Extraction of oil from pressed palm oil (Elaes guineensis) fibers using supercritical CO2

Residual fibers from palm oil production are a good source of carotene, since they contain more than 5% of the original oil, with about 5000 ppm of carotenoids. As carotenoids are thermosensitive molecules, supercritical CO₂ can be used for oil recovery, because this technique employs low temperatures. In this work results of oil extraction experiments from pressed palm oil fibers are shown. Fibers were from AGROPALMA, an industry which is located in Tailândia (Pará, Brazil). Extractions were carried out at 200, 250 and 300 bar and at temperatures of 45 and 55oC. Oil was analyzed by UV/vis spectrophotometry for total carotene determination. Results showed a large increase in extraction rate from 200 to 250 bar and a small variation from 250 to 300 bar. The total amount of carotenes did not increase in the course of extraction at 300 bar, but it showed a large increase at 200 and at 250 bar. Free fatty acids are present in amounts larger than those found in commercial oils.

A mass transfer model applied to the supercritical extraction with CO2 of curcumins from turmeric rhizomes (Curcuma longa L)

ABSTRACT: Increasing restrictions on the use of artificial pigments in the food industry, imposed by the international market, have increased the importance of raw materials containing natural pigments. Of those natural substances with potential applications turmeric rhizomes (Curcuma longa L), are one of the most important natural sources of yellow coloring. Three different pigments (curcumin, desmetoxycurcumin, and bis-desmetoxycurcumin) constitute the curcuminoids. These pigments are largely used in the food industry as substitutes for synthetic dyes like tartrazin. Extraction of curcuminoids from tumeric rhizomes with supercritical CO2 can be applied as an alternative method to obtain curcuminoids, as natural pigments are in general unstable, and hence degrade when submitted to extraction with organic solvents at high temperatures. Extraction experiments were carried out in a supercritical extraction pilot plant at pressures between 25 and 30 MPa and a temperature of 318 K. The influence of drying pretreatment on extraction yield was evaluated by analyzing the mass transfer kinetics and the content of curcuminoids in the extracts during the course of extraction. The chemical identification of curcuminoids in both the extract and the residual solid was performed by spectrophotometry. Mass transfer within the solid matrix was described by a linear first-order desorption model, while that in the gas phase was described by a convective mass transfer model. Experimental results showed that the concentration profile for curcuminoids during the supercritical extraction process was higher when the turmeric rhizomes were submitted to a drying pretreatment at 343 K.

Supercritical extraction of pupunha (Guilielma speciosa) oil in a fixed bed using carbon dioxide

The pupunha (Guilielma speciosa) is the fruit of a palm tree typical of the Brazilian Northern region, whose stem is used as a source of heart of palm. The fruit, which is about 65% pulp, is a source of oil and carotenes. In the present work, an analysis of the kinetics of supercritical extraction of oil from the pupunha pulp is presented. Carbon dioxide was used as solvent. The extractions were carried out at 25 MPa and 323 K and 30 MPa and 318 K. The chemical composition of the extracts in terms of fatty acids was determined by gas chromatography. The amount of oleic acid, a saturated fatty acid, in the CO2 extracts was larger than that in the extract obtained with hexane. The overall extraction curves were modeled using the single-parameter model proposed in the literature to describe the desorption of toluene from activated coal.

Nutrient intake and digestibility of the lipid residue of biodiesel from palm oil in sheep

ABSTRACT: The objective of this study was to evaluate the effect of inclusion of lipid residue of biodiesel originated in the processing of palm oil (Elaeis guineensis) in the diet on the digestibility of feedlot lambs. Twenty-five crossbred male castrated lambs, weighing 20±1.61 kg, were distributed in randomized blocks with five treatments and five replications. The experimental period lasted 22 days; 15 for diet adaptation, 2 for the adaptation to the indicator LIPE (lignin from Eucalyptus grandis isolated, purified and enriched, UFMG, Minas Gerais) and 5 for fecal sampling. Diets were formulated with 64% concentrate based on corn and soybean meal, 31% Massai grass (Panicum maximum cv. Massai) hay and 5% lipid supplementation from increasing levels of substitution of 0, 25, 50, 75 and 100% of palm oil for biodiesel oil from palm residue. The lambs were offered two meals a day, at 7h00 and 16h00. There was linear effect of inclusion of the residue from palm oil biodiesel on dry matter intake. There was no change in digestibility of nutrients except for ether extract. The use of biodiesel from palm oil residue up to 100% replacement for the lipid supplementation of sheep positively influences the consumption without altering the digestibility of nutrients.

Classification of honeys from Pará State (Amazon region, Brazil) produced by three different species of bees

Vinte e sete amostras de mel, produzidas em dez cidades do Estado do Pará (Região Amazônica, norte do Brasil) por três espécies diferentes de abelhas (Apis mellifera, Melipona fasciculata e Melipona flavoneata), foram analisadas em seus teores de elementos minerais (Al, As, Ba, Be, Bi, Ca, Cd, Co, Cr, Cu, Fe, K, Li, Mg, Mn, Na, Ni, Sr e Zn) e alguns parâmetros fisicoquímicos (cor, umidade, densidade, pH, sólidos insolúveis e solúveis totais, cinzas, condutividade elétrica, índice de formol, acidez livre, hidroximetilfurfural, açúcares redutores e totais e sacarose). Os teores minerais foram determinados via espectrometria de emissão atômica por plasma acoplado indutivamente (ICP OES) e as análises dos parâmetros físico-químicos seguiram metodologias oficiais. Os resultados das análises físico-químicas apresentaram-se de acordo com a legislação nacional e internacional, bem como com outros trabalhos similares ao redor do mundo. A análise estatística multivariada (análise por agrupamento hierárquico (HCA) e por componentes principais (PCA)) foi aplicada aos resultados dos teores metálicos e aos parâmetros físico-químicos, sendo possível a separação das amostras de mel conforme a espécie produtora.

Species composition and reproductive modes of anurans from a transitional Amazonian forest, Brazil

The aim of the present study was to describe the species composition and reproductive modes of an anuran community from a transition area between the Amazonia and Cerrado biomes. Data were collected in habitats exhibiting different degrees of anthropogenic degradation. The community (35 species) identified during the present study presented a larger number of reproductive modes when compared with those from Cerrado communities, but smaller than those of other sites in the Amazon. While all nine modes were recorded in the gallery forests of local rivers and streams, anthropogenic habitats (rubber tree orchards and soybean fields) were occupied only by species adapted to environments where humidity is low, typical of the Cerrado. Overall, the anuran fauna of the study area was characterized by species that depend on access to water bodies for their reproduction, with only a few specialized species able to reproduce in dry environments.

Mangrove vegetation in Amazonia: a review of studies from the coast of Pará and Maranhão States, north Brazil

O presente estudo apresenta uma compilação da literatura sobre a vegetação dos manguezais da costa norte do Brasil, apresentando uma síntese do conhecimento e listando a literatura disponível. O estudo se concentra na costa dos estados do Pará e Maranhão que formam um cinturão contínuo de manguezais. Foram contabilizadas seis espécies arbóreas exclusivas de mangue e várias outras associadas. A altura e o diâmetro das árvores de mangue variam em função de parâmetros abióticos locais. As variações sazonais do regime de chuvas e da salinidade afetam a fenologia das espécies e a produção de serapilheira. A população costeira utiliza a flora do manguezal para diferentes fins (ex: combustível, medicinal, construção rural). O aumento da ocupação costeira inicia um processo de impacto para as florestas de mangue e a disponibilidade de seus recursos.

Ceramic raw materials from the State of Maranhão, Brazil. Part 1: chemical and mineralogical characterization and technological properties of clays from São Luis, Rosário, Pinheiro and Mirinzal

Nesse trabalho, foram caracterizadas algumas argilas coletadas nos municípios de São Luís, Rosário, Pinheiro e Mirinzal. A caracterização foi realizada através dos ensaios de difração de raios X, massa específica real, capacidade de troca de cátions (CTC), área superficial, distribuição granulométrica, análise química, análise térmica (TG-DTA) e limites de Atterberg. Ensaios tecnológicos de retração linear, antes e após a queima, absorção de água e tensão de ruptura a flexão, em três pontos, foram realizados em corpos de prova prensados uniaxialmente a 20 MPa e tratados termicamente em 850, 950, 1050, 1150 e 1250ºC. Os resultados obtidos permitiram identificar duas argilas de queima branca, constituídas de quartzo, caolim, feldspato e anatásio, com excelentes propriedades para uso em cerâmica branca. As restantes são queima vermelha e possuem composição mineralógica de quartzo, caolim, feldspato, montmorilonita, hematita e goetita. Estas últimas apresentaram valores moderados de plasticidade e são adequadas para aplicações em cerâmica vermelha.

Chemical composition of phytoplankton from the estuaries of Eastern Amazonia

O fitoplancton é de grande importância para os estudos das interações solo-água, como indicadores de modificações químicas e biológicas nos ecossistemas naturais. O objetivo desse estudo foi determinar a composição química total do fitoplâncton nos estuários do rio Pará e Mocajuba (Pará, Brasil). As análises químicas foram realizadas na água superficial, sedimento de fundo (amostra total e fração biodisponível) e no fitoplancton, por espectrometria óptica e de massa com plasma indutivamente acoplado. A composição química elementar do fitoplancton é composta por elevadas concentrações de Ca, P, Mn, Fe, Zn, Al, Ba e Pb. O fitoplancton do estuário do rio Mocajuba é rico em Fe (2.967 a 84.750 µg g^-1) e do rio Pará rico em Al (1.216 a 15.389 µg g^-1), provavelmente com contribuição antropogênica. O material fitoplanctonico apresentou elevado fator de bioconcentração proveniente tanto da água quanto da fração biodisponível, e reflete a eficiência desses organismos em concentrar metais.

Evaluation of the therapeutic response of hepatitis C in coinfected patients (HIV/HCV): a study of cases from a hospital for chronic liver diseases in the Eastern Brazilian Amazon

INTRODUCTION: The aim of this study was to evaluate the therapeutic response of hepatitis C in patients coinfected with human immunodeficiency virus (HIV-1). METHODS: A retrospective study of 20 patients coinfected with HIV-1/HCV who were treated in the outpatient liver clinic at the Sacred House of Mercy Foundation Hospital of Pará (Fundação Santa Casa de Misericórdia do Pará - FSCMPA) from April 2004 to June 2009. Patients were treated with 180µg PEG interferon-α2a in combination with ribavirin (1,000 to 1,250mg/day) for 48 weeks. The end point was the sustained virological response (SVR) rate (HCV RNA negative 24 weeks after completing treatment). RESULTS: The mean age of the patients was 40±9.5 years, of which 89% (n=17) were male, and the HCV genotypes were genotype 1 (55%, n=11/20), genotype 2 (10%, n=2/20) and genotype 3 (35%, n=7/20). The mean CD4+ lymphocyte count was 507.8, and the liver fibrosis stages were (METAVIR) F1 (25%), F2 (55%), F3 (10%) and F4 (10%). The early virological response (EVR) was 60%, the end-of-treatment virological response (EOTVR) was 45% and the SVR was 45%. CONCLUSIONS: The median HCV viral load was high, and in 85% of cases in which highly active antiretroviral therapy (HAART) was used, none of the patients with F3-F4 fibrosis responded to treatment. Of the twenty patients treated, 45% achieved SVR and 45% achieved EOTVR. Studies that include cases from a wider region are needed to better evaluate these findings.