Structural changes and dynamic behaviour of vanadium oxide-based catalysts for gas-phase selective oxidations

Selective oxidation is one of the simplest functionalization methods and essentially all monomers used in manufacturing artificial fibers and plastics are obtained by catalytic oxidation processes. Formally, oxidation is considered as an increase in the oxidation number of the carbon atoms, then reactions such as dehydrogenation, ammoxidation, cyclization or chlorination are all oxidation reactions. In this field, most of processes for the synthesis of important chemicals used vanadium oxide-based catalysts. These catalytic systems are used either in the form of multicomponent mixed oxides and oxysalts, e.g., in the oxidation of n-butane (V/P/O) and of benzene (supported V/Mo/O) to maleic anhydride, or in the form of supported metal oxide, e.g., in the manufacture of phthalic anhydride by o-xylene oxidation, of sulphuric acid by oxidation of SO2, in the reduction of NOx with ammonia and in the ammoxidation of alkyl aromatics. In addition, supported vanadia catalysts have also been investigated for the oxidative dehydrogenation of alkanes to olefins , oxidation of pentane to maleic anhydride and the selective oxidation of methanol to formaldehyde or methyl formate [1]. During my PhD I focused my work on two gas phase selective oxidation reactions. The work was done at the Department of Industrial Chemistry and Materials (University of Bologna) in collaboration with Polynt SpA. Polynt is a leader company in the development, production and marketing of catalysts for gas-phase oxidation. In particular, I studied the catalytic system for n-butane oxidation to maleic anhydride (fluid bed technology) and for o-xylene oxidation to phthalic anhydride. Both reactions are catalyzed by systems based on vanadium, but catalysts are completely different. Part A is dedicated to the study of V/P/O catalyst for n-butane selective oxidation, while in the Part B the results of an investigation on TiO2-supported V2O5, catalyst for o-xylene oxidation are showed. In Part A, a general introduction about the importance of maleic anhydride, its uses, the industrial processes and the catalytic system are reported. The reaction is the only industrial direct oxidation of paraffins to a chemical intermediate. It is produced by n-butane oxidation either using fixed bed and fluid bed technology; in both cases the catalyst is the vanadyl pyrophosphate (VPP). Notwithstanding the good performances, the yield value didn’t exceed 60% and the system is continuously studied to improve activity and selectivity. The main open problem is the understanding of the real active phase working under reaction conditions. Several articles deal with the role of different crystalline and/or amorphous vanadium/phosphorous (VPO) compounds. In all cases, bulk VPP is assumed to constitute the core of the active phase, while two different hypotheses have been formulated concerning the catalytic surface. In one case the development of surface amorphous layers that play a direct role in the reaction is described, in the second case specific planes of crystalline VPP are assumed to contribute to the reaction pattern, and the redox process occurs reversibly between VPP and VOPO4. Both hypotheses are supported also by in-situ characterization techniques, but the experiments were performed with different catalysts and probably under slightly different working conditions. Due to complexity of the system, these differences could be the cause of the contradictions present in literature. Supposing that a key role could be played by P/V ratio, I prepared, characterized and tested two samples with different P/V ratio. Transformation occurring on catalytic surfaces under different conditions of temperature and gas-phase composition were studied by means of in-situ Raman spectroscopy, trying to investigate the changes that VPP undergoes during reaction. The goal is to understand which kind of compound constituting the catalyst surface is the most active and selective for butane oxidation reaction, and also which features the catalyst should possess to ensure the development of this surface (e.g. catalyst composition). On the basis of results from this study, it could be possible to project a new catalyst more active and selective with respect to the present ones. In fact, the second topic investigated is the possibility to reproduce the surface active layer of VPP onto a support. In general, supportation is a way to improve mechanical features of the catalysts and to overcome problems such as possible development of local hot spot temperatures, which could cause a decrease of selectivity at high conversion, and high costs of catalyst. In literature it is possible to find different works dealing with the development of supported catalysts, but in general intrinsic characteristics of VPP are worsened due to the chemical interaction between active phase and support. Moreover all these works deal with the supportation of VPP; on the contrary, my work is an attempt to build-up a V/P/O active layer on the surface of a zirconia support by thermal treatment of a precursor obtained by impregnation of a V5+ salt and of H3PO4. In-situ Raman analysis during the thermal treatment, as well as reactivity tests are used to investigate the parameters that may influence the generation of the active phase. Part B is devoted to the study of o-xylene oxidation of phthalic anhydride; industrially, the reaction is carried out in gas-phase using as catalysts a supported system formed by V2O5 on TiO2. The V/Ti/O system is quite complex; different vanadium species could be present on the titania surface, as a function of the vanadium content and of the titania surface area: (i) V species which is chemically bound to the support via oxo bridges (isolated V in octahedral or tetrahedral coordination, depending on the hydration degree), (ii) a polymeric species spread over titania, and (iii) bulk vanadium oxide, either amorphous or crystalline. The different species could have different catalytic properties therefore changing the relative amount of V species can be a way to optimize the catalytic performances of the system. For this reason, samples containing increasing amount of vanadium were prepared and tested in the oxidation of o-xylene, with the aim of find a correlations between V/Ti/O catalytic activity and the amount of the different vanadium species. The second part deals with the role of a gas-phase promoter. Catalytic surface can change under working conditions; the high temperatures and a different gas-phase composition could have an effect also on the formation of different V species. Furthermore, in the industrial practice, the vanadium oxide-based catalysts need the addition of gas-phase promoters in the feed stream, that although do not have a direct role in the reaction stoichiometry, when present leads to considerable improvement of catalytic performance. Starting point of my investigation is the possibility that steam, a component always present in oxidation reactions environment, could cause changes in the nature of catalytic surface under reaction conditions. For this reason, the dynamic phenomena occurring at the surface of a 7wt% V2O5 on TiO2 catalyst in the presence of steam is investigated by means of Raman spectroscopy. Moreover a correlation between the amount of the different vanadium species and catalytic performances have been searched. Finally, the role of dopants has been studied. The industrial V/Ti/O system contains several dopants; the nature and the relative amount of promoters may vary depending on catalyst supplier and on the technology employed for the process, either a single-bed or a multi-layer catalytic fixed-bed. Promoters have a quite remarkable effect on both activity and selectivity to phthalic anhydride. Their role is crucial, and the proper control of the relative amount of each component is fundamental for the process performance. Furthermore, it can not be excluded that the same promoter may play different role depending on reaction conditions (T, composition of gas phase..). The reaction network of phthalic anhydride formation is very complex and includes several parallel and consecutive reactions; for this reason a proper understanding of the role of each dopant cannot be separated from the analysis of the reaction scheme. One of the most important promoters at industrial level, which is always present in the catalytic formulations is Cs. It is known that Cs plays an important role on selectivity to phthalic anhydride, but the reasons of this phenomenon are not really clear. Therefore the effect of Cs on the reaction scheme has been investigated at two different temperature with the aim of evidencing in which step of the reaction network this promoter plays its role.

Il Progetto Good Water Neighbors nella pratica quotidiana: il people to people approach alla prova delle comunità israeliane, palestinesi e giordane. L'acqua quale strumento di pace e di empowerment sociale nel quadro del conflitto arabo-israeliano

Il Medio Oriente è una regione in cui le scarse risorse idriche giocano un ruolo fondamentale nei rapporti e nelle relazioni tra gli Stati. Soprattutto nell'area di Israele, Palestina e Giordania la natura transfrontaliera delle fonti idriche condivise è considerata da qualche ricercatore come un catalizzatore del più ampio conflitto arabo-israeliano. Altri studiosi, tuttavia, vedono nella cooperazione regionale sulle risorse idriche un potenziale cammino verso una pace duratura veicolata dalla natura interdipendente delle fonti idriche comuni a più territori. Dato che l'acqua è l'elemento che per molti aspetti contribuisce allo sviluppo sociale ed economico e dato che le fonti idriche sotterranee e di superficie non conoscono confini e si muovono liberamente nel territorio, la cooperazione tra gli Stati rivieraschi delle risorse idriche dovrebbe arrivare a prevalere sul conflitto. Unica nel suo genere, l'ong trilaterale israelo-palestinese giordana Friends of the Earth Middle East, FoEME, ha fatto proprio tale auspicio e dal 1994 punta a sviluppare progetti di cooperazione per la salvaguardia del patrimonio naturale dell'area del bacino del fiume Giordano e del Mar Morto. Attraverso l'esperienza del Progetto Good Water Neighbors, GWN, avviato nel 2002, sta lavorando ad una serie di iniziative nel campo dell'environmental awareness e del social empowerment a favore di comunità  israeliane, palestinesi e giordane transfrontaliere che condividono risorse idriche sotterranee o di superficie. Operando inizialmente a livello locale per identificare i problemi idrico-ambientali di ogni comunità  selezionata e lavorare con i cittadini (ragazzi, famiglie e amministratori municipali) per migliorare la conoscenza idrica locale attraverso attività  di educazione ambientale, di water awareness e piani di sviluppo urbano eco-compatibile, il Progetto GWN ha facilitato a livello transfrontaliero i rapporti tra le comunità  confinanti abbattendo la barriera di sfiducia e sospetto che normalmente impedisce relazioni pacifiche, ha coadiuvato l'analisi dei problemi idrici comuni cercando di risolverli attraverso uno sforzo programmatico condiviso e sostenibile, per giungere infine a livello regionale ad incoraggiare la gestione idrica comune attraverso lo scambio di informazioni, il dialogo e lo sforzo/impegno cooperativo congiunto tra gli attori parte del GWN al fine di incentivare la pace attraverso l'interesse comune della tutela delle fonti idriche condivise. Gli approcci di local development e participation, le azioni di confidence building e il peacebuilding attraverso la tutela ambientale applicati con il metodo di bottom up all'interno di un contesto non pacificato come quello del conflitto arabo-israeliano, fanno del Progetto GWN un esperimento innovativo e originale. Le comunità  israeliane, palestinesi e giordane selezionate hanno imparato a migliorare le proprie condizioni idrico-ambiennali cooperando assieme e sfruttando l'interdipendenza dalle fonti idriche condivise, avviando nel contempo rapporti pacifici con società  sempre considerate nemiche. La sfida è stata quella di far comprendere le potenzialità  di una cooperazione locale, in vista di un coordinamento regionale e di uno sforzo comune in grado di generare un beneficio collettivo. La lezione appresa finora durante questi primi sette anni di Progetto è stata quella di capire che non è necessario attendere la fine del conflitto per poter essere di aiuto alle proprie comunità  o per un benessere personale, ma si può agire subito, anche nel pieno dell'Intifada al-Aqsa e con i coprifuoco.

Fresh Produce Safety and Good Agricultural Practices: Stakeholders' Perception and Consumers' Choice in Thailand

Concerns of Thai consumers on food safety have been recently increasing, especially in urban areas and for fresh produce because food safety scandals, such as chemical residues on fresh produce (e.g., cabbage) still frequently occur. The Thai government tried to meet consumer needs by imposing in the domestic market a stronger regulation aimed at increasing the baseline level of food safety assurance and by introducing a voluntary standard (based on Good Agricultural Practices or GAPs and known as Q-GAP) and the related food safety label (i.e., Q mark). However, since standards and regulations are weakly implemented in the domestic market compared to exported products, there is still a lack of Thai consumers’ confidence in the safety of local food products. In this work the current situation of GAPs adoption in Thai fresh produce production is analysed. Furthermore, it is studied whether Thai consumers place value on food safety labels available on the market, to know whether consumer demand could drive the market of certified safer products. This study contains three essays: 1) a review of the literature, 2) a qualitative study on stakeholders' perception toward GAPs adoption and 3) a quantitative study, aimed at analysing consumers' preferences and willingness-to-pay for food safety labels on fresh produce using a discrete choice experiment. This dissertation contributes to the economics of quality assurance and labelling, specifically addressing GAPs and food safety label in the fresh produce supply chain. Results show that Q-GAP could be effectively used to improve food safety in Thai domestic market, but its credibility should be improved. Stakeholder’s awareness toward food safety issues and the delivery of reliable and sound information are crucial. Thai consumers are willing to pay a premium price for food safety labelled produce over unlabelled ones. Implications for both government and business decision-makers are discussed.