Casting yield improvement in graphite iron castings

A well designed runner and feeding system should produce castings with minimal defects and low pour weight. This thesis investigates how the filling regime and solidification of the mould influences defects in the castings produced from that mould. Design guidelines to reduce such defects are proposed and tested. An existing shrinkage fault in a Grey Iron disc brake casting is simulated using a commercial finite-difference computer program. Three criteria are used to predict the defect and the effect of changes to the feeder geometry. Critical Fraction Solidification analysis is used to determine whether the feeder remains in liquid contact with the casting during solidification and this approach is shown to correctly predict the presence or absence of porosity* The feeder block is extended below the ingate of the casting to improve liquid contact between the casting and feeder without significantly increasing the feeder mass. Plant trials confirm the change to the feeder eliminates the porosity defect. The runner system and mould venting for a thin walled Ductile Iron casting are investigated. Trials show that by setting the total mould vent area to be greater than the net ingate area of the castings, the cold-shut frequency is halved. A method for runner system design based on peak linear flow velocity in the runner during mould filling is proposed. A new pressurised runner system produces castings with significantly fewer defects and reduced pour weight when runner areas are designed to maintain peak velocity below 1 m/s. Peak velocity and magnesium levels are demonstrated to be critical factors in the elimination of cold-shut defects. A pressurised runner system is also shown to isolate inclusion defects from castings more effectively than an unpressurised system. From this work, a technique is proposed which allows the yield of an existing runner and feeder system for iron castings to be improved with confidence in the results.

A blue whale (Balaenoptera musculus) feeding ground in a southern Australian coastal upwelling zone

A localised aggregation of blue whales. which may be pygmy blue whales (B. m. brevicauda), occurs in southern Australian coastal waters (between I39°45'E-143°E) during summer and autumn (December-May), where they feed on coastal krill (Nyctiphanes australis). a species which often forms surface swarms. While the abundance of blue whales using this area is unknown, up to 32 blue whales have been sighted in individual aerial  surveys. Krill appear to aggregate in response to enhanced productivity  resulting from the summer-autumn wind-forced Bonney Coast upwelling along the continental shelf. During the upwelling's quiescent (winter-spring) period. blue whales appear to be absent from the region. Krill surface  swarms have been associated with 48% of 261 blue whale sightings since 1998, with direct evidence of feeding observed in 36% of all sightings. Mean blue whale group size was 1.55 (SD =0.839), with all size classes represented including calves. This seasonally predictable upwelling system is evidently a regular feeding ground for blue whales, and careful  management of human activities is required there.

Zebra fingerprints : towards a computer-aided identification system for individual zebra

Information regarding wildlife behavioural patterns provides researchers with clearer understanding of species. Social interactions, breeding habits, feeding and migration trends are key factors influencing decisions in game management and ecological impact assessment. In order to obtain such information researchers must be able to track individual animals over a period of time. One of the commonest methods of identifying individual animals is to tag them with radio, satellite, or GPS transmitters (Mech & Barber, 2002). While these systems are very effective, they are often costly and can be traumatic for tagged animals.

Blue whale habitat selection and within-season distribution in a regional upwelling system off southern Australia

Blue whales Balaenoptera musculus aggregate to feed in a regional upwelling system during November–May between the Great Australian Bight (GAB) and Bass Strait. We analysed sightings from aerial surveys over 6 upwelling seasons (2001–02 to 2006–07) to assess within-season patterns of blue whale habitat selection, distribution, and relative abundance. Habitat variables were modelled using a general linear model (GLM) that ranked sea surface temperature (SST) and sea surface chlorophyll (SSC) of equal importance, followed by depth, distance to shore, SSC gradient, distance to shelf break, and SST gradient. Further discrimination by hierarchical partitioning indicated that SST accounted for 84.4% of variation in blue whale presence explained by the model, and that probability of sightings increased with increasing SST. The large study area was resolved into 3 zones showing diversity of habitat from the shallow narrow shelf and associated surface upwelling of the central zone, to the relatively deep upper slope waters, broad shelf and variable upwelling of the western zone, and the intermediate features of the eastern zone. Density kernel estimation showed a trend in distribution from the west during November–December, spreading south-eastward along the shelf throughout the central and eastern zones during January–April, with the central zone most consistently utilised. Encounter rates in central and eastern zones peaked in February, coinciding with peak upwelling intensity and primary productivity. Blue whales avoided inshore upwelling centres, selecting SST ~1°C cooler than remotely sensed ambient SST. Whales selected significantly higher SSC in the central and eastern zones than the western zone, where relative abundance was extremely variable. Most animals departed from the feeding ground by late April.

Ratio-dependent response of a temperate Australian estuarine system to sustained nitrogen loading

Classical resource- and the less studied ratio-dependent models of predator–prey relationships provide divergent predictions as to the sustained ecological effects of bottom-up forcing. While resource-dependent models, which consider only instantaneous prey density in modelling predator responses, predict community responses that are dependent on the number of trophic levels in a system, ratio-dependent models, which consider the number of prey per consumer, predict proportional increase in each level irrespective of chain length. The two models are only subtly different for systems with two or three trophic levels but in the case of four trophic levels, predict opposite effects of enrichment on primary producers. Despite the poor discriminatory power of tests of the models in systems with two or three trophic levels, field tests in estuarine and marine systems with four trophic levels have been notably absent. Sampling of phytoplankton, macroinvertebrates, invertebrate-feeding fishes, piscivorous fishes in Kooloonbung Creek, Hastings River estuary, eastern Australia, subject to over 20 years of sewage discharge, revealed increased abundances in all four trophic levels at the disturbed location relative to control sites. Increased abundance of phytoplankton at the disturbed site was counter to the predictions of resource-dependent models, which posit a reduction in the first trophic level in response to enrichment. By contrast, the increase in abundance of this first trophic level and the proportionality of increases in abundances of each of the four trophic groups to nitrogen loading provided strong support for ratio dependency. This first evidence of ratio dependence in an estuarine system with four trophic levels not only demonstrates the applicability of ecological theory which seeks to simplify the complexity of systems, but has implications for management. Although large nutrient inputs frequently induce mortality of invertebrates and fish, we have shown that smaller inputs may in fact enhance biomass of all trophic levels.

Flying, fasting, and feeding in birds during migration: a nutritional and physiological ecology perspective

Unlike exercising mammals, migratory birds fuel very high intensity exercise (e.g., flight) with fatty acids delivered from the adipose tissue to the working muscles by the circulatory system. Given the primary importance of fatty acids for fueling intense exercise, we discuss the likely limiting steps in lipid transport and oxidation for exercising birds and the ecological factors that affect the quality and quantity of fat stored in wild birds. Most stored lipids in migratory birds are comprised of three fatty acids (16:0, 18:1 and 18:2) even though migratory birds have diverse food habits. Diet selection and selective metabolism of lipids play important roles in determining the fatty acid composition of birds which, in turn, affects energetic performance during intense exercise. As such, migratory birds offer an intriguing model for studying the implications of lipid metabolism and obesity on exercise performance. We conclude with a discussion of the energetic costs of migratory flight and stopover in birds, and its implications for bird migration strategies.

The orexinergic system in rainbow trout Oncorhynchus mykiss and its regulation by dietary lipids

In this study, we report the distribution of orexin A (OXA), orexin B (OXB), and orexin receptor (OX2R) immunoreactive (ir) cells in the hypothalamus and gastrointestinal tract of Oncorhynchus mykiss fed diets with different dietary fatty acid compositions. Trout were fed five iso-energetic experimental diets containing fish oil, or one of four different vegetable oils (olive, sunflower, linseed, and palm oils) as the added dietary lipid source for 12 weeks. OXA, OXB, and OX2R immunoreactive neurons and nervous fibers were identified in the lateral and ventro-medial hypothalamus. OXA, OXB, and OX2R ir cells were found in the mucosa and glands of the stomach and in the mucosa of both the pyloric cecae and intestine. OX2R ir cells were localized in the mucosa layer of both the pyloric cecae and intestine. These immunohistochemical (IHC) results were confirmed via Western blotting. Antibodies against preproorexin (PPO) crossreacted with a band of ∼16 kDa in the hypothalamus, stomach, pyloric cecae, and intestine. Antibodies against OX2R crossreacted with a band of ∼38 kDa in the hypothalamus, pyloric cecae, and intestine. The presence and distribution of OXA, OXB, and OX2R ir cells in the hypothalamus and gastrointestinal tract did not appear to be affected by dietary oils. The presence of orexin system immunoreactive cells in the stomach, pyloric cecae, and intestine of rainbow trout, but not in the enteric nervous system, could suggest a possible role of these peptides as signaling of gastric emptying or endocrine modulation, implying a main local action played by orexins.

The personality behind cheating: behavioural types and the feeding ecology of cleaner fish

The complex mutualistic relationship between the cleaner fish (Labroides dimidiatus) and their 'clients' in many reef systems throughout the world has been the subject of debate and research interest for decades. Game-theory models have long struggled with explaining how the mixed strategies of cheating and honesty might have evolved in such a system and while significant efforts have been made theoretically, demonstrating the nature of this relationship empirically remains an important research challenge. Using the experimental framework of behavioural syndromes, we sought to quantitatively assess the relationship between personality and the feeding ecology of cleaner fish to provide novel insights into the underlying mechanistic basis of cheating in cleaner-client interactions. First, we observed and filmed cleaner fish interactions with heterospecifics, movement patterns and general feeding ecology in the wild. We then captured and measured all focal individuals and tested them for individual consistency in measures of activity, exploration and risk taking (boldness) in the laboratory. Our results suggest a syndrome incorporating aspects of personality and foraging effort are central components of the behavioural ecology of L. dimidiatus on the Great Barrier Reef. We found that individuals that exhibited greater feeding effort tended to cheat proportionately less and move over smaller distances relative to bolder more active, exploratory individuals. Our study demonstrates for the first time that individual differences in personality might be mechanistically involved in explaining how the mixed strategies of cheating and honesty persist in cleaner fish mutualisms.