己酸乙酯酯化真菌筛选及发酵条件研究

本文主要研究了具有己酸乙酯酯化活性的真菌菌株的筛选和发酵条件优化。从大曲和糟醅样品中分离纯化获得79株产生透明圈的丝状真菌，菌落形态初步识别结果显示分离菌株包括红曲霉属、根霉属及曲霉属等菌株。其中菌株EM-56酯化酶活力最强，发酵获得的粗酶制剂酶活为172.36 u。根据显微形态、菌落形态及生理生化特征，初步鉴定该菌株为曲霉科红曲霉属紫色红曲霉（Monascus purpureus）。 在此基础上重点研究了菌株EM-56在不同培养基成分及不同培养条件下的产酶情况，确定了最佳培养基和培养条件。通过单因素实验确定在基础培养基中添加最佳碳源为葡萄糖，最佳氮源为蛋白胨。正交优化实验结果确定了最佳培养基组成：以麸皮为基础培养基，添加葡萄糖 2%，蛋白胨 0.3 %，KH2PO4.3H2O 0.05 %，MgSO4.7H2O 0.06 %。菌株EM-56在上述培养基中的最佳发酵条件为：初始pH 5.5，发酵温度为35°C，发酵时间7d，种龄48h，接种量8%，装瓶量50g / 瓶（500mL）。在最佳培养基和发酵条件下，菌株EM-56发酵获得的粗酶制剂酶活达到241.56 u，比优化前提高了40.15%。 In this paper, the research focuses on the selection of fungus with esterifying activity and optimization of fermentation conditions. We isolated 79 strains which had transparent zones from Daqu and fermented grains. The isolated strains contained Monascus、Rhizopus and Aspergillus through primary morphology analysis. The strain of EM-56 which produces strongest esterase was selected. The enzyme activity reached 172.36u. According to related literature, EM-56 was identified as Monascus purpureus through morphology analysis and biochemical determination. We also studied the effects of different medium and fermentation conditions on the esterase production of strain EM-56. The optimal medium and fermentation conditions were determined. Single factor experiment result shows that the optimal carbon source added is glucose and the optimal nitrogen source added is peptone. The optimal fermentation medium determined by orthogonal optimization test is as follows: wheat bran as substrate, glucose 2%, peptone 0.3%, KH2PO4.3H2O 0.05%，MgSO4.7H2O 0.06%. The optimal fermentation conditions are: initial pH 5.5, cultural temperature 35°C, cultural time 7d, seed age 48h, inoculation 8%, medium mass 50g / flask（500mL）. The esterse activity of EM-56 cultivated in the optimal medium and fermentation conditions reached 241.56u and increased by 40.15% compared with the original activity.