative analytical chemistry lab classes, providing students the opportunity to test a real sample.

Mathematical simulation parameters for drying of cassava starch pellets

Based on experimental tests, it was obtained the equations for drying, equilibrium moisture content, latent heat of vaporization of water contained in the product and the equation of specific heat of cassava starch pellets, essential parameters for realizing modeling and mathematical simulation of mechanical drying of cassava starch for a new technique proposed, consisting of preformed by pelleting and subsequent artificial drying of starch pellets. Drying tests were conducted in an experimental chamber by varying the air temperature, relative humidity, air velocity and product load. The specific heat of starch was determined by differential scanning calorimetry. The generated equations were validated through regression analysis, finding an appropriate correlation of the data, which indicates that by using these equations, can accurately model and simulate the drying process of cassava starch pellets.

Technology for sugarcane agroindustry waste reuse as granulated organomineral fertilizer

Aiming to evaluate the use of sugarcane industry waste such as byproducts from vinasse concentration process, it was assessed the organomineral fertilizer BIOFOM (concentrated vinasse, filter cake, boiler ash, soot from chimneys and supplemented with mineral fertilizers). The study included characterization and agronomic potential analysis of a test plant (corn), by noting the differences between mineral fertilizers and BIOFOM fertilization until 45 days after sowing. The technology traditionally used to produce BIOFOM was based on vinasse evaporation with high heat transfer coefficients. It was observed that the technology, which can be formulated according to the needs of any crop, could be used in many cases as mineral fertilizer. Therefore, the use of this organomineral fertilizer reduces waste generation of sugarcane industry.

Pellets de trigo e soja produzidos por extrusão

A mistura de trigo e soja representa uma importante fonte calórico-protéica com proteínas de boa qualidade. Apesar disso, a utilização da soja como ingrediente tem sido limitada pelo seu sabor de feijão cru (beany flavor), o qual é melhorado pelo processo de extrusão. Foram estudados os efeitos de umidade da mistura, Temperatura de Barril (TB) e Velocidade de Rotação de Parafuso (VRP, Nº 5) do extrusor no Índice de Expansão (IE), no Índice de Solubilidade em Água (ISA) e nas características sensoriais de pellets produzidos com mistura de trigo e soja (90:10), objetivando a otimização deste processo para a obtenção de pellets fritos com melhores qualidades sensoriais. A farinha mista crua foi extrusada em 2 umidades (32 e 35%), 4 TB (60 a 90 °C) e 4 VRP (60 a 150 rpm), totalizando 32 tratamentos. O pellet frito, preparado com a farinha mista com 32% de umidade e extrusada em 60 rpm a 80 °C, apresentou o maior IE e as melhores qualidades sensoriais (aparência, sabor e textura), sendo preferido pela equipe de provadores não treinados, tanto com sabor de bacon como com sabor de queijo.

Effect of air-temperature and diet composition on the drying process of pellets for japanese abalone (Haliotis discus hannai) feeding

The aim of this research was to study the effect of air-temperature and diet composition on the mass transfer kinetics during the drying process of pellets used for Japanese Abalone (Haliotis discus hannai) feeding. In the experimental design, three temperatures were used for convective drying, as well as three different diet compositions (Diets A, B and C), in which the amount of fishmeal, spirulin, algae, fish oil and cornstarch varied. The water diffusion coefficient of the pellets was determined using the equation of Fick's second law, which resulted in values between 0.84-1.94×10-10 m²/s. The drying kinetics was modeled using Page, Modified Page, Root of time, Exponential, Logarithmic, Two-Terms, Modified Henderson-Pabis and Weibull models. In addition, two new models, referred to as 'Proposed' models 1 and 2, were used to simulate this process. According to the statistical tests applied, the models that best fitted the experimental data were Modified Henderson-Pabis, Weibull and Proposed model 2, respectively. Bifactorial analysis of variance ANOVA showed that Diet A (fishmeal 44%, spirulin 9%, fish oil 1% and cornstarch 36%) presented the highest diffusion coefficient values, which were favored by the temperature increase in the drying process.

Optimization of extrusion process for production of nutritious pellets

A blend of 50% Potato Starch (PS), 35% Quality Protein Maize (QPM), and 15% Soybean Meal (SM) were used in the preparation of expanded pellets utilizing a laboratory extruder with a 1.5 × 20.0 × 100.0 mm die-nozzle. The independent variables analyzed were Barrel Temperature (BT) (75-140 °C) and Feed Moisture (FM) (16-30%). The effect of extrusion variables was investigated in terms of Expansion Index (EI), apparent density (ApD), Penetration Force (PF) and Specific Mechanical Energy (SME), viscosity profiles, DSC, crystallinity by X-ray diffraction, and Scanning Electronic Microscopy (SEM). The PF decreased from 30 to 4 kgf with the increase of both independent variables (BT and FM). SME was affected only by FM, and decreased with the increase in this variable. The optimal region showed that the maximum EI was found for BT in the range of 123-140 °C and 27-31% for FM, respectively. The extruded pellets obtained from the optimal processing region were probably not completely degraded, as shown in the structural characterization. Acceptable expanded pellets could be produced using a blend of PS, QPM, and SM by extrusion cooking.

Occurrence of Cryptosporidium oocysts and Giardia cysts in raw water from the Atibaia river, Campinas, Brazil

Cryptosporidium parvum and Giardia duodenalis are waterborne parasites that have caused several outbreaks of gastrointestinal disease associated with drinking water. Due to the lack of studies about the occurrence of these protozoa in water in the Southeast of Brazil, an investigation was conducted to verify the presence of cysts and oocysts in superficial raw water of the Atibaia River. The water samples were submitted to membrane filtration (3.0 mum) and elution was processed by (1) scraping and rinsing of membrane (RM method) and (2) acetone-dissolution (ADM method). Microbiologic and chemical parameters were analyzed. Aliquots of the pellets were examined by immunofluorescence (Merifluor, Meridian Diagnostics, Cincinnati, Ohio). All water samples were positive for Cryptosporidium and Giardia, in spite of the high turbidity. Higher recovery rates occurred in samples treated by the RM method than by the ADM technique. The goal for future work is the assessment of viability of cysts and oocysts to determine the public health significance of this finding.

Occurrence of Giardia cysts and Cryptosporidium oocysts in activated sludge samples in Campinas, SP, Brazil

Giardia and Cryptosporidium have caused several outbreaks of gastroenteritis in humans associated with drinking water. Contaminated sewage effluents are recognized as a potential source of waterborne protozoa. Due to the lack of studies about the occurrence of these parasites in sewage samples in Brazil, we compared the efficiency of two procedures for concentrating cysts and oocysts in activated sludge samples of one sewage treatment plant. For this, the samples were submitted to i) concentration by the ether clarification procedure (ECP) and to ii) purification by sucrose flotation method (SFM) and aliquots of the pellets were examined by immunofluorescence. Giardia cysts were present in all samples (100.0%; n = 8) when using ECP and kit 1 reagents, while kit 2 resulted in six positive samples (85.7%; n = 7). As for SFM, cysts were detected in 75.0% and 100.0% of these samples (for kit 1 and 2, respectively). Regarding Cryptosporidium, two samples (25.0%; kit 1 and 28.5% for kit 2) were detected positive by using ECP, while for SFM, only one sample (examined by kit 1) was positive (12.5%). The results of the control trial revealed Giardia and Cryptosporidium recovery efficiency rates for ECP of 54.5% and 9.6%, while SFM was 10.5% and 3.2%, respectively. Considering the high concentration detected, a previous evaluation of the activated sludge before its application in agriculture is recommended and with some improvement, ECP would be an appropriate simple technique for protozoa detection in sewage samples.

Microbiological contamination of a hemodialysis center water distribution system

The microbiological monitoring of the water used for hemodialysis is extremely important, especially because of the debilitated immune system of patients suffering from chronic renal insufficiency. To investigate the occurrence and species diversity of bacteria in waters, water samples were collected monthly from a hemodialysis center in upstate São Paulo and tap water samples at the terminal sites of the distribution system was sampled repeatedly (22 times) at each of five points in the distribution system; a further 36 samples were taken from cannulae in 19 hemodialysis machines that were ready for the next patient, four samples from the reuse system and 13 from the water storage system. To identify bacteria, samples were filtered through 0.22 µm-pore membranes; for mycobacteria, 0.45 µm pores were used. Conventional microbiological and molecular methods were used in the analysis. Bacteria were isolated from the distribution system (128 isolates), kidney machine water (43) and reuse system (3). Among these isolates, 32 were Gram-positive rods, 120 Gram-negative rods, 20 Gram-positive cocci and 11 mycobacteria. We propose the continual monitoring of the water supplies in hemodialysis centers and the adoption of effective prophylactic measures that minimize the exposure of these immunodeficient patients to contaminated sources of water.

Comparative study of cultivation of feces in vermiculite or charcoal to obtain larvae of Strongyloides venezuelensis

IntroductionWe compared feces culturing in charcoal or vermiculite to obtain Strongyloides venezuelensis larvae.MethodsFeces (5g) from infected rats was mixed with vermiculite (10g) or coal (10g) in plastic cups and incubated at 28°C for 48h. Larvae were recovered using Baermann-Moraes method.ResultsSignificantly higher number of positive larval cultures were recovered from vermiculite than from charcoal (15/17 and 4/17, respectively; p < 0.001; 990.6 ± 307.5 and 215 ± 78.1 larvae, p = 0.027).ConclusionsVermiculite yields more larvae and provides cleaner pellets, improving larvae identification and facilitating their use for other purposes.

Observações preliminares sôbre caponização de frangos "Leghorn" com estrogênios

The effect of "Capastrol", pellets of diethilstilbestrol at 0,015 g., in 12 weeks S. C. W. Leghorn cockerels, was studied. The results secured are in accordance with those obtained by other authors and can be resumed as follows: 1) paleness and shrunken of the comb, whose size is reduced, in comparison with the controls; 2) no differences in the total weight gain between control and treated lot; 3) size of testis greatly reduced in treated males; 4) improvement of meat by fat deposition in chickens that received treatment.

Indução do crescimento ovariano em Aegla uruguayana (Crustacea, Anomura, Aeglidae) mediante a incorporação de neuroreguladores ao alimento

O efeito estimulante da spiperona e da naloxana sob a maturação ovariana foram avaliados em fêmeas de Aegla uruguayana Schmitt, 1942 e, para isto, tais neuroreguladores foram incorporados ao alimento e administrados a uma dose de 10-8 mol/animal a cada sessão de alimentação. Fêmeas adultas foram coletadas com puçá em um arroio próximo à cidade de Salto, Província de Buenos Aires, Argentina. Dez fêmeas foram sacrificadas, medidas, pesadas e os seus ovários foram retirados e pesados para a determinação do índice gonadossomático (IG). As demais fêmeas (30) foram divididas em três grupos experimentais - (a) controle: alimentadas com pellets controle composto por ração para peixe - 34% de proteína e 43% de proteína; (b) spiperona: alimentadas com pellets controle enriquecidos com spiperona; (c) naloxana: alimentadas com pellets controle enriquecidos com naloxana. Após 7 semanas as fêmeas foram sacrificadas e avaliado o IG. Os ovários e o hepatopâncreas foram quantificados quanto aos níveis de lipídeos totais e colesterol. A naloxana produziu um aumento significativo nos níveis de lipídeos tanto nas gônadas como no hepatopâncreas em relação ao grupo controle. A spiperona produziu aumento significativo nos níveis de lipídeos nas gônadas e no hepatopâncreas e de colesterol no hepatopâncreas quando comparados ao controle. Os níveis de lipídeos foram significativamente menores na hemolinfa das fêmeas que foram alimentadas com pellets com spiperona e maiores nas fêmeas tratadas com naloxana quando comparadas as fêmeas que foram alimentadas apenas com ração. A spiperona e a naloxana, ao inibir os efeitos da dopamina e dos opióides endógenos, provavelmente causaram a secreção do hormônio estimulante das gônadas e a inibição do hormônio inibidor das gônadas, causando, portanto indução do desenvolvimento ovariano. Tal hipótese é reforçada pelos aumentos do índice gonadossomático verificado nestes grupos experimentais.

Maintenance and breeding of Thrichomys (Trouessart, 1880) (Rodentia: Echimyidae) in captivity

South American histricognath rodents Thrichomys apereoides laurentius and Thrichomys pachyurus are natural hosts of Trypanosoma cruzi, agent of Chagas disease. We established breeding colonies of these species to serve as experimental models in various parasitological studies. Both species of Thrichomys have all the requirements necessary to become excellent laboratory models: they can be easily maintained in the standard laboratory conditions and breed throughout the year and they do not have any special dietary demands and can be fed by standard food pellets designed for laboratory mice. Both species produce precocious offspring that have their eyes and ears open, teeth erupted, fur well developed, and can eat solid food in the first week of life. T. a. laurentius has larger litter sizes and lower body masses at birth and weaning than T. pachyurus. Moreover, females of T. a. laurentius reach puberty earlier and with lower body mass than T. pachyurus.

Notas sobre a socialidade e a biologia de nidificação de Trypoxylon (Trypoxylon) asuncicola Strand, 1910 (Hymenoptera, Sphecidae)

Twenty-two nests of Trypoxylon asuncicola were sampled in Viçosa, State of Minas Gerais, Brazil, in January 2000 and the occupants' behavior of three nests was registered in 2h of direct observation. 528 brood cells were excavated (24±13.84 SD cells per nest), 129 were reused cells, some of them for seven times (meconium deposit count). The mean number of total cells, mean number of open and closed cells, parasitism rate and mean number of reused cells per nest were similar between old and new nests. Parasitism rate and cell reuse were associated with the number of building cells in the nest, but nest aggregate in the sampled area may play some role in the parasitism rate. Brachymeria sp. (Chalcididae) was the most important agent of brood mortality (80%). Other parasites were Melittobia sp. (Eulophidae) (17%) and a species of Icheumonidae (3%). The number of closed cells with immature individuals per nest was 4±4.2SD (N=17) and the mean reproductivity per female was 3±2.4SD (N=5). New nests produced more offspring (0 a 35%) than old nests (0 to 11%). Females and males can be found resting in the nest but copula or guarding behavior by the male was not observed. There is some evidence that in the sampled area the switch of nests by females is great and agonistic behavior between a nest owner and a visitor was not evident. Females were larger (3.9±0.4SD mm) than males (3.1±0.3SD mm) (measured as forewing length). The secondary sex ratio was 1.26 (±0.07 SE) in favor of females, which was not different from 1:1 ratio. The majority (97%) of the sampled larvae of T. asuncicola showed diapause. Some (5.1%) 'anomalous cells' were found.