Adição de superplastificante e anti-segregante à base de CMC em pastas de cimento para Poços de Petróleo

Oil well cementing materials consist of slurries of Special class Portland cement dispersed in water. Admixtures can be used to provide the necessary fluidity, so the material can be efficiently pumped down as well as penetrate porous rocks with controlled filter loss. Construction admixtures can be used to modify the properties of oil well cements provided they can withstand and hold their properties at the higher than ambient temperatures usually encountered in oil fields. In civil construction, superplasticizer play the role of dispersants that reduce the facto r of water cement improve mechanical properties and fluidity of the cement, whereas anti-segregation agents improve the workability of the slurry. In the present study, oil well cement slurries were produced adding both a dispersant and an anti-segregation agent conventionally used in Portland CPII-Z-32 RS cement aiming at materials for primary cementing and squeeze operations. Three basic aspects were evaluated: fluidity, filter loss and the synergetic effect of the admixtures at two temperatures, i.e., 27°C and 56°C, following API RP 10B practical recommendations. The slurries were prepared using admixture concentrations varying from 2.60 Kgf/m3 (0.02 gallft3) to 5.82 Kgf/m3 (0.045 galJft3) BWOC. The density of the slurries was set to 1.89 g/cm3 (15.8 Ib/gal). 0.30 to 0.60% BWOC of a CMC-based anti-segregation agent was added to the cement to control the filter loss. The results showed that the addition of anti-segregation at concentrations above 0.55% by weight of cement resulted in the increased viscosity of the folders in temperatures evaluated. The increasing the temperature of the tests led to a reduction in the performance of anti-segregation. At concentrations of 5.20 kgf/m3 (0,040 gallft3) and 5.82 Kgf/m3 (0,045 gal/ft 3) observed a better performance of the properties evaluated in the proposed system. At low temperature was observed instability in the readings of rheology for all concentrations of anti-segregation. Contents that increasing the concentration of anti¬-segregation is limited concentrations greater than 0.55 % BWOC of the CMC in temperature analyzed. The use of the system with CMC promoted a good performance against the properties evaluated. The principal function of anti¬-segregation was optimized with increasing concentration of superplasticizer, at temperatures above the 2rC. The study of the behaviour of systemic additives, resulting in slurries of cement, which can be optimized face studies of other intrinsic properties in oil fields

Contribuição ao desenvolvimento de ontologias para processos petroquímicos : estudo de caso em uma planta DEA

In the last decades, the oil, gas and petrochemical industries have registered a series of huge accidents. Influenced by this context, companies have felt the necessity of engaging themselves in processes to protect the external environment, which can be understood as an ecological concern. In the particular case of the nuclear industry, sustainable education and training, which depend too much on the quality and applicability of the knowledge base, have been considered key points on the safely application of this energy source. As a consequence, this research was motivated by the use of the ontology concept as a tool to improve the knowledge management in a refinery, through the representation of a fuel gas sweetening plant, mixing many pieces of information associated with its normal operation mode. In terms of methodology, this research can be classified as an applied and descriptive research, where many pieces of information were analysed, classified and interpreted to create the ontology of a real plant. The DEA plant modeling was performed according to its process flow diagram, piping and instrumentation diagrams, descriptive documents of its normal operation mode, and the list of all the alarms associated to the instruments, which were complemented by a non-structured interview with a specialist in that plant operation. The ontology was verified by comparing its descriptive diagrams with the original plant documents and discussing with other members of the researchers group. All the concepts applied in this research can be expanded to represent other plants in the same refinery or even in other kind of industry. An ontology can be considered a knowledge base that, because of its formal representation nature, can be applied as one of the elements to develop tools to navigate through the plant, simulate its behavior, diagnose faults, among other possibilities

Efeitos da inclinação da esteira na marcha de indivíduos hemiparéticos crônicos

Objective: To examine the effects of treadmill inclinations on the walking of hemiparetic chronic subjects. Design: Observational descriptive study. Location: Laboratory of human movement analysis. Participants: Eighteen subjects, 10 men and 8 women were evaluated, with a mean age of 55.3 ± 9.3 years and the time since the injury of about 36 ± 22.8 months. Intervention: Not applicable. Main Outcome Measures: All subjects were evaluated for functional independence (Functional Independence Measure - FIM) and balance (Berg Balance Scale). Angular variations of the hips, knees and ankles in the sagittal plane were observed, as well as the speed of the movement (m/s), cadence (steps/min), stride length (m), cycle time (s), step time on the paretic leg and on the non-paretic leg (s), support phase time and balance phase time on the paretic leg (s) and the ratio of symmetry inter-limb as subjects walked on a treadmill at three conditions of inclination (0%, 5% and 10% ). Results: There were angular increases in the initial contact of the hip, knee and ankle, amplitude increase in the hip between 0% and 10% (37.83 ± 5.23 versus 41.12 ± 5.63, p < 0,001) and 5% and 10% (38.80 ± 5.96 versus 41.12 ± 5.63, p = 0,002), amplitude increases in the knee between 0% and 10% (47.51 ± 15.07 versus 50, 30 ± 12.82, p = 0,040), extension decreases in the hip, dorsiflexion increases in the balance phase and in the time of support phase from 0% to 5% (0.83 ± 0.21 versus 0.87 ± 0, 20, p = 0,011) and 0% and 10% (0.83 ± 0.21 versus 0.88 ± 0.23, p = 0,021). Conclusion: The treadmill inclination promoted angle changes as such as the increase of the angle of the hip, knee and ankle during the initial contact and the balance phase and the increase of the range of motion of the hip and knee; furthermore, it also promoted the increase of the support time of the paretic lower limb

Avaliação da expressão imuno-histoquímica de marcadores de hipóxia em carcinoma epidermóide de língua

The tumor hypoxia modulates a series of genetic changes related to adaptive development, invasion and metastasis of various human cancers, among which squamous cell carcinoma of the tongue (SCCT). The objective of this study was to analyze clinical, morphological and immunohistochemical expression by HIF-1α, GLUT-1 and CA-IX in 57 cases of CEL and correlated this expression to clinical parameters and morphological. After a descriptive analysis of data on gender, age, race, and habits of patients, it was found that the results were consistent with the literature. The clinical and morphological parameters analyzed and the expression of these markers of hypoxia were subjected to statistical analysis (Qui2 test), verifying that they can be used as indicators of the biological behavior of CEL. Among the results of this study, we observed that the intensity of expression for HIF-1α, in most cases located in the cytoplasm and nucleus, statistically correlated with clinical staging (p = 0.011) and histological grading (p = 0.002). As for the relationship between the distribution of labeling for HIF-1α and metastasis, the chi-square (Qui2) showed that there was statistically significant differences between the groups (p = 0.040). 75.8% of the sample who had metastases, there was the predominance of diffuse marking. The immunoexpression cytoplasmic/membrane GLUT-1 showed a statistically significant correlation with the clinical stage (p = 0.002) and histological grading (p = 0.000). Concerning the location of markings for GLUT-1 tumor on the island, there was a predominance of peripheral marking specimens in most low-grade (78.6%). In the sample of high-grade, prevailed the location center/periphery (55.8%). According to the chi-square (Qui2), the location on the island of the tumor (p = 0.025) showed statistically significant difference in histological grading. The immunoreactivity of CA-IX, in most cases located in the membrane and cytoplasm, exhibited a statistically significant correlation with histological grading (p = 0.005). Based on these results, we can conclude a broad participation of these markers of hypoxia in oral carcinogenesis and its possible use as markers of biological behavior and tumor progression in CEL

Imunoexpressão de vegf-c, vegfr-3 e hif-1α e mensuração da densidade linfática em carcinomas epidermóides de lábio inferior metastáticos e não-metastáticos: uma relação com parâmetros clinicopatológicos e prognósticos

Squamous cell carcinoma of the lower lip is among the most common malignant tumors of the oral and maxillofacial region, with good prognosis in more than 90% of patients with 5-year survival. In these carcinomas, the development of lymph node metastasis decreases the prognosis and it has been associated with the formation of new lymphatic vessels. It has been suggested the important role of vascular endothelial growth factor-C (VEGF-C), the receptor type 3 VEGF (VEGFR-3) and hypoxia-induced factor 1 (HIF-1) in this process. The aim of this study was to evaluate the immunoexpression of VEGF-C, VEGFR-3 and HIF-1α and correlate with intra and peritumoral lymphatic density in squamous cell carcinomas of the lower lip metastatic and non-metastatic. The sample consisted of 50 cases of squamous cell carcinoma of lower lip, of which 25 had regional lymph node metastasis and 25, absence of metastasis. The percentages of cells immunostained for VEGF-C, VEGFR-3 and HIF-1α in front of tumor invasion and in the center of tumor were evaluated. Microvessel density lymphatic (MDL) was determined by the counting of lymph microvessels immunostained by the anti-D2-40 in five fields (200×), in an area of evaluation with 0.7386 mm2. The invasion of the lymph vessels by malignant cells was also evaluated. Immunostaining was correlated with the presence and absence of metastasis, TNM clinical stage, local recurrence, disease outcome (remission of injury or patient death) and histological grading. The analysis of intra and peritumoral lymphatic density showed no significant association with clinicopathological parameters and immunoexpressions of VEGF-C, VEGFR-3 and HIF-1α (p > 0,05). There was a weak positive correlation, significant, between intra and peritumoral lymphatic density (r = 0,405; p = 0,004). VEGF-C showed no significant association with clinicopathological and prognosis parameters (p > 0,05). For VEGFR-3, there was scarce membrane staining and intense and homogenous cytoplasmic staining in neoplastic cells. Percentage of positive cytoplasmic VEGFR-3 in center of tumor, exhibited a statistically significant association with metastasis (p = 0,009), patient death (p = 0,008) and histological grades of malignancy proposed by Bryne et al. (1992) (p = 0,002) and World Health Organization (p = 0,003). A low positive correlation was statistically significant between the immunoreactivity of VEGFC and VEGFR-3 cytoplasmic (r = 0,358; p = 0,011) and between the percentage of positive cytoplasmic VEGFR-3 in front of tumor invasion and in the center of the tumor (r = 0,387; p = 0,005) was also demonstrated. There was no association between HIF-1α, clinicopathological and prognosis parameters, and VEGF-C and VEGFR-3. The percentage of nuclear positivity for HIF-1α was significantly higher in cases without invasion of peritumoral lymphatic (p = 0,040). Based on the results we can conclude that most cytoplasmic expression of VEGFR-3 in center of tumor in metastatic cases, high degree of malignancy and poorly differentiated, contributes to poor outcome of squamous cell carcinoma of the lower lip, including patient death. Intra and peritumoral lymphatic density seems to be not associated with lymph node metastasis in these carcinomas