Freeze drying of fishery products: Part IV - Biochemical changes occurring in prawn muscle during freezing, freeze drying and prolonged storage of the freeze dried product

The changes occurring in water and salt extractable protein and non-protein fractions in prawn muscle of different species during freezing, freeze drying and subsequent prolonged storage have been studied. There is no denaturation of water extractable proteins, whereas salt extractable proteins were rendered insoluble to the extent of 21% due to freeze drying. The freeze dried products remained in good edible condition for 32 months of storage up to which storage characteristics were followed.

Freeze drying of fishery products: Part V - Storage characteristics of ready-to-serve freeze dried foods

Behaviour of freeze dried ready-to-serve fish based food preparations during prolonged storage at room temp has been studied and reported in this paper. Storage life of such products under the conditions employed in this study can be reckoned in years at our ambient temps.

Effect of cooking and drying on carbonyls of oil sardine

Changes in the total as well as major individual carbonyls of oil sardine during steam cooking, oven drying, sun drying and freeze drying are presented. Carbonyls extracted with hexane were converted to their 2:4 dinitro phenyl hydrazone (DNPH) derivatives and were separated into major classes by column chromatography on celite/magnesia. Individual carbonyls were then identified by capillary gas chromatography of the DNPH derivatives. Dehydration and heating increase the carbonyl production from highly unsaturated fish lipids. The carbonyls produced react with other muscle constituents leading to complex changes. The influence of the mode of dehydration on these different aspects and their net effect on flavour are discussed.

Methode zur Bestimmung des Sandgehalts in Muschelerzeugnissen

A method to estimate the sand content in mussel products is described. It is based on the § 35 method for measuring the hydrochloric acid-insoluble portion of tomato purée, modified by freeze-drying of the sample during the preparation. By increasing of the volume of the sample it is also possible to minimise the standard deviation and the coefficient of variation.

Improvement in the nutritive quality of soyabean meal by co-ensiling with under-utilized fish discards

Improvement in the nutritive value of soybean meal was investigated by Co-ensiling it with underutilized trash fish discards (gizzard shad)at different proportions. The following proportions of gizzard shad to soybean meal were used; (a) 100% gizzard shad + acid combination (b)80% gizzard shad +20% soybean meal & 10% WB (c) 60% gizzard shad + 40% soybean meal & 10% WB (d) 100% gizzard shad without acid combination. Co-ensiling was achieved by adding sufficient acid to produce a paste. Products were neutralized by addition of 2% (by weight) calcium hydroxide and drying was affected by freeze-drying.The dried silage products were stored at low temperatures. Products were analysed for proximate composition and amino acid composition.The amino acid composition and ration of essential amino acid. Non essential amino acid (EAA/NEAA) was used as index of nutritive quality. Also essential amino acid profile of the co-ensiled products were compared with essential amino acid requirement of some warmwater fish species to estimate their nutritive usefulness for these species

The meaning of some common terms used in sampling toxic phytoplankton

The author explains some aspects of sampling phytoplankton blooms and the evaluation of results obtained from different methods. Qualitative and quantitative sampling is covered as well as filtration, freeze-drying and toxin separation.

Studies on the chemical and nutritional quality of protein powders isolated from shrimp waste

Protein powders were prepared from processing waste of prawns either by mechanically squeezing the shell and freeze drying the resultant aqueous extract or by treating the shell with 0.5% sodium hydroxide, filtering it and freeze drying the filtrate. Comparative studies on the proximate composition, amino acid profile, consumer acceptability and nutritional quality of the protein powders showed that the product prepared by freeze drying of the press liquor obtained by passing the waste through a hand operated expeller is better in all aspects studied than the product prepared by mild alkali extraction.

Drying of fish--factors to consider

Although one of the best possibilities for raising the animal protein of the diets of Nigerian is to increase the consumption of fish; particularly through the use of several methods of long term preservation techniques, such as drying, no radical approach has yet emerged. Although, a great deal of the artisanal fish catch is dried for the huge consumer and distant markets, the traditional methods of fish preservation need improvements to cope with demand for increased quantity, shelf-stable, and improved quality of fish products. The paper discusses drying requirements, heat and mass transfer, consumer acceptance, fuel sources, storage and marketing of dried fish products; and suggest ways and means of structurally transforming the artisanal technology of fish drying

River Leven (at Newby Bridge) freeze coring report

This is the River Leven (at Newby Bridge) freeze coring report produced by Lancaster University in 2000. This study looks at fine materials in river Leven that may have to be considered detrimental to successful salmonid spawning. Following an observed decline in quality of salmonid fisheries at the site an investigation was initiated to assess the extent of ingress of fine sediments into the spawning gravels. A broader picture was sought by sampling both above and below the weir and close to both banks of the river. A comparison of the fine sediment from each sample site was undertaken. All the freeze cores used in this report contained distinct horizontal strata down through their length. The cores often penetrated into a highly compacted layer of light grey coloured material. The upper surface of this highly compacted layer is considered as a boundary between fine materials of different origin. Considerable variability was observed in the median grain size (D50) of the gravels from the cores. In addition variability was observed in the thickness of the upper less compacted layers. The role of regulated river flow across the weir in clearing fines from river gravels is briefly considered.

River Crake (at Bouthrey Bridge) freeze coring report

This is the River Crake (at Bouthrey Bridge) freeze coring report produced by Lancaster University in 1999. This study looks at fine materials in river Crake at Bouthrey Bridge that may have to be considered detrimental to successful salmonid spawning. Following an observed decline in quality of salmonid fisheries at the site an investigation was initiated to assess the extent of ingress of fine sediments into the spawning gravels. Fine sediments from one potential source, upstream riverbanks, are also compared to those isolated from the spawning gravels. The percentage by weight of fine sediments for the six freeze cores, was found to be lower than first expected, given the visual appearance of the reach. However the fines were found to be distributed evenly down the cores with a marked absence of an upper, coarse gravel armour layer. In addition the median grain size (D50) of the six samples was generally low, falling to 6mm for core 5. The low median grain size and the absence of coarse grained upper strata are considered detrimental to the success rate of salmonid spawning.

Effects of different types of drying on the nutritive value of proteins in the fishmeals

A comparative study on the effect of different types of drying on the nutritive value of the proteins in the different fishmeals of known history was made. From the observations, it is clear that the mode of drying has got little or no effect on the nutritive value of the meal as revealed by the chemical indices of available lysine and pepsin digestibility, provided enough precautions were taken to avoid scorching during drying process. Sun dried meals are in no way inferior to the meals prepared by hot-air, steam or vacuum drying.

An accelerated method of hot air drying of fish

The effects of temperature and relative humidity on the rate of drying of split open fish and salted fish in a tunnel dryer have been studied at a constant air velocity. By a judicious combination of these two, the rate of drying could be considerably accelerated, 10 to 12 hours only being required for drying to moisture levels below 30% in the case of mackerel, lactarius, otolithes and kilimeen (Nemipterus japonicus)

On sun-drying of Bombay duck

Sun-drying of Bombay duck by hanging on scaffolds gave better products than those obtained by drying them in trays. Optimum rate of drying and quality of dried product were obtained when the fish were suspended at the rate of 50 to 60 per meter length of the rope. The quality of the raw material as affected by the delays in different hauls in the fishing trip was reflected in the dried products also.

Investigations on wooden floating materials: the loss of buoyancy under continuous immersion in water and the rate of its redemption by drying

A wooden fishing float under immersion in water for long periods is liable to absorb water, the quantity of water absorbed possibly being dependent upon the physical factors like the specific gravity and the inherent property of the material, the time of soaking and the pressure acting on it. Consequently a wooden float is likely to become heavy and loss its original buoyancy. However, when the float is removed from water and dried, the lost buoyancy is regained on complete drying. The present paper is an attempt to elucidate these two important characteristics of some of the chief wooden floating materials used on the West Coast of India.

Preparation of mussel meat by drying

The paper describes a simple and cheap process for the preservation of mussel meat by drying. The method involves blanching the mussel meat shucked from purified live mussels in 5% boiling brine for 5 min followed by drying to moisture of 10 to 15%. The product stored in glass bottles or polythene bags suitably sealed, has a storage life of about six months after which the organoleptic qualities begin to deteriorate. No preservative is used at any stage of processing and the yield of the product is approximately 20%. The major type of spoilage during storage is brown discoloration. Spoilage due to insect infestation is also common unless packed properly.