Potential of biogas production from swine manure supplemented with glycerine waste

In this study, was studied the biogas generation from swine manure, using residual glycerine supplementation. The biogas production by digestion occurred in the anaerobic batch system under mesophilic conditions (35°C), with a hydraulic retention time of 48 days. The experiment was performed with 48 samples divided into four groups, from these, one was kept as a control (without glycerin) and the other three groups were respectively supplemented with residual glycerine in the percentage of 3%, 6% and 9% of the total volume of the samples. The volume of biogas was controlled by an automated system for reading in laboratory scale and the quality of the biogas (CH4) measured from a specific sensor. The results showed that the residual glycerine has high potential for biogas production, with increases of 124.95%, 156.98% and 197.83% in the groups 3%, 6% and 9%, respectively, relative to the sample control. However, very high organic loads can compromise the process of digestion affecting the quality of the biogas generated in relation to methane.

COD, TSS, nutrients and coliforms removals in UASB reactors in two stages treating swine wastewater

The performance of two upflow anaerobic sludge blanket (UASB) reactors was evaluated in pilot scale (908 and 188 L), installed in series (R1 and R2), fed with swine wastewater with TSS around 5 and 13 g L-1. The UASB reactors were submitted to HDT of 36 and 18 h with VOL of 5.5 to 34.4 g COD (L d)-1 in the R1 and HDT of 7.5 e 3.7 h with VOL from 5.1 to 45.2 g COD (L d)-1 in the R2. The average removal efficiencies of COD ranged from 55 to 85% in the R1 and from 43 to 57% in the R2, resulting in values from 82 to 93% in the UASB reactors in two stage. Methane concentrations in the biogas were 69 to 74% with specific production from 0.05 to 0.27 L CH4 (g removedCOD)-1 in the R1 and of 0.10 to 0.12 L CH4 (g removedCOD)-1 in the R2. The average removal efficiencies were 61 to 75% for totalP, 39 to 69% for KN, 82 to 93% for orgN and 20 to 94% for Fe, Zn, Cu and Mn. The amN concentration were not reduced indicating the need to post-treatment for effluent disposal into water bodies. There were reductions of total coliforms from 99.8123 to 99.9989% and of thermotolerant coliforms from 99.9725 to 99.9999%. The conditions imposed to the UASB reactors in two stage provided high conversions of removedCOD into methane (up to 77%) and reductions of organic an inorganic pollution loads from swine wastewater.

Condições ambientais em galpão convencional telado para galinhas poedeiras hyline W-36

Devido às ocorrências dos vírus de influenza aviária (H5N1 e H7N2), estudos relacionados à biosseguridade têm-se intensificado, e uma das soluções discutidas é o uso de tela para cercar completamente o perímetro dos galpões, visando a evitar o contato das galinhas poedeiras alojadas com outras aves. Desta forma, o presente trabalho teve como objetivo avaliar e comparar a utilização de tela cercando o perímetro de galpões convencionais de poedeiras, sobre o ambiente acústico e aéreo no interior da instalação. A pesquisa foi realizada em uma granja comercial para produção de ovos, localizada no sul do Estado de Minas Gerais, e foi conduzida em um galpão aberto, que teve a metade de sua área cercada por tela e a outra metade mantida totalmente aberta. Foram alojadas galinhas poedeiras da linhagem Hyline W-36, sendo analisadas as variáveis de intensidade sonora, concentração de amônia (NH3) e concentração de dióxido de carbono (CO2). As variáveis foram coletadas em seis pontos de medição, em cada região (com e sem tela), dois em cada corredor (norte, central e sul). Os resultados indicaram que o uso de tela não alterou o nível de ruído e as concentrações de NH3 e de CO2 no interior do galpão analisado. Contudo, os níveis mensurados foram inferiores àqueles que ofereceriam riscos à saúde das aves e dos trabalhadores, podendo-se concluir que o uso de tela não influenciou negativamente no ambiente aéreo do galpão.

HYDROPHOBIC MEMBRANE TECHNOLOGY FOR AMMONIA EXTRACTION FROM WASTEWATERS

ABSTRACT Total Ammoniacal Nitrogen - TAN (NH3 + NH4+) in wastewaters cause environmental degradation concerns due to their negative impacts on air, soil and water. Several technologies are available for TAN removal from the wastewaters. One emerging technology is the use of hydrophobic membrane as non-destructive NH3 extraction. In this paper the authors discuss the uses of gas permeable membrane (GPM) and its physicochemical characteristics that influence gas mass transfer rate, diffusion and recovery mechanisms of NH3 from liquid sources (e.g. animal wastewater). Several aspects of NH3 extraction from liquid manure and other TAN generation sources using GPM technology as well as its applicability for NH3 mitigation from liquid effluents and possible recovery as a nutrient for plant growth are also discussed in this review.

Comparação genotípica de isolados de Corynebacterium pseudotuberculosis de caprinos e ovinos do sertão de Pernambuco

Objetivou-se com este estudo comparar genotipicamente 35 isolados de Corynebacterium pseudotuberculosis recuperados de conteúdo de abscessos de caprinos e ovinos com linfadenite caseosa, procedentes de cinco municípios localizados no Sertão de Pernambuco, Brasil. Utilizou-se a técnica de fingerprint RFLP-PCR com as enzimas de restrição Hpy-Ch4 e Msp1 aplicada ao gene rpoB e as enzimas Pst I e Msp I para o gene pld. Não houve diferença nos padrões de fragmentos de bandas entre os isolados, independente da espécie hospedeira ou da área geográfica estudada, definindo-se um padrão genotípico homogêneo de C. pseudotuberculosis responsável por abscessos superficiais na região.

Ethological activities, ruminal parameters and weight gain of calves supplemented with different amounts of sodium chloride

The daily weight gain, behavioral activities (grazing, ruminating and water consumption) and the number of rumen protozoa, pH, NH3, and the osmolarity of rumen fluid was evaluated for four groups of six calves HPB/Zebu submitted to daily intake of 15, 30, 60 and 90g of NaCl during 135 days (9th Jan. to 24th May 2008).Throughout the experimental period the calves were in perfect health condition and did not show any signs suggestive of chronic sodium poisoning. There was no significant difference in average daily gain of the calves as the intake of NaCl increased. No significant behavioral changes were observed in the activities of grazing and rumination. However, there was a noticeable change in the frequency of water consumption in the calves that ingested 90g/d of NaCl; they went more often to the trough and drank more water than the group that ingested only 15g sodium chloride/d. The osmolarity of ruminal liquid was higher in the group of calves fed 90g of NaCl/d. The pH, NH3 concentration and number of rumen protozoa was within the normal range.

Thermal radiation in combustion systems

A numerical procedure for solving the nongray radiative transfer equation (RTE) in two-dimensional cylindrical participating media is presented. Nongray effects are treated by using a narrow-band approach. Radiative emission from CO, CO2, H2O, CH4 and soot is considered. The solution procedure is applied to study radiative heat transfer in a premixed CH4-O2, laminar, flame. Temperature, soot and IR-active species molar fraction distributions are allowed to vary in the axial direction of the flame. From the obtained results it is possible to quantify the radiative loss in the flame, as well as the importance of soot radiation as compared to gaseous radiation. Since the solution procedure is developed for a two-dimensional cylindrical geometry, it can be applied to other combustion systems such as furnaces, internal combustion engines, liquid and solid propellant combustion.

Effects of different ammoniacal nitrogen sources on N-metabolism of the atmospheric bromeliad Tillandsia pohliana Mez

Increasing levels of atmospheric ammonia from anthropogenic sources have become a serious problem for natural vegetation. Short-term effects of different ammoniacal sources on the N metabolism of Tillandsia pohliana, an atmospheric bromeliad, were investigated. One-year-old, aseptically grown plants were transferred to a modified Knudson medium lacking N for three weeks. Plants were subsequently transferred to Knudson media supplemented with 0.5, 1.0, or 1.5 mM of N in the forms of NH3 or NH4+ as the sole N source. The activities of glutamine synthetase (GS) and glutamate dehydrogenase (GDH-NADH) were determined after 40 h. The GS activity was stimulated significantly by increasing the levels of the gaseous form. The GDH-NADH activity increased significantly under increasing N concentrations with NH3, while no significant differences were observed with NH4+ as a N source. These results may reflect a faster NH3 absorption by T. pohliana compared to NH4+ uptake. The increased activity of GDH-NADH in NH3 treatment may play a role in protecting the cells from the toxic effects of increased endogenous level of free ammonium. A raise in the concentration of N, especially in the form of NH3, greatly increased the content of free amino acids and soluble proteins. A possible utilisation of T. pohliana to evaluate the changes of atmospheric gaseous ammonia is proposed.

Effect of age and gender on sweat lactate and ammonia concentrations during exercise in the heat

The dependence of sweat composition and acidity on sweating rate (SR) suggests that the lower SR in children compared to adults may be accompanied by a higher level of sweat lactate (Lac-) and ammonia (NH3) and a lower sweat pH. Four groups (15 girls, 18 boys, 8 women, 8 men) cycled in the heat (42ºC, 20% relative humidity) at 50% VO2max for two 20-min bouts with a 10-min rest before bout 1 and between bouts. Sweat was collected into plastic bags attached to the subject's lower back. During bout 1, sweat from girls and boys had higher Lac- concentrations (23.6 ± 1.2 and 21.2 ± 1.7 mM; P < 0.05) than sweat from women and men (18.2 ± 1.9 and 14.8 ± 1.6 mM, respectively), but Lac- was weakly associated with SR (P > 0.05; r = -0.27). Sweat Lac- concentration dropped during exercise bout 2, reaching similar levels among all groups (overall mean = 13.7 ± 0.4 mM). Children had a higher sweat NH3 than adults during bout 1 (girls = 4.2 ± 0.4, boys = 4.6 ± 0.6, women = 2.7 ± 0.2, and men = 3.0 ± 0.2 mM; P < 0.05). This difference persisted through bout 2 only in females. On average, children's sweat pH was lower than that of adults (mean ± SEM, girls = 5.4 ± 0.2, boys = 5.0 ± 0.1, women = 6.2 ± 0.5, and men = 6.2 ± 0.4 for bout 1, and girls = 5.4 ± 0.2, boys = 6.5 ± 0.5, women = 5.2 ± 0.2, and men = 6.9 ± 0.4 for bout 2). This may have favored NH3 transport from plasma to sweat as accounted for by a significant correlation between sweat NH3 and H+ (r = 0.56). Blood pH increased from rest (mean ± SEM; 7.3 ± 0.02) to the end of exercise (7.4 ± 0.01) without differences among groups. These results, however, are representative of sweat induced by moderate exercise in the absence of acidosis.

Pré-hidrólise enzimática da gordura de efluente da indústria de pescado objetivando o aumento da produção de metano

A aplicação de preparados enzimáticos sólidos (PES) ricos em lipases foi avaliada no tratamento anaeróbio de efluente de indústria de conservas de pescado. O PES foi produzido pelo fungo Penicillium simplicissimum por fermentação em meio sólido (FMS) de resíduo industrial, sendo empregado na hidrólise de gorduras presentes no efluente a fim de viabilizar a utilização de metano como fonte de energia. O efluente contendo 1500 mg O&G.L-1 foi hidrolisado com 0,2, 0,5 e 1,0% (m/v) de PES a 30 °C por até 18 horas. O efeito do pré-tratamento enzimático dos O&G não foi significativo com relação à remoção de DQO, pois, independente das condições adotadas, obtiveram-se valores de 91 a 95%. Por outro lado, a produção específica de metano apresentou valores que variaram com a adição do PES e o tempo de hidrólise. Em experimentos controle (sem adição de PES), a produção específica de metano aumentou com o tempo de incubação, atingindo um máximo com 18 horas (138 mL CH4.g-1 DQOinicial). No entanto, valores mais elevados de produção específica de metano foram obtidos com 0,5 e 1,0% de PES, destacando-se a hidrólise com 0,5% de PES e 8 horas de hidrólise, com 216 mL CH4.g-1 DQOinicial. Quando se compara o experimento controle 0 horas (efluente bruto) com o efluente hidrolisado com 0,5% de PES durante 8 horas, um aumento de 2,7 vezes na produção específica de metano foi observado, indicando que a matéria orgânica foi mais facilmente assimilada pelos microrganismos anaeróbios nesta última condição.