Antibiotic sensitivity of Staphylococcus aureus strains isolated from fishery products

During the course of an investigation on the incidence of Staphylococcus aureus contamination in frozen crab meat, frozen prawns and dried fishes from Cochin, 116 strains of S. aureus were isolated. The sensitivity of the isolated strains towards nine antibiotics showed that all the S. aureus strains were sensitive to kanamycin and streptomycin (100%). Sensitivity to other antibiotics like chloramphenicol, polymyxin-B, erythromycin, tetracycline, neomycin, penicillin and ampicillin were shown by 98.28, 93.10, 87.93, 68.10, 67.24, 56.90 and 55.17 percent of the isolates respectively.

Quality of certain ready-to-eat fish products of the domestic trade

Quality of 181 samples of ready-to-eat fish products comprising fried fish, fish curry and fish/prawn pickles collected from Cochin and Calicut were studied. Salmonella was absent in all the samples. V. cholerae was tested in the samples collected at Cochin and was absent in all the cases. Coliforms, E. coli, faecal streptococci and coagulase-positive staphylococci were present in some of the samples studied. The study indicated the necessity to improve the sanitary and hygienic conditions of the hotels engaged in the preparation of these products. The study further indicated that fried fish and fish curry shall not be served after 6 hours of their preparation. Added care is to be exercised in the selection of shrimps and fish for the preparation of pickles.

Occurrence of enterotoxigenic staphylococci in frozen fishery products

Sixty six samples of frozen fishery products consisting of frozen crab meat, frozen prawns, frozen cuttlefish and frozen mussel collected from nine cold stores situated in and around Cochin city were examined for coagulase positive staphylococci. Forty eight samples (72.72%) revealed the presence of coagulase positive staphylococci, which were then tested for enterotoxigenity, employing cellophane-over-agar method for toxin production and optimum-sensitivity-plate (OSP) method for toxin detection. Seventy seven out of one hundred and two (75.49%) coagulase positive staphylococcal isolates from the above products produced enterotoxins A, B, C, D and E either singly or in combinations. Enterotoxin A and D were detected more often than others. The occurrence of enterotoxigenic staphylococci in frozen fishery product is reported for the first time in this country.

Incidence of arthropods in dried fish products

Arthropods have been recorded from various types of insect infested dried fish products stored in the laboratory. They have been identified as Suidesia nesbetti Hughes (Acaridae) infesting dried anchovies and dried mussel, Dermestes ater Dermestidae coleoptera) attacking wet cured sardines and smoked catfish and Stegobium panicium infesting smoked catfish and dried mussel. Incidences of Stegobium panicium in dry fish products and Suidesia nesbetti in dried mussel has been recorded for the first time.

Incidence and low temperature survival of coagulase positive staphylococci in fishery products

Coagulase-positive staphylococci was found to be absent in all the frozen samples of lobsters, cuttle fish, cat fish, seer fish and red snapper examined. Coagulase-positive staphylococci were present in 38% of the cooked frozen shrimps and only 16% of the samples had staphylococci count more than 100/g. In the case of headless, peeled and deveined, peeled undeveined shrimps, the incidence of the organism was 6, 12 and 16% respectively. The study indicated that the incidence of coagulase-positive staphylococci is not a serious problem in frozen fishery products processed in this country. There was remarkable difference in the rate of destruction of coagulase-positive staphylococci in raw and cooked shrimps during freezing and frozen storage.

Levels of cadmium in seafood products

The concentrations of total cadmium were determined in 448 samples of processed fishery products comprising crustaceans, molluscs, marine fish and brackish water fish. Shrimp product, the major export item, contained on average 0.122 ppm cadmium and 20% of crustaceans analysed did not contain cadmium on detectable level. Average content of cadmium in 68 marine fish of 9 species was 0.153 ppm and 35% of the samples did not contain the element. Of the total number of crustaceans analysed only 2% showed a level > 0.5 ppm. All the 174 samples of molluscan products, except 3 canned oysters, showed cadmium concentration far below the limit allowed. The average cadmium content in molluscan products was 0.552 ppm.

Incidence and low temperature survival of Salmonella in fishery products

Salmonella was isolated from 12% of PD shrimps, 10% of HL shrimps, 14% of PUD shrimps, 17% of lobsters, 14% of cuttle fish, 25% of cat fish and 20% of seer fish (all frozen) tested. One percent of the fish meal, 4% of dried non-penaeid prawn and 23% of sea beach sand showed incidence of the organism. Salmonella was also isolated from 2 and 4% of the swab samples of utensil surfaces and the floor surface of the processing hall respectively as well as from 1% of the process water tested. All the serotypes of Salmonella tested were resistant to freezing at -40°C, but during subsequent storage at -20°C, there was some difference between the serotypes with regard to their viability, S. paratyphi B being the most resistant which survived up to 9 months while S. saintpaul the least resistant having survival up to 5 months only.

On the pattern of Salmonella serotypes in fishery products, froglegs and processing environments

Thirty four different serotypes of Salmonella have been isolated from aquatic products. The number of serotypes from frozen froglegs were 22. Only four serotypes were isolated from frozen shrimps. S. weltevreden predominates in frozen shrimps and fish. S. roan and S. larochelle were isolated for the first time in India. Isolation of six rare serotypes of Salmonella has also been reported.

Reliability of Escherichia coli and faecal streptococci as indicators of Salmonella in frozen fishery products

The results obtained in the present study suggest that Escherichia coli and faecal streptococci are of little value as indicators of the possible presence of Salmonella in frozen fishery products.

Quality assessment of traditional and solar tunnel dried SIS (Small Indigenous Fish Species) products

Studies were conducted to assessment the quality of traditional and solar tunnel dried SIS products. The moisture content of the solar products ranged from 14.38 to 18.48% with the lowest in batashi and the highest value in tengra. The moisture content of the traditional products was in the range of 23.26 to 26.42%. The range of protein contents on moisture free basis was from 67.57 to 71.90% in solar dried fishes with highest value obtained in dhela and lowest value in batashi. These values were more or less similar to those of traditional dried SIS products which were in the range of 68.02 to 73.54% on dry weight basis. Lipid contents of solar dried SIS varied from 14.10 to 16.26% and on moisture free basis the in the range of 11.73 to 21.98 with highest value found in tengra and lowest in puti. These values were more or less similar to those found for traditional dried products on dry weight basis and ranged from were 12.37 to 22.43%. Maximum reconstitution of solar dried products was obtained at 80°C in all samples and was in the range of 65.26 to 70.51% where the percentage of reconstitution increases with the increase of socking time and reach maximum at the end of up to 60 min. The TVB-N content of solar dried fish is low compared with traditional one ranging from 20.30 to 28.40mg/100g and peroxide value in the range of 12. 54 to 19.20meq./kg oil. The TVB-N of traditionally dried products were in the range of 32.50 to 45.45mg/100g and PO values of the traditionally dried products were in the range of 30.00 to 36.00meq./kg oil. The bacterial load of the solar dried products was in the range of 4.0x10 super(3)/g to 3.6x10 super(5)CFU/g and of the traditionally dried products ranged from 1.45x10 super(5) to 2.52x10 super(6) CFU/g.

Quality assessment of traditional, rotary and solar tunnel dried small indigenous fish species products

Studies on the quality assessments of three traditional, rotary and solar tunnel dried SIS products were conducted. Organoleptic quality of traditional dried SIS products available in the markets was poor compared to those produced in rotary and solar tunnel dryer. Reconstitution of samples were in the range of 54.26% to 75.24%, 69.37% to 83.73% and 55.08% to 80.24% when soaked at 80°C for traditional, rotary and solar tunnel dried products, respectively. The percentage of reconstitution increased with the increase of soaking time and the uptake of water was maximum after 60 min of soaking. The moisture contents of traditional, rotary and solar tunnel dried products were in the range of 26.02% to 27.33%, 16.23% to 22.84% and 13.71% to 19.30%, respectively. The protein contents were in the range of 60.78% to 72.59%, 62.17% to 76.27% and 61.11% to 76.00%, respectively; lipid contents were in the range of 12.26% to 22.60%, 14.00% to 24.71% and 13.92% to 22.39%, respectively and ash contents in the range of 15.11% to 16.59%, 8.32% to 13.51% and 8.71% to 16.45%, respectively on dry matter basis. The TVB-N content of rotary and solar tunnel dried products was low compared to traditional one ranging from 10.64 to 17.52 mg/100g and 14.34 to 15.68 mg/100g, respectively whereas the TVB-N content of traditional samples was in the range of 15.46 to 20.36 mg/100g. The bacterial load of traditional, rotary and solar tunnel dried products were in the range of 1.43x10 super(8) CFU/g to 2.89 x10 super(80 CFU/g, 1.91x10 super(8) CFU/g to 2.84x10 super(8) CFU/g and 1.95x10 super(8) CFU/g to 2.59x10 super(8) CFU/g, respectively. The results of the study indicated that dried fish products from rotary dryer and solar tunnel dryer were found to be of better quality in nutritional and food quality aspects than those of traditional dried products.

Shelf-life of rotary and solar tunnel dried SIS products under different packaging and storage conditions

A study was conducted on the shelf-life of rotary and solar tunnel dried SIS products under different packaging and storage conditions. Organoleptically dried products were found in good condition after a storage period of 60 days in ambient and chilled conditions. The moisture content, TVB-N value and bacterial load slightly increased during 60 days of storage in ambient and chilled conditions. The changes in moisture content and bacterial load were faster in ambient temperature than in chilled storage condition whereas changes in TVB-N value was higher in chilled condition than in ambient temperature. The initial moisture content was in the range of 13.71% to 22.84%. After 60 days of storage in ambient and chilled condition the moisture content of dried products was in the range of 15.09% to 25.11% and 14.49% to 25.01%, respectively. The initial TVB-N value was in the range of 10.64 to 17.52 mg/100g and after 60 days of storage in ambient and chilled condition, TVB-N value was in the range of 29.00 to 34.82 mg/100g and 31.41 to 39.11 mg/100g, respectively. The initial bacterial load was in the range of 1.91x10 super(8) to 2.84x10 super(8) and after 60 days of storage in ambient and chilled condition, the bacterial load was in the range of 6.2x10 super(8) to 1.8x10 super(9) and 5.75x10 super(7) to 5.05x10 super(8) CFU/g, respectively. The results of the present study indicated that it is necessary to store high quality dried products in sealed packed in chilled condition to ensure good quality up to a certain period of time.

Organoleptic, biochemical and bacteriological aspects of the low cost tunnel dried fish products

Studies were conducted on the organoleptic, biochemical and bacteriological aspects of three dried fish products produced from two different model of low cost solar tunnel dryer. The overall quality of the products obtained from both dryers was excellent. Sixty minutes soaking showed the maximum water reconstitution of the products with values between 66.82 to 75.28% and 71.98 to 78.09% in dryer 1 & 2 respectively. The highest reconstitution was obtained from Silver Jew fish (75.28-78.09%) and lowest from Bombay duck (66.86-71.98%) from both dryers. The average moisture, protein, lipid and ash content of the dried products were 11.8-15.0%, 57.32-68.49%, 6.08-8.62% and 12.25-14.88% respectively in fish in dryer 1 and dryer 2. The TVB-N values were in the range of 24.3 to 30.9 in dryer 1 and 22.1 to 28.2 mg/100 g samples in dryer 2. The highest values were obtained from Bombay duck and lowest value in Silver Jew fish in both dryers. The peroxide values varied from 14.1 to 16.9% in dryer 1 and 13.3 to 16.4% in dryer 2. The highest peroxide value was obtained from Ribbon fish and lowest from Silver Jew fish. Total bacterial load varied in the range of 6.6x10⁴— 8.6x10⁴ CFU/g in dryer 1 and 2.54x10⁴ to 4.9x10⁴ CFU/g in dryer 2. The highest value was obtained from Ribbon fish and lowest from Silver Jew fish.

Production of quality dried small indigenous fish species products using low cost solar tunnel drier

A low cost solar drier was constructed using locally available materials. The size of the drier was 20x3.6x3 having drying capacity of 80 kg of SIS (w/w). Optimization of moisture content was observed for mola, dhela, chapila, chanda and puti at temperature ranges between 40-45°C and 50-55°C in solar tunnel drier. There was little or no change in moisture content at temperature below 40°C during the first 3 hours. Then the moisture content declined gradually with the increase of drying period. On the other hand, at temperature between 50-55°C, moisture content started to decline after 2 hours of drying. The moisture content of the sample reached at about 16% after 26 hours of sun drying at 40-45°C and 20 hours at 50-55°C. The optimum temperature for producing high quality dried products was 45-50°C in solar tunnel drier. The temperature and relative humidity outside and inside the dryers (with fish) at various locations were recorded from 8.00am to 4.00pm. The normal atmospheric ambient temperature was recorded in the range of 25-37°C from at 8:00am to 4:00pm. During the same period the atmospheric relative humidity recorded was in the range of 30-58%. On the other hand, the maximum temperature inside the dryers was recorded in the range of 28-65°C. The lowest temperature recorded was 28°C in the morning and at 13.00pm the highest temperature 65°C was recorded. The maximum relative humidity 58% found in the afternoon and minimum of 28% at noon. There was inverse relationship between temperature intensity of sunshine and humidity which decreased as sunshine increased. In total, it took around 26 hours of drying to reduce the moisture level to about 16%.

Fish products of 6 Asian countries

The paper gives an overview of the 11 main categories of fish products resulting from the survey in Brunei Darussalam, Indonesia, Malaysia, Philippines, Singapore and Thailand.