Evaluation of the nutrient composition of some unconventional feedstuffs

A trial was carried out to evaluate the nutrient composition of some unconventional feedstuffs to ascertain their suitability for incorporation into fish feed. Pawpaw seed, mudskipper meal, water melon seed, almond kernel and groundnut husk were processed and analyzed for their proximate and mineral composition using internationally established procedure. The results obtained showed that the experimental feed stuffs had percentage crude protein that ranged from 7.38% to 55.85%. The highest level (55.85%) was found in mudskipper meal while the lowest (7.38%) was found in groundnut husk. The experimental feed stuffs had appreciable levels of calcium, potassium and phosphorus ranging from 0.29% to 1.87%, 0.17 to 1.26 and 0.06 to 0.97 respectively. Almond kernel can be used to replace soybean meal in aqua feed. Also, mudskipper meal can be used to replace fish meal in order to produce a cheaper fish feed; but it was recommended that feeding trials should be conducted to ascertain the inclusion level at which they can be effectively incorporated. The potentials of some of these feedstuffs in fish feed formulation seem high.

Growth and survival of Clarias batrachus (Lin.) larvae fed on formulated diets

An experiment was conducted for a period of 28 days using 7-day old C. batrachus larvae of initial total length (±S.D.) of 7.4 ± 0.49 mm and weight (±S.D.) of 2.8 ± 0.75 mg. Five test diets viz. diets I, II, III, IV and V were prepared. Diet I was formulated using 30% fish meal (FM), 20% soybean meal (SM) and 20% Baker's yeast (BY), diet III using 15% FM, 20% SM, 15% cotton seed meal and 30% BY and diet IV using 20% FM, 30% BY and 30% powdered milk. The remaining two diets (diets II and V) were prepared using minced clam meat (96%) and BY (90%) respectively as the sole source of protein. Three replications were used for each treatment. The larvae fed on diet II exhibited significantly (P<0.05) better length gain and specific growth rate (SGR) than those of the larvae fed on diet III and there was no significant difference among the length gain and SGR of the larvae fed on diet I,II,IV and V. The larvae fed on diet II also showed significantly better weight gain and survival than those of the larvae fed on other diets. There was no significant difference between the condition factor of the larvae fed on diet II and IV. However, the larvae fed on diet II showed better condition factor than those of the larvae fed on other diets.

Development of low-cost feed for culture of giant freshwater prawn (Macrobrachium rosenbergii de Man) in ponds

An experiment was conducted for 105 days in 12 earthen mini ponds of each 30m² size. Five different experimental diets containing 32% protein were formulated and prepared using fishmeal, shrimp meal, soybean meal, mustard oil cake, sesame meal, wheat bran and rice bran. A commercial shrimp diet (SABINCO starter-III) was assigned to treatment six and considered as the control. Prawns were stocked at the rate of 2.5 fry/m² and feed twice daily at the rate of 10% at the beginning and reduced to 8% for the last two months. The results of the experiment showed that prawn fed diets 1, 2, and 6 (control) showed significantly (P<0.05) highest weight gain among the dietary groups, while prawn fed diet 5 showed significantly lowest weight gain. The FCR values of diets ranged between 3.06 to 4.85. Prawns fed diet 1 and 6 showed significantly higher SGR, survival (%) and production among the dietary groups. The survival (%) of the prawns ranged between 46.6 to 66.6% and the production ranged between 304.5 to 563.3 kg/ha/105 days. The result of the study showed that diet containing 30% fishmeal, 5% shrimp meal, 5% soybean meal, 10% mustard oil cake, 10% sesame meal, 20% wheat bran, 18% rice bran, 1% oyster shell and 1% vitamin premix may be recommended for monoculture of M. rosenbergii.

Dried fish cakes with improved texture

To overcome the problem of underutilization of marine by-catches, Basu et al. (1985) developed fish cube from minced fish meat. Although the product was acceptable, it had little rubbery texture. An attempt was made to improve the texture of the cake by several methods. It was found that 5% tapioca starch along with 3% texturised soybean protein improved the texture and juiciness of the rehydrated product. Preheating of the minced meat at 70°C for 30 minutes also improved the texture appreciably. It was also found that mixing of the ingredients at low speed (less than 100 rpm) in a dough mixer gave the best texture, higher speed and sharp blades leading to rubbery texture. The dehydrated product (moisture 19-20%) thus prepared had a shelf life of six months at ambient temperature.

Effects of physiological doses of vitamin D sub(3) (Cholecalciferol) on induced molting and growth in giant freshwater prawn, Macrobrachium rosenbergii (de Man)

Effects of three different doses of vitamin D sub(3) on molting, growth, and calcium and phosphate composition of tissue and molt during the grow-out of the giant freshwater prawn Macrobrachium rosenbergii (average weight 10.56 ± 0.20 g), obtained from a grow-out pond, were studied. Intramuscular doses of vitamin D sub(3) (100, 500 and 2000 IU/kg body weight) were given on the 1st, 3rd, 5th, 7th, 9th, 11th, 13th, 15th, 20th, 25th and 30th days. All the experimental animals were fed with a basal diet containing fish meal, shrimp meal, wheat flour, groundnut de-oiled cake, soybean meal and wheat bran at 3% of the body weight. The numbers of molts were recorded as 20±0.50, 29±1.16, 51±1.87, and 30±1.60 in control, 100, 500 and 2000 IU/kg body weight physiological doses, respectively. Maximum growth was recorded in prawns given 500 IU/ kg dose. Survival was between 58.33 ± 9.13 and 77.77 ± 8.61%. The ash content and calcium level increased significantly (p<0.05) and recorded the highest values in 500 IU/kg physiological dose. However, the inorganic phosphate (P sub(i)) content recorded the highest values in tissue in 2000 IU/kg dose (p<0.05, F = 50.60613). There is no significant difference in calcium contents (p>0.05) in both tissue and molt at 500 and 2000 IU/kg doses. It was found that a higher physiological dose (2000 IU/kg) of vitamin D sub(3) increased the rate of mortality. Results have shown that vitamin D sub(3) has a positive impact on the growth and survival of M. rosenbergii and it interferes with the metabolism of Ca and P sub(i), in tissue, and alters molting frequency. Results on physiological dose suggest an alternative and effective dietary supplementation method of vitamin D sub(3) in the grow-out phase of M. rosenbergii.

Input-output relationship and economics of pangas monoculture and carp-pangas polyculture in two districts of Bangladesh

An attempt was made to study the input-output relationships and economics of pangas monoculture and carp-pangas polyculture in Bangladesh. By analyzing the data collected from 50 pangas farms and 55 carp-pangas farms, the study has investigated the production systems of two technologies and the effects of fingerling stocking and applications of feed and fertilizer on fisheries income. The data were collected from the fishermen of Trishal and Bhaluka of Mymensingh district, and Kahaloo and Adamdighee of Bogra district during 2001-02. For pangas monoculture, the stocking density was 31,561 per ha while it was 55,017 per ha in carp-pangas polyculture. Most of the farmers used urea, TSP and lime before stocking. Rice and wheat bran happened to be the most common feed ingredients for both types of culture in general. Other important ingredients used were mustard oil-cakes, rice polish, wheat flour, fish meal, bone meal, soybean meal and poultry litter. In terms of quantities, rice bran and wheat bran dominated the farmers list. Rice and wheat bran together constituted about 60% of all studied feeds. Feed cost constituted 59.13% of total costs for pangas monoculture and 67.44% for carp-pangas polyculture. Per ha productions of pangas and carp-pangas in a single culture cycle were 15,508 kg and 19,745 kg, respectively. Per ha gross profits were estimated to be Tk 310,311 and Tk 464,418 for pangas monoculture and carp-pangas polyculture, respectively. Net profit appeared to be Tk 264,216 per ha for pangas monoculture and Tk 416,509 per ha for carp-pangas polyculture. The BCRs calculated were 1.46 and 1.68 for monoculture and polyculture, respectively. The break-even costs per kg of fish were estimated at Tk 36.93 for pangas and Tk 30.93 for mixed species which was much lower than the prices the producers received. Break-even productions were estimated at 10,702 kg per ha for pangas monoculture and 11,784 kg per ha for carp-pangas polyculture. Fingerling and feed cost, and pond size significantly explained the variation of income from pangas monoculture. These factors have significantly influenced the income from the crop. Functional analysis shows that 1% increase in the feed cost might increase 0.51% of pangas income and 0.41% in carp-pangas income. No other inputs had shown this much of responses to increasing income from a fish.

Preliminary chemical and physical evaluation of some formulated feeds for P. monodon

The culture of Penaeus monodon has explicitly defined the need for diet formulations or supplementary feeds that would promote optimum growth and survival of the animal. A total of 28 feed combinations were developed for P. monodon. Fish meal, shrimp head meal, squid head meal, Ascetes spp. rice bran, and soybean cake were used as primary ingredients in these feeds. The commercial vitamin mix No. 22 was added to the dry ingredients. Gelatinized corn starch and wheat flour were used as binders. The pellets were extruded using a portable kitchen grinder with a diameter of 4 mm. The products were either sun-dried for 8 hours or oven-dried overnight at 50 degree C to stabilize moisture at 8-10%. The pellets were then kept in covered glass bottles and stored in the laboratory at room temperature. The cost of the feeds excluding labour were also computed. The pellets were analyzed for protein, fat, carbohydrate, crude fiber, ash, and moisture contents using standard procedures. They were also analyzed for water stability. To test the stability of pellets in water, 2-g samples were placed in plankton nets (mesh #40) and suspended in water for two, and six hours. The undissolved samples were then vacuum-dried and the moisture determined. Cost of the feeds ranged from P1.10 to P2.60 per kg depending on the feed ingredient. Squid and Ascetes spp. were rather expensive for use as basic ingredients. Proximate analysis of dry weight showed percentage protein content ranged from 20-63 g; fat, 8-20 g; carbohydrate (by difference), 11-36 g; ash, 8-28 g; moisture, 6-11 g; and crude fiber, 5 . 13 g. Stability tests showed that after two hours, 35-88% of solids remained intact and after 6 hours, 20-55% of the pellets remained undissolved. When a pellet disintegrates easily, pollution of the water occurs. Chances for the shrimp to feed on the pellet is minimized when the pellet is unstable. Thus, the search for a more compact feed pellet has to be continued.

Preliminary biological evaluation of some formulated feeds for P. monodon

Rice bran is widely used by fish farmers as supplementary feed while soybean cake is used both as feed and as fertilizer in fishponds. Both fish meal and shrimp head have been found acceptable as feed ingredients. However, not much is known of the acceptability and efficiency of a mixture of these ingredients as feed for Penaeus monodon larvae. Ninety 127-day old P. monodon were measured for length and weight and were randomly divided into nine aquaria each containing 20 liters of water. These were fed 'lampirong' for two months previous to the study. There were three replications for each treatment. Length, weight, and survival rates were used to compare the efficiency of the diets. Weighed amounts of pellets equivalent to 100% of the body weight were fed during the first three days and reduced to 50% thereafter. A stopwatch was used to determine the length of time that elapsed before the shrimps would approach the pellet. Ten shrimps approximately 4 months in age were placed in 10 liters of water in a 25-liter aquarium. Two grams of each pellet type were placed simultaneously on opposite sides of the aquarium. The time that elapsed from the moment the pellets sunk to the bottom up to the time that any one shrimp approached the pellets was recorded. The group fed the imported pellets gained the most. Those fed FP-2s-77 elongated faster than those fed FP-1s-77. Survival rate of those fed FP-2s-77 was 37% while those fed imported pellets was 73%. Both 1s and 2s pellets disintegrated in water easily but the imported pellets were stable even after six hours in water. The attractability test for the pellets showed that the prawns were more readily attracted to the pellets 1s and 2s than to the imported pellets.

Effect of varying crude protein levels on spawning frequency and growth of Sarotherodon niloticus breeders

Four-month-old S. niloticus breeders were fed with dry pellets containing 20-50% crude protein and the frequency of spawning involving removal of egg from the mouthbrooding females and growth were determined. When the diets contain high quality proteins from fish meal and soybean oil meal and the amounts of daily food allowance are at satiation level, the influence of increasing dietary crude protein on spawning frequency involving egg removal from the brooder and growth may not be significant.

Species diversification in coastal aquaculture: production potentials of shrimp (Penaeus monodon) with mono and mixed sex tilapia

An experiment of 120 days of culture was conducted in brackishwater earthen ponds having an area of 0.2ha each. The hatchery produced shrimp (Penaeus monodon) post larvae were stocked in the 40m² fine meshed nylon net nursery enclosures were fed with commercial pellet feed. After two weeks of nursing, juveniles were allowed to spread in cultural pond by opening the fence. Fingerlings of three different strain of tilapia were stocked as shrimp and Strain-1 all male (monosex) (T1), shrimp and Strain-2 all male (T2), shrimp and Strain-3 mixed sex population (T3) @ 20.000/ha and 10.000/ha, respectively and shrimp only (monoculture) (T4) @ 20.000/ha. The shrimp and fish were fed with farm made feed consisting of a mixture of fishmeal 29%, MOC 15%, rice bran 30%, soybean meal 16%, wheat flour 9% and vitamin premix 0.1%. The average final weight of shrimp was 24.9±1.13g, 23.41±3.26g and 26.67±1.89g that stocked with tilapia in treatments T1, T2, and T3 respectively. The final average weight of shrimp in monoculture (T4) was 27.41±0.76g, apparently higher but insignificant in treatments. The survival of shrimp was 42.17%, 32.38%, 39.45% and 61.98% in treatments T1 T2, T3 and T4 respectively. The production of shrimp in concurrent culture was 193.67, 154.26 and 210.41kg/ha in T1, T2 and T3, respectively, while in monoculture (T4) was 339.77 kg/ha. The growth and survival of tilapia among the treatments was insignificant. The growth of monosex tilapia ranged 225.29 and 291.31g and survival 62.77 and 72.20% in T1 and T2, respectively, in mixed sex was 193.0g and 83.20% (T3). The production of tilapia monosex strains was 1676.69kg/ha (Strain-2 all male) and 1668.98 kg/ha (Strain-1 all male) while that of Strain-3 mixed sex population was 1622.92 kg/ha.

Effects of different levels of energy and protein sources on the growth performance, feeding, survival rate and the chemical body composition of juvenile Pacific white shrimp (Litopenaeus vannamei)

The present study was carried out in order to establish an economical effective diet for the pacific white shrimp in the southern part conditions of Iran. With the consideration of three dietary energy levels (E1=262, E2=312, E3=362 kcal 100 g-1 diet) and six ratios of fish meal (FM) to soybean meal (SBM) [(P1=100%FM+0%SBM, P2=80%FM+20%SBM, P3=60%FM+40%SBM, P4=40%FM+60%SBM, P5=20%FM+80%SBM, P6=0%FM+100%SBM)], 18 experimental diets (with 36% crude protein) were prepared. Completely randomized design was used to assign 54 polyethylene 300 litre round tanks provided by aeration and flow through water system and was stocked by 19 juvenile as 3 replicates to each treatment. Shrimps average weight was about 0.77 grams at the start. After 56 days culture period, maximum growth and nutritional performances were observed in the P6E1 treatment (containing 100% soybean meal and 262 kcal 100 g-1 diet) and P5E1 treatment (containing 80% soybean meal and 262 kcal 100 g-1 diet). Also the highest survival rate of the shrimps was observed in the P1E1, P1E2, P3E3 and P5E3 treatments. Additionally interactive effect of different protein ratios and energy levels had significant difference on body protein, fat, fiber and ash contents (P<0.05). Results of the present study suggest the possibility replacement of at least 80% of dietary fish meal by soybean meal in the diet of pacific white shrimp in the conditions of southern part of Iran.